SIMULATION OF RIGID RECTANGULAR COLUMN HIT THE WALL.
1. problem description and modeling analysis:
Problem: A rectangular column, a length of 10mm, width 5mm, height of 50 mm, with an initial speed of 300 mm/ms vertical velocity impact rigid wall plane, as shown in Figure ".1. Deformation test analysis rectangular column
Fig: 1 Model Dimension drawing (mm)
Calculation of rectangular column material model uses TANTALUM, create a complete 3D model calculations. When the modeling is constrained at one end in contact with a rigid rectangular column inner wall plane degrees of freedom for all nodes, the simulation of rigid rectangular column hit the wall. 2 AUTODYN modeling analysis procedure: 2.1 in Lagrange analysis process: Step 1: Determine the output folder Step 2: Set the name and work units Step 3: Select a symmetrical manner Step 4: Defining materials Step 5: Define initial conditions
Step 6: The definition of the boundary conditions
Step 7: Creating the choice of algorithms and models Step 8:Boundary conditions Step 9: Solution Control Step 10: Output Settings Step 11 : Start calculation run up to now Lagrange completed
Euler method Euler method (Euler) when analyzed, the first four-step process of analysis and modeling Lagrangian method is the same for this step from the beginning of this section describes the fifth.