Professional Documents
Culture Documents
Date:____________________________ Project:_______________________________
Fixture Type: ______________________ Specifier/Rep:__________________________
Wiring diagrams and electrical connections
The new lighting systems, that use light sources in a LED solid state must be
connected to the main voltage through electronic devices that maintain the critical
parameters of operation constant.
With Leds in particular, the current values that pass through the light source
must remain constant and if necessary measurements are not taken to keep
these parameters constant, the LED will tend to absorb higher currents resulting
overheating triggering a vicious mortal cycle of the semiconductor. Because of
this physical-electric phenomenon the systems with LED technology need very
sophisticated control devices compared to the traditional sources.
The current control can be integrated into the power supply or can be placed between
the power supply and the LED system. In this case the Led connection should be
done in series with a maximum quantity of 10/12 Led that can be connected
In the most evolved systems the control electronic can be split and integrated
directly on the PCB together with the Leds; here the connection can be done in
parallel with a 24V dc power supply and without any limit of the quantity of Leds
that can be connected
To facilitate the user in consulting this catalog, in this section there is a list of all
the diagrams of connection between control gears , interfaces and power supplies,
as well as the combination of the correct power supplies / control gear and lighting
systems showing the article codes.
Important note:
Suggested maximum distance from driver: 30ft (using 18 AWG solid copper wire)
Disclaimer: Distances, type of wiring and gauge must be determined by a certified professional to avoid voltage drop problem.
Serial connection
Parallel connection
30 Tycos Drive, Toronto, Ontario, Canada M6B 1V9 PH: 800.388.3382 / 416.247.9221 FAX: 416.247.9319, www.zaneen.com tech@zaneen.com
Date:____________________________ Project:_______________________________
Fixture Type: ______________________ Specifier/Rep:__________________________
DMX OUT
DMX Controller
DMX IN
IN
Power supply
DMX OUT
DMX IN
DMX OUT
LED
LED
LED
LED
LED
LED
RGB
RGB
RGB
RGB
RGB
RGB
OUT
+
-
ECO.0054.99
ECO.0048.99 *
30 Tycos Drive, Toronto, Ontario, Canada M6B 1V9 PH: 800.388.3382 / 416.247.9221 FAX: 416.247.9319, www.zaneen.com tech@zaneen.com