Professional Documents
Culture Documents
Website:http://biz.LGservice.com
COLOR MONITOR
SERVICE MANUAL
CHASSIS NO. : LM 84B
MODEL: W2252TQ(W2252TQ-PFT.K***A**)
( ) **Same model for Service
CAUTION
BEFORE SERVICING THE UNIT,
READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
CONTENTS
SPECIFICATIONS ................................................... 2 ADJUSTMENT ...................................................... 13
PRECAUTIONS ....................................................... 4 TROUBLESHOOTING GUIDE .............................. 15
TIMING CHART ....................................................... 8
EXPLODED VIEW...................................................19
DISASSEMBLY ........................................................ 9
BLOCK DIAGRAM ................................................. 10 SCHEMATIC DIAGRAM ..........................................20
DESCRIPTION OF BLOCK DIAGRAM...................11
SPECIFICATIONS
1. LCD CHARACTERISTICS 4. MAX. RESOLUTION
Type : TFT Color LCD Module Analog : 1680 x 1050@60Hz
Active Display Area : 22 inch diagonal Digital : 1680 x 1050@60Hz
Pixel Pitch : 0.282(H) x 0.282 (V)
Size : 493.7(H) x 320.1(V) x 16.5(D) 5. POWER SUPPLY
Color Depth : 16.7M colors 5-1. Power Adaptor(Built-in Power)
Electrical Interface : LVDS Input : AC 100-240V~, 50/60Hz, 1.0A
Surface Treatment : AG(Haze 25%), Hard Coating(3H)
Operating Mode : Normally White 5-2. Power Consumption
Backlight Unit : 4 CCFL
MODE H/V SYNC VIDEO POWER CONSUMPTION LED COLOR
2. OPTICAL CHARACTERISTICS less than 45 W(max)
2-1. Viewing Angle by Contrast Ratio 5 POWER ON (NORMAL) ON/ON ACTIVE BLUE
less than 40 W(typ)
Left : +80 min., +88(Typ) Right : -80 min., -88(Typ) STAND BY OFF/ON OFF less than 1 W AMBER
Top : +80 min., +85(Typ) Bottom : -80 min., -85(Typ) SUSPEND ON/OFF OFF less than 1 W AMBER
2-2. Luminance : 180(Typ) (Typ. 10)-sRGB DPMS OFF OFF/OFF OFF less than 1 W AMBER
: 220(min), 300(Typ)-6500K POWER S/W OFF - - less than 1 W OFF
: 150(min)-9300K
AC Volt-meter
TAKE CARE DURING HANDLING THE LCD MODULE
WITH BACKLIGHT UNIT.
Must mount the module using mounting holes arranged
in four corners. Good Earth Ground
such as WATER PIPE,
Do not press on the panel, edge of the frame strongly CONDUIT etc.
To Instrument's
or electric shock as this will result in damage to the exposed
screen. METALLIC PARTS
CAUTION
Please use only a plastic screwdriver to protect yourself
from shock hazard during service operation.
Video
B
C
Sync
D E F
A
CLASSI Polarity DOT Frequency Total Display Front Sync. Back Resolution
MODE FICATION CLOCK [kHz]/ [Hz] Period (A) Porch (C) Porch
[MHz] (E) (D) (B)
1. Put a cushion or soft cloth on a flat surface. 3. Slide the Cable Deco Cover out from the stand body.
2. Place the monitor face down on the cushion or soft cloth.
4. Press the hook,Take off the stand base from stand body. 5. Please pull the stand body lightly to separate it from the hinge body.
7. Pull the front cover upward,then separate all the latches. 8. Place the monitor face down,then disassemble back cover.
-9 -
Copyright
TSUMO58CWHJ 1680X1050@60Hz
146Mhz
LVDS
Display Response
Processing Time
Panel
LVDS
Engine Enhancement Interface
D-Sub
Module
EEPROM Interface
3.3V DRAM
(EDID) Engine
DVI-D
EEPROM 1.8V
KEY
(EDID)
SDA
/SCL
- 10 -
Crystal
LIPS EEPROM Flash ROM
(System) 14.318MHz
BLOCK DIAGRAM
3.3V 3.3V
5V
3.3V
Filter 15V 5V Regulator 1.8V
15V
Inverter(4Lamps)
2. Power Part.
This part consists of the one 3.3V, and one 1.8V regulators to convert power which is provided 5V in Power board.
