This document provides instructions for adjusting the valves on a 3408E engine. It lists the valve clearance specifications for intake and exhaust valves. It outlines the procedure for adjusting each valve, which includes ensuring the engine is at top dead center on cylinder 1, adjusting specified intake and exhaust valves, tightening the adjustment screws, rotating the flywheel, and adjusting the remaining valves. It also notes transmission performance test parameters like idle speeds and oil pump pressures.
This document provides instructions for adjusting the valves on a 3408E engine. It lists the valve clearance specifications for intake and exhaust valves. It outlines the procedure for adjusting each valve, which includes ensuring the engine is at top dead center on cylinder 1, adjusting specified intake and exhaust valves, tightening the adjustment screws, rotating the flywheel, and adjusting the remaining valves. It also notes transmission performance test parameters like idle speeds and oil pump pressures.
This document provides instructions for adjusting the valves on a 3408E engine. It lists the valve clearance specifications for intake and exhaust valves. It outlines the procedure for adjusting each valve, which includes ensuring the engine is at top dead center on cylinder 1, adjusting specified intake and exhaust valves, tightening the adjustment screws, rotating the flywheel, and adjusting the remaining valves. It also notes transmission performance test parameters like idle speeds and oil pump pressures.
BEFORE AFTER BEFORE AFTER 1 COMPRESSION 1 2 5 7 7 12 1 3 4 8 2 EXHAUST 3 4 6 8 10 11 2 5 6 7 3 4 SATUAN DALAM MM 5 7 5 3 1
6 7 8
8 6 4 2
CYLINDER AND VALVE VALVE LOCATION ( 3408 E )
1 SET EXHAUST VALVE TO 0.76 mm OR 0.30 IN
2 SET INTAKE VALVE TO 0.38 mm OR 0.15" 3 ENSURE CYLINDER ONE ( 1 ) IS IN THE TOP DEAD CENTER COMPRESION STROKE VALVES THAT ON BE ADJUSTED ARE 4 Adjust Valve Lash Intake : 1-3-4-6-7 and 12 Atur clearance Intake : 1-3-4-6-7 and 12 5 Adjust Valve Lash Exhaust : 1-4-5-8-9 and 12 Atur clearance Intake : 1-4-5-8-9 and 12 6 Tighten Valve Adjustment screw to 30 +/-4 N.m ( 22 +/- 3 lb ft ) ( Kencangkan Valve adjustment screw sampai 30 +/- 4 N.m ( 22 +/- 3lb ft ) 7 Remove timing bolt ----> Turn fly wheel 360 degress Lepas timing bolt lalu putar fkywheel 360 derajat sesuai arah putaran engine 8 Adjust valve lash intake : 2-5-8-9-10 and 11 Atur clearance intake : 2-5-8-9-10 and 11 9 Adjust Valve lash exhaust : 2-3-6-7-10 and 11 Atur clearance exhaust : 2-3-6-7-10 and 11 10 Tighten Valve Adjustment screw to 30 +/-4 N.m ( 22 +/- 3 lb ft ) Kencangkan Valve adjusment screw sampai 30 + /- 4 N.m ( 22 +/- 3lb ft ) 11 Remove timing bolt from the flywheel when all adjustment to valve last had been made Transmision performance test