Professional Documents
Culture Documents
Tutorial Lesson 2 - Connection Joints: Mechanism Design Ii - (Be2 - Wildfire3)
Tutorial Lesson 2 - Connection Joints: Mechanism Design Ii - (Be2 - Wildfire3)
** In this exercise, you will create the above Engine mechanism assembly. This assembly contains
multiple components with multiple joint connections. To begin, you will need to create a new assembly
and assemble the Block_Bottom part. **
Page 5
** The next component to be assembled is the Crank Shaft. Since the Block_Bottom is our ground, the
remaining components in this assembly will have joint connections. The Crank Shaft will utilize a Pin
connection with the Block_Bottom. **
** The following 2 images display the proper references for the Pin joint creation: **
Page 6
Page 7
** Once completed, the Crank_Shaft will only be allowed to rotate about Axis A-1. Your assembly should
look like the following image. **
Page 8
** The next component to assemble is the Connecting Rod. This component will also use a Pin joint. **
** The following 2 images display the proper references for the Pin joint creation: **
Page 9