Professional Documents
Culture Documents
Findind Workbench Tutorial On Geometry
Findind Workbench Tutorial On Geometry
To get to
this, OPEN WORKBENCH, the select NEW GEOMETRY to start the
DESIGN_MODELER_8.1. Then select HELP from the menu at the top. Read from
the beginning and about 5 windows in (the arrows) you will be at this page. Here is the
menu location of this tutorial. If you work through this example, you will use all the
tools you need to make holes or cut off corners etc from your extruded parts.
This tutorial makes the holes by extruding them from the beginning. To make holes after
the fact, see below.
See that two cylinders that were extruded from the XY plane into the Z direction by 12
inches were removed. When I hit generate, the cylinders that were here disappeared,
along with the holes in the pipe. If the cylinders had been longer (into the negative Z
side), I would have clearance holes through the pipe.