Section Views:
‘Section Waves Te used to show te Intenor features of complex parts. Orawings having a section view will
‘show the cufting plane line In fhe appropriate adjacent view.
tf 14 Zz
-
- 1 Z
q 1 t
z
Foi Secnon- Frost View Foi Secnox- Tor View Fou Secnow- Sime View
“These mules apply to the oreation of section views.
1, Crossnatoned areas are to be Dounded by coject ines.
2. Use the srose-haiching patier for cast ran. All Ines are thin and parallel. The spacing should be
‘consistent,
3 thes are to be tt phantom ines —long Ines separate by two 18 Jong aches art
Sra Ae aamce She axing pane ln sould tend sprcnanay fe" 1 od he ven
apencng on De stun.
} eae
ie
‘Varies thom ~ tid to 122
b
ingen lines are omitted trom section views,
”
‘Visite 20ges and contours nehind the cuting peane line should be shown.
(Conrours BERND
ARE aor
6 Centertines used for dimensioning can extend off of cuting plane lines passing Ewough the center of
odes, etc,AYN |
7
=
7 |
Working Drawings:
‘Agel f working crag: coca an ecemay craving 2 a et, a al crawgg fea ren
‘standard part When poBsbe the pars ist Wil appeaT on Te assemby rating. The pans in me assembly
‘ili teyedio ie ar tatears sary fe pa ure, attached fo te parts wth leaders. The
drawings wil have 3 balloon containing the part number which corresponds to the parts st and
Sseenby mur,Threaded Features:
‘The slrmpified method of thread representaiion shall be used on drawings. Thread notes for holes shall
ncaude te tap oF size ani gepin, the proper
‘Tread note and the depth or tread. Thread notes tor
threaded rods shall Include the fread note and the length of thread.
ene
TrPicaL THREanes Roo
4,558
131
Bi4— 10UNC-23
ae
Nomen.
TREAD
DANETER e
THREADSIN HOLES ARE USSLALLY || | Tecan
Woo JP nae Tl piu DE ae om
REQUIRED EMBEONENT OF THE rill ae Dra.
FASTENER. THE TAP ORILL DEPT yu Deets
|e THEN 3P LONGER THAN THE Tar Drew. i |
THREAD OFT. DAMETER JS
{P= ne wRean eres
OF THREADING)
For fweads created In a part, we wil use the folowing table to find the minimum engagement to prevent pull
‘out of he steel Tactener. Dis the nominal dkameter of te:
Minimum Thread
Part Mtenat
Engagement
Steet D
Gaairon
‘Brass ano
Brome
AuTIAU,
an 20
Pistic