D20-96 26
WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADI
PRECAUTION" AND “PRODUCT SAFETY NOTICE” ON PAGE 2 OF THIS MAN
CAUTION: The international hazard symbols “A\" intheschematic diagramandt
which have special characteristics important for safety and should be replacec
inthe original circuit or specified in the parts list. The mounting position of re
‘originals. Before replacing any of these components, ead carefully the PRODU
not degrade the safety ofthe receiver through improper servicing,SCHEMATIC DIAGRAM
D THE “X-RAY RADIATION PRECAUTION", “SAFETY
PAGE 2 OF THIS MANUAL,
‘hematic diagram and the partslist designatecomponents
Ind should be replaced only with types identical to those
‘ounting position of replacements is to be identical with
idcarefully the PRODUCT SAFETY NOTICE on page 2. D0
"servicing,
NOTE:
1. RESISTOR
2. CAPACITOR
3. The parts indicated with = 2
MODEL : CF27F30 Chassis No
Resistance is shown in ohm [K = 1.000, M = 1.000.000). A,
Fesistor, unless otherwise noted as the following marks.
‘U2R = Metal or Metal oxide of 172 watt Was = C
ARF = Fuse resistor of 1 watt 10W * C
K= 210% G= 42% F* 21%
Unless otherwise noted in schematic, all capacitor values |
more than Tin pF
All capacitors are ceramic S0V, unless otherwise noted «
IK Electolytic capacitor 54} Mylar cap
hhave special characteristics, and sho
1030 Chassis No. TAC9620 CL29F30 Chassis No. TAC9620
100, M = 1.000.000), All resistors are 1/6W and 5% tolerance carbon
the following marks.
watt “U2S = Carbon compsistion of 1/2 watt
‘OW = Cement of 10 watt
+ all eapacitor values less than 1 are expressed inf, and the values
299 otherwise noted @s the following marks.
Syb— Mylar capacitor
‘aracteristies, and should be replaced with identical parts only.
4, Voltages read with DIGITAL MULTI-METER from point indicate
at normal, line voltage 120 volts.
8, Waveforms are taken receiving color bar signal with enou
6. Voltage reading shown are nominal values and may varyTER from point indicated to chassis ground, using a color bar signal with all controls
bar signal with enough sensitivity
values and may vary 20% except H.V.UNIT PB6461 -1
MAT