MARINE
PROPULSION
ENGINE
‘TURBOCHARGED-AFTERCOOLED
‘SHOWN WITH ACCESSORY EQUIPMENT
1.001 | 1:00:1
295 | 2001
aze1 | 2081
reoucrion | 3601 | 2561
| “ranios | 4001 | «00:1
| aso1 | cera
65.1
sant
5.881
V8, ¢ STROKE-CYCLE DIESEL
BORE—in (mm)
STROKE in (mm)
DISPLACEMENT cu in (ier)
ROTATION trom fiywhee! end)
6.251159)
5.00 203)
1,984 (322)
Clockwise or Counterclockwise
ENGINE WEIGHT, Nat Dry (appraximate)—ib (ka)
Sei
Jacket Water Attercooled (WAC)
te Circuit Atercooled (SCAC)
11.775 6340)
111648 (6287)
TRANSMISSION WEIGHT Not Dry (appraximate)—to (ka)
"7251 (weight varies with gear rato}
78
5:206-5,855 (2401-2655)
‘1500 (2041)
Note: Caterpillar Marine Engines and Teansmissions are approved for certification by the
following marine classification societies: ABS. BV, CBSI, Dav. GL. LA. NK, RNa.
STANDARD EQUIPMENT
AirIntake System:
AirCleener Adapters
AirCleaner Service Indicators
Single Stage Ory AitCioaners
Controls
ByaresMetnaniesl Governor
Gooling System:
oolant Expansion Tank
Sooiant Pump
Soolant Thermostats
[be Oii Cooler
NoneSelltPriming Fresh Water Pump
(SCAC— keel cooled)
‘seltPriming Sea Water Pump
{SCAG Heat exchanger cooled)
Exhaust System:
Watercoolte Exhaust Manifolds
(continuous rating ony)
wstercooled turbocharger Shield
uel Sytem:
Fuel Erming Pump
Fuel Transfer Pum
inetrumonts and Gauges:
Instrument Panelithien Gauges
Ske Standard Dual tachometer Orie
Tabscating System:
mergeney Connections
Ube Bit Ehter
Lube Oil Pump
Manual Sump Pump
Mounting System:
Liting Eyes!
Mounting als
Power Takeott:
Flywheel Housing, SAE No, 00
Front Accessory Brive
Protection Devices:
Manual Shutet Control
Shutotts~Oil Pressure and Coolant
"Temperature Contactors, Intake
Manifold Temperature Contactor
(Scag)
ACCESSORY EQUIPMENT*
Control system
Engine mounted
Piottouse
‘Cooling System
Emergency Coolant Connections
fea Bhangere
shauat System?
Mut
Fuel System:
Double Wall Fue! Lines
Duplex Fuel Fier
Pleible Fuel ines
Instruments and Gaug
Exnaust Pyrometer and Thermocouples
Pilot House Panels
Tachometer.
Lubricating
Duplex Lube Sr ners
Marine Tranemissions:
Gat 7241, 7251
Emergency Lubs Oil Connections
Trolingvave
Mounting System:
Sound lsblation Mounting
Power Takeota:
‘Auxillary Drive Pulleys,
Front enclosed Cluteh
Prot
ABS"av Dav GL, LA, NK, LNA
Approved Pats Kiergieand
Starting Syetoms:
arsiating
Bavary Chargers
Battery Set
Charging Aternators(24,90:32V)
Etoctrie Starting (24, 30-82V)
Glow Plugs
“Consult your Caterpillar Dealer
{or additonal aecessory equipment.RATINGS: SEPARATE CIRCUTT
‘om he kW.
RATE CIRCUIT, ACKET waTER
AFTERCOOLED HOF" ‘AETERCOOLED
wm hp kW fom hp kw
‘halt Power 125 [v5 aes 362
om om US. gph new
FuetRate 1 1235 301087
136 iio Yea
+000 jaw go Goa
‘300 sooty 83
‘catorpiar Goaier vs 54308
rom US. goh inerh aaeaeeeen: tom _U8. gph iitewh
rom hea
mm, eae
= om Rs
gee
a Gt
Shalt Power e463
US. gph iter
Fuel Rate ape 1387
get ioe?
as ‘a
fot cog
85% (30°C) water toatorcoter.
OHO el wate oaereooe
RATING DEFINITIONS
Continuous: For heavy-duty service where the engine is oper-
‘ted at rated load and speed without interruption or load
eyeling,
Medium-Duty Commercial For service where engine load and
‘speed are constant with some cycling. Full power operation is,
limited to four hour periods followed by one hour at continuous
‘power levels and below. Synonymous with “maximum continu-
us" ratings used by marine classification societies.
Light-Duty Commercial: For service where engine load and
speed are cyclical. Full power operation is limited to one hour
‘eriods followed by one hour at continuous power levels and
below.
RATING CONDITIONS
Ratings are based on SAE J816 standard conditions of 29.38 in
Hg (99.2 KPa) and 85°F (30°C). These ratings also apply at DIN
6270 standard conditions of 978 kPa (28.87 In Hg) and 20°C
(er)
‘Shaft power represents power requirements ofa typical fixed
pitch propeller and 87 percent of gross engine horsepower.
Fuel rates are based on power requirements of atypical tixed
pitch propeller and fuel oil having an HAV of 19,690 Bulb
(45570 uika) and weighing 7076 US. gal enone liter).
Sorewmact sic) Sarge) Sat ete)
Materials and specications are subject To change wihout notice
ens 7.7)
Stowe aniecn
Print in USA