Professional Documents
Culture Documents
[ 3 points ]
STP
.
PVST
.
BPDU
.
Q 1 :
1234-
[ 4 points ]
d
e
show NVRAM
show version
10.
What could be the effect of duplicate unicast frames arriving at
a destination device due to multiple active alternative physical
paths?
a Frame collisions increase.
b Application protocols malfunction.
c The number of broadcast domains increases.
d The number of collision domains increases.
11.
Which three components are combined to form a bridge ID?
a extended system ID
b MAC address
c bridge priority
d port ID
e IP address
f Cost
12.
Which STP port role is adopted by a switch port if there is no
other port with a lower cost to the root bridge?
a designated port
b alternate
c root port
d disabled port
13.
What is an advantage of PVST+?
a PVST+ optimizes performance on the network through load sharing.
b PVST+ requires fewer CPU cycles for all the switches in the network.
c PVST+ reduces bandwidth consumption compared to traditional
implementations of STP that use CST.
d PVST+ optimizes performance on the network through autoselection of
the root bridge.
14.
Which STP priority configuration would ensure that a switch
would always be the root switch?
a spanning-tree vlan 10 priority 61440
b spanning-tree vlan 10 priority 0
c spanning-tree vlan 10 root primary
d spanning-tree vlan 10 priority 4096
15.
Which two network design features require Spanning Tree
Protocol (STP) to ensure correct network operation? (Choose two.)
a static default routes
b implementing VLANs to contain broadcasts
c link-state dynamic routing that provides redundant routes
d redundant links between Layer 2 switches
e removing single points of failure with multiple Layer 2 switches
16.
What value determines the root bridge when all switches
connected by trunk links have default STP configurations?
a VLAN ID
b extended system ID
c MAC address
d bridge priority
Q 3 :
Define the root switch, root ports, Designated ports and nonDesignated ports.
[ 5 points ]