2. Choose the type of testing and type of indenter 3. Install pawl, bush, selected indenter and locking hood in position 4. Press key on computer panel. After a few second the MAIN MENU appears on display 5. Press
key to display the program lists
6. Select program from SELECT GROUP heading by pressing
key and then press VICKERS
key . Choose ROCKWELL, BRINELL or
7. Select test category from TEST SCALE heading by pressing
key and then press on type of material)
or
or
key. Choose HRA, HRB or HRC (depend
8. Position the sample to be tested
9. Press in sometimes start
button and keep it pressed until the beginning of the countdown for the predefined time of permanence of the load.
10.Wait for the indenter to return to its initial position
On main switch, make sure the pump button is in auto position
Place sample in position Push the holder and lock the speciment tigh Close the cover Switch on the light Hold and push button start Slowly cut the sample Caution ! Do not put to much pressure 8. Press stop button 9. Open the cover 10. Swith off light and main power
INSTRUCTIONS PROCEDURE MOUNTING PRESS MACHINE 1. On main switch at the back 2. Make sure the pressure is 80 psi
3. Put the sample on ram in position
4. Press down button 5. Close the sample (put bayonet closure) 6. Press run button 7. Holding pocess on going 8. Complete auto stop 9. Press down button to release pressure 10. Turn the wheel anticlockwise (unscrew bayonet closure) 11. Hold the cover (bayonet closure), press up button balance pressure in the machine and take out the sample Caution ! Hot sample 12. Switch off the machine