You are on page 1of 2

Instructions

Follow the instructions carefully.

Step 1 :
Install Samsung Drivers and connect your device to PC. let it
install drivers and if its updating let it update. your device
drivers should be perfectly installed without a single failure.

Link to Samsung Drivers

Step 2 :
Download Odin 3 you can use 3.07 or 3.09

You can download Odin from here

Download the TWRP Recovery

Step 3:
Turn of your device and go to odin mode [ Vol down + power
+ home button (all at the same time) ] release it when you
see Galaxy E5 Logo

Press vol up to confirm

Step 4:
Now that you are in Odin Mode connect your device via USB
cable.

Now open Odin3 3.09 or 3.07 that you have downloaded.

If there is a pop-up like Installing ADB drivers let it get


finished it usually updates.

Make sure the COM : xx (xx is usb port number it can be any
number so dont worry about it,just verify COM is lit up)
Now select AP and browse to where you have .tar file and
select it

Make Sure only Default Auto Reboot and F. Reset Time is


ticked and nothing.verify twice only these 2 are ticked.
Untick Auto Reboot if you are installing recovery for first
time!

Click Start and wait for the process to end. DO NOT Interrupt
during this time.

Once it says PASS. BOOT INTO RECOVERY USING VOL UP +


HOME + POWER BUTTON.

Done.

Installation
1. Make sure you have updated to stock 5.1.1
2. Download the ROM from the link below
3. Download 6.0.1 ARM GAPPS
4. Transfer the zip files to your SD card
5. Reboot to recovery mode ( Vol UP + Home + Power )
Note: It is highly recommended to use TWRP recovery
6. Optional: Do nandroid backup
7. Wipe data / Factory Reset
Note: Needed if you are updating from other andorid version or stock
8. Install CM zip and GApps zip
9. Reboot to system
10. And setup ur device [/COLOR]
Enjoy!

You might also like