Cebex 100
eae
ws, consiruetive solutions
L,
Expanding and Plasticising grout admixture
Uses
Cebex 100 is an admixture lor site batched cementitious
‘grout where @ reduced watericament rato and positive
‘expansion Is tequired. Applications include bed grouting,
dust grouting, non-shrink inilling and ointng.
Advantages
1 Geseous expansion system compensates for plastic
shrinkage end settement in property cesigned
comenttious grout
1 Reduced watorfcoment rate in the grout mix onsuros
Tow permeability and lang term durabilty in service
@ Gives high grout Muidity with low waterfoement rato,
thus making placement or injection of the grout easy
No meteliciron cantent to corrode end ccuse staining
or daterioretion due to rust expansion in the grout
Composition alows high early strength development
in grouts, without te use of chiorides,
Standards compliance
Cebex 1001s a sutabe pre-stressing groul admixture
whan complying with BS 8110 Part 1.1936,
Section 89.4.6
Description
Gebex 100s supplied 2s a power acimixture. The
material is a combination of a plasiiising agent and a
gas producing expansion mecium. The plasticising egent
allows the use of reduces water/cement rato wth
‘consequent inereaced strangths and curablity. The
exparsive medium counteracts the natural selUement
and piaste shrinkage of the grout and aids stability and
cohesion.
Sufficient restrained expansion is developed to ensure
a high degree of interiacial contact.
Properties
Chloride content: Nilo BS 6075
Compressive
strength:
‘The Plasticising action in Gebex 100
lows reduction ol the waier/eoment
allo of cameniiicus yrouts whilst
mainizining flow properties, This
gives improvement in strength and
Tong term durabilly when cured
lunar restrain:
Setting times:
Gebax 100 does not signincerily
affect the selling times of coment
based grauts
‘The controlled positive expansion in
Lnset grouts incarperating Cebex
100 overcomes plastiz seivement
when measured in accordance with
ASTM C827. An unvestreined
expansicn of up to 4% is typical
Time for
expansion: 15 minutesto 2 hours. Temperatures
above 20°C may slightly reduce
those times
Compatibiliy: Cobex 100 is compatible with all
types of Poriand cement,
Cebex 100 may be used in mixes
containing certain other Fosroc
admictures. Consulted Fosroc for
forthor information
‘Specification clauses
‘Supplier specification
AT grouting (specify details and areas cf application) must
be carried oul usirg a cement based groul, incorporating
Cabex 100 manufactured by Fosroc, applied strictly in
aecandance wilh the manufacturers teemicel dete sheet.
Instructions for use
Mixing
Forbest resus a mecrantcally gowered grout mixer must
be used, For quaniiios upto 50kg a slow speed dill ited
with @ Conbextra mixing peddle 's suitable. Larger
‘quantities wil require a high shear vane micer.Itis
cseential that machina mixing capacity and labour
avallabliy Is adequate to enable te grouting operation
to be earied cut continuously, This may require the use
fa holding tank wih provision for genlle agitation to
mainiain fluidity.
‘The selected water conten! should ba accurately mea.
sured into the rixer Slowly acd the cement {and send
if required) and Cedex 100. Mix continuously or 6 minutes,
‘mating sure thal a errosth even consistency is obtained,Cebex 100
Application
‘Areasto be grouled shouldbe preparedioensure _substates
4ar2 clean, sound, and then pre-wetted. The unresianed surtace
area of the groul must be kept to 9 minimum. Prace the grout
within 20 minutes of mixing to. gain the full banefitof the
‘xparsion procass. Adopt usual placing or purbing procedures
‘ensuring a continuous oporaticn.
Curing
On compiation o' the grouting operation, any exposed reas
lwhich are net to bo cut back shoul be thoroughly cured by
neans of waxer application, concure during membrane or wet
hessian
Cleaning
Gcouts mixad with Cobox 190 should be removed from teols
and equipment with éean water immediate after use.
Ramove cured material mechanically or with Fosroc Acid
Eich
Limitations
Cebex 100 is incompatible wil Hig Alumina Cement.
Estimating
Packaging
‘Cedex 100 ic euppied in 20 kg pall
Important note
ior
PT, Fosroc
Indonesia
4 sas Ink AB No.
Dette Sion nut Park
telephone
Lingo Cikarena $6221 897 2103
Bess te60 +62 22520 1300,
#6231 5029142
www.fosroc.com
Fate pets ae fuarnoc opps cote masa snr
40222 622 2713
sexsi
Dosage
‘OPC Conereting -Wator —-—Conkex Approx
Sand 400__yiele
50kg = ato 22iires 225g d6lires
SOK) S0kg ZU ZA llves 225g __—ST lives
Note: Far grout, mortar or concrete mixes with an aggre-
sgatefooment ralio more than 1, use 4 x 225 g of Cebex.
100 per 100 ka of cement
Effacte of overdosing
Diastic overcasing of Cebex 100 increases expansion,
and may cause frothing,
Storage
Cebex 100 has a shat ife of 12 months if keptin @ cry
store ints original packaging. High temperature and
humidity storage may reduce this period.
Precautions
Health and Safety
‘han mixing grouts with Gehex 100, avoid inhalaton of
dust and contac! with skin and eyes. Wear suitable
protective olothing, gloves, oye protection and rospiratary
protective equipmant. The use of barrier creams provide
adcitionel skin pretection. In case of contact with ekin
rinse with plenty of clean wale, hen cleanse wilh sca
ano weter. In case of contact with eyes, rinse immediately
vith plenty of clean water and seak medical advize. IF
swallowed, seak medical attention immediately - do not
Induce vorniing
For further information see Product Safety Data Sheet
Codex is the treda mark of Fosroc International Limited
fa ros jet so
837 2107 eonesia@tosios.com
Fo ss0tmac