Professional Documents
Culture Documents
Unigraphics General Interview Questions PDF
Unigraphics General Interview Questions PDF
1.
2.
4.
Continuity describes the behavior of surfaces and curves at their segment boundaries
Gn& Cn
5.
6.
When creating a new feature,the vertices or edges of that feature may not touch the vertices or
edges of the solid body
14. How to remove parameters of a model and retrieve it back?
EditFeatureRemove Parameters
15.
16.
17.
18.
19.
20.
14. What is Degree of Freedom? How many degree of freedom will be there for a mechanical
object?
Explain the following:
1.Product life cycle management (PLM)
2.Team centre
3.Master model concept
4.I-MAN5.Grip
6.Interoperate
7.Examine geometry
8.Global Shaping
9.Part cleanup
10.Quick stack
11.Knowledge fusion
12.WAVE
13.Promotion of bodies
14.Cloning
15.Zone
16.Envelope
17.Component filter
Sheets to Solid Assistant produces solids from sets of unsewn sheet bodies
25.Quality checks of model in Unigraphics
26.What is law curve?
you may continue to undo changes until the expression list is in its original state when you started
working on expressions
29.How many colors are there in UG?
216
30.How is tube shown in model tree?
The Heal Geometry application exports the work part to another NX part to perform any required
healing operations on the selected solid bodies. As a result, after healing completes the work part is the
same as before the application starts
33.What is Para Solid?
34.What is direct modeling?
Direct modeling commonly use to edit face and some face feature
35.How do you export the model in STL format?
36.What is Timestamp?
Explain difference between the following with respect to Unigrahics:
1.Class A & Class B surfaces
2.Surface & B-Surface
3.IGES & STEP
4.Orient view & replace view
5.Higher & lower degree curves/surfaces
6.Cubic & quintic
7.Spline and Spine
8.Curve and String
9.Face blend & edge blend
10.Sheet from curve & bonded plane
11.Sew & quilt
12.N sided surface & Bonded plane and Sheet from curves
13.Through curves & ruled
14.Swept and Through curve mesh
15.Cylinder & Boss
16.Through point & through poles
17.Top down and Bottom up assembly
18.Wave link & Promotion
19.Mate & align
20.Instance & transform
21.Trim & patch
22.Blank & suppress & layer
23.Fixed datum plane & relative datum plane
24.Define mating alternatives and verify mating alternatives
25.Simple instance & identical instance & general instance
26.Trim & split
27.Simplify & join
28.Intersect & section curve operation
29.Orthographic view & auxiliary view
30.Geometric tolerances & dimensional tolerances
31.Work part & displayed part
32.Flatness & parallelism
33.Architectural feet inches & engineering feet inches
34.Offset & Extrude
35.Drafting and Detailing