Submitted by : ANKIT SAROHA (00714807814) SANDEEP KR. PAL (0031480814) PAWAN BAINSLA (30114807814) BRANCH- EEE456
The whole arrangement is placed in a wheel
using foam plaster so the it sticks on both sides the wheel is attached to 6mm shaft and 1000RPM metal gare motor.
I arranged the LEDs on a separate PCB and
connected them to the pinheads and an eight pin female connector is used to connect the 8 LEDs to connect to PORT0 of AT89S52. I used the KIEL software to program the microcontroller. i prefer to work with C rather than assembly. I am using a USB based programmer to burn the AT89S52 MCU.