Professional Documents
Culture Documents
TAP Interface
Report Summary
User Behaviour
Application Risks & Usage
Web Risks & Usage
Intrusion attacks
Note:
The SAR can also be generated by existing users of Cyberoam, who have deployed the appliance in
one of the in-line modes: Route Mode, Bridge Mode or Mixed Mode. The SAR for in-line modes gives
visibility into risks averted by Cyberoam and potential risks, if any, prevailing within the network, which
can be addressed by configuring Cyberoam more effectively.
Prerequisite
Scenario
Connect One (1) interface of Cyberoam to the network switch through which all network traffic passes.
Configuration
This article contains Two (2) sections which have instructions to:
-
Connect one end of the straight-through cable into Port A of the Appliance and the other end into
the Ethernet Adapter port of the Network Switch.
Change the IP address of the LAN computer from which you wish to access Cyberoam
(Management Computer) to 172.16.16.2 and the subnet mask to 255.255.255.0.
In the Management Computer, open a web browser and browse to https://172.16.16.16. Logon to
the Cyberoam Web Admin Console using default username "admin" and password "admin".
Connect another cable between an unbound Cyberoam port and a port on the Network Switch on
which you will configure Port Mirroring (refer step 3).
Logon to CLI Console via Telnet or SSH. You can also access the CLI Console by clicking
on the upper right corner of the Web Admin Console screen.
Logon to iView Web Admin Console. You can logon using one of the following ways:
a. Logon to Cyberoam Web Admin Console and either go to Logs & Reports > View Reports
or click
.
b. Log on to Reports from Cyberoam Web Admin Console login page.
Go to System > Configuration > Report Notification and click Add to add a Report Notification.
On the Add Report Notification screen select Security Assessment Report and fill in details as
shown below.