Professional Documents
Culture Documents
Chief Architect Tutorial
Chief Architect Tutorial
Lets assume I want only the porch to carry the gable then I will use the break
wall tool to break the long exterior wall at the joint of the room and porch and
the porch and bath
To break the points, simply select BUILD, WALL, BREAK WALL as shown
below and click the two points
After selecting the two points, you
should have a single wall now.
NOTE: The Gable roof process above is if you want only a portion of the exterior wall
to carry the gable (just the porch as in the case above). If you want the whole front
to carry the gable just double click on it then select full gable.
TO CREATE POP
Make Room
Molding Polyline
button
When the exterior room is selected, click on the Make Room Molding
Polyline button shown above.
Specify the desired Height of the molding from ground in the Make Room
Molding Polyline dialog box. 600mm is selected in this case as shown
below
Click OK.
Note that the moulding polyline is already selected dont click anything
Now with the newly created moulding