15V is provided for inverter in W2252TQ.
Also, 5V is converted 3.3V and 1.8V by regulator. Converted power is provided for IC in the main board.
The inverter converts from DC 15V to AC 700Vrms and operates back-light lamps of module in W2252TQ.
3. MICOM Part.
This part is include video controller part. And this part consists of EEPROM IC , control data, Reset IC and the Micom.
The Micom distinguishes polarity and frequency of the H/V sync are supplied from signal cable.
The controlled data of each modes is stored in EEPROM.
15V
50 ~ 60Hz
PRIMARY SECONDARY
Operation description_Power
1. EMI components.
This part contains of EMI components to comply with global marketing EMI standards like FCC,VCCI CISPR, the
circuit included a line-filter, across line capacitor and of course the primary protection fuse.
3. Energy Transfer.
This part function is for transfer the primary energy to secondary through a power transformer.
5. Photo-Coupler isolation.
This part function is to feed back the DC output changing status through a photo transistor to primary controller to
achieve the stabilized DC output voltage.
6. Signal collection.
This part function is to collect the any change from the DC output and feed back to the primary through photo
transistor.
1. Port Setup
a) Copy UserPort.sys file to
c:\WINNT\system32\drivers folder
b) Run Userport.exe
2) Wait for about 5 seconds and press MENU, POWER switch for 1 second interval.
3) The SVC OSD menu contains additional menus that the User OSD menu as described below.
IBM 9 6
Video Signal 5 1
Compatible PC 15 11
Generator 10 6
5 1
C
PARALLEL PORT
d
13 1
se
tu
25 14
2C
No
23
OFF ON
RS
5V
F
L
Control Line
LE
C
RAL
PA
4.7K
220
VG
Power Select Switch ON 4.7K
R
5V
WE
S
(110V/220V) E
PO
74LS06
A MO Power LED
T
4.7K
CS
NI OFF
TO
YN
R
V-S
74LS06
E ST Switch
B
B
F V-Sync On/Off Switch
(Switch must be ON.)
NO POWER
(POWER INDICATOR OFF)
YES
YES
NO
4
1 CHECK U501 PIN127 CHECK CRYSTAL(X501)
PULSE
YES
CHECK U501
Waveforms
1 P704-#5,6 2 IC703-#2 3 IC702-#2 4 U501-#127
NO RASTER
(OSD IS NOT DISPLAYED)
CHECK P704 NO
CHECK POWER BOARD
1 VOLTAGE PIN5,6 (LIPS)
(5V)?
YES
YES
1. CONFIRM BRIGHTNESS
NO
OSD CONTRL STATUS
3 CHECK P704
2. CHECK MICOM DIM-ADJ
PIN10
PORT
YES
CHECK
PULSE AS
CONTACTING PROBE NO
4 POWER BOARD (LIPS)
TO THE LAMP
WIRE OF THE
LCD MODULE
Waveforms
YES
1 P704-#5,6 2 P704-#9
NO RASTER
(OSD IS NOT DISPLAYED)
YES
YES
CHECK U501
PIN32(H-SYNC) AND NO
PIN33(V-SYNC). CHECK CONNECTION LINE
IS PULSE APPEARED AT FROM D-SUB TO U501
SIGNAL PINS?
YES
TROUBLE IN CABLE
OR LCD MODULE
Waveforms
1 U501-#127
TROUBLE IN DPM
YES
1 CHECK NO
U501 PIN 32,33 CHECK H/V SYNC LINE
2 SYNC PULSE
YES
TROUBLE IN U501
Waveforms
1 H-SYNC 2 V-SYNC
520
530 420
400
410
430
540 500
900
510
910
920
930
SCHEMATIC DIAGRAM
1. SCALER
LED