Professional Documents
Culture Documents
Full Wave Rectifier: A Project Report
Full Wave Rectifier: A Project Report
A Project Report
Submitted by
Aashray Kotha
CBSE GRADE XII
PHYSICS
2016-17
CERTIFICATE
This is to certify that Aashray Kotha of Grade XII in Nehru Smarka
Vidyalaya Kendra, Bangalore, with registration number has successfully
completed the project in Physics on the topic Full Wave Rectifier in
partial fulfilment of the requirements stated by CBSE in the year 2016-17.
Signature of Principal
ACKNOWLEDGEMENT
Finally, I extend my gratitude to one and all who are directly or indirectly
Aashray Kotha
INDEX
1. AIM
2. ACKNOWLEDGEMENT
3.CERTIFICATE
4.INTRODUCTION
5. MATERIALS REQUIRED
6. CIRCUIT DIAGRAM
7. WORKING
8.BIBLOGRAPHY
AIM
Introduction
A full wave rectifier is a device which is used to rectify
all the alternating current components in an alternating
supply and make it purely a direct current The two
alternating halves of an alternation current are rectified
in a full wave rectifier which is an advantage over a half
wave rectifier. Most electronic devices cannot withstand
very high voltage or alternating current due to its intense
high power. The use of batteries in all devices is not
practical as their replacement and durability is a huge
problem as the device has to be dismantled each time for
such a replacement. So these rectifiers are used in most
of the electronic devices like TVs, Radios, Chargers, and
Lightings etc.
Materials required in
the construction
Connecting wires
A Plug
A Circuit board
A Transformer
A Capacitor
A Resistor (1 K )
An LED
Circuit Diagram
Connection details
Connections are done as in the circuit. The A.C. supply is
given to both the input wires of the transformer and the
two ends of the secondary coil is given to the P side of
the two diodes and the N side of the diodes are twined
and then connected to one en d of the capacitor and the
other end to the centre tap lead and to the resistor.
Further, the other end of capacitor with the diode
connect ion is connected to the other end of
Working
1st when the A.C. is supplied to the transformer, it
steps down the 230V main supply to 6 volts. It has a
capability of delivering a current of 500mA. The 6 volts
C. appearing across the secondary is the RMS value
and the peak value is 8.4 volts. During the 1st
half cycle of the A.C. input Diode D1 is forward biased
and a current I flows in the circuit in the direction
S1D1 ABEOS1. During this time diode D2 is reverse
biased. So it does not conduct any electric current.
During the next half cycle the diodeD2 is forward and
D1 is reversed. Hence D2 conducts current in the
direction S2D2ABEOS2 and D1 does not conduct any
current. In subsequent half cycles of the A.C
current the above processes are repeated. In both
the half cycles it is clear that current flows through
the
resistor in only one direction ABE. Even
thoug
h
it
will
components. This
is
GRAPH
BIBLIOGRAPHY
Physics-Textbook for Class XII ; NCERT
Websites:
www.google.com
www.wikipedia.org
www.ncert.nic.in