a. Die. b. Adopter. c. Melt pump (If applicable) d. Screen changer. e. Screw and cleaned it properly. f. Cyclone. g. Hopper. h. Clean the barrel properly. i. Prepare a support below the barrel and loose all the bolts of feeder sleeve and shift the barrel atleast 2 feet from the gear box. j. Take out the dowel pins of output flange of MGB then, loose all the bolts of output flange. k. Gently take out the output flange by using chain pulley block, so that it will not damage shaft surface. l. Take out both the oil seals from the flange. m. Check for any groove formation over the shaft surface and also check, previously the oil seal position shifted or not. If there is no problem in shaft surface then, we can place both the seal in the flange else measure the distance and prepare a seem in order to shift the position of oil seals. n. Then apply grease OKS 424 in between oil seal (within the V shape after fitment of oil seals in the flange) o. Now properly clean the surface of gear box where flange need to be mount. p. Apply sealant Make- Fevicol 191 over the surface. q. Now gently put the flange and tight it properly. r. Then put all the things in sequence.