anor -arve EleretInernal Forces
Frame Element Internal Forces
‘The frame element intemal forces are:
=P, the axial force
= V2, the shear foree in the 1-2 plane
= V3, the shear force in the 1-3 plane
= T the axial torque (about the ‘-axis)
‘= M2, the bending moment in the 1-3 plane (about the 2-axis)
‘= M3, the bending moment in the 1-2 plane (about the 3-axis)
‘These intemal forces and moments are present at every cross section along the length of the frame element,
For each load case and load combination, the frame element intemal forces and moments are computed and reported at
each frame element output station.
In frame element output displayed in a tabular form, either on the computer screen, printed to a printer or printed to a file,
the locations of the output stations are identified by the absolute distance to the station measured from the i-end of the
element.
Frame Element Sign Convention
‘The sign convention for frame element internal forces is illustrated in the figure below. This sign convention can be
described by defining the concept of positive and negative faces of an element. Consider a section cut through the element
in the 2-3 plane, At this section, the positive 1 face is the face whose outward normal (arrow that is perpendicular to the
section and pointing away from the section) is in the positive local 1 direction. At this same section, the negative one face
is one whose outward normal is in the negative local 1 direction, The positive 2 and 3 faces are those faces with outward
normals in the positive local 2 and 3 directions, respectively, from the neutral axis. Note the following about the frame
element intemal forces:
61
0 AG OE,
ive Aula once and Tor
["
conpreasios ate ~ waist
2 aniea™ wise
ane Ou .
al “a
ne i 8
iD sues ‘ rd
» avs ae
Ena ns
ve | Seasie se ei
_ Eusiive Moment ons Shesrin he 1-2 Plane ¢. Positve Wementand Shsarin the 13 Plane
hipsldocs csiamerica.com/holpflsieabs/Octput_Convertions/Frame,Elomen_Irirral Forces im 42anor
-arve EleretInernal Forces
Positive internal forces (P, V2 and V3) and positive axial torque (T) acting on a positive 1 face are oriented in the
positive direction of the corresponding element local coordinate axis. For example, when V2 acting on a positive 1
face is positive, itis oriented in the direction of the positive local 2-axis.
Positive internal forces (P, V2 and V3) and positive axial torque (T) acting on a negative 4 face are oriented in the
negative direction of the corresponding element local coordinate axis, For example, when V2 acting on a negative 1
face is positive, it is oriented in the direction of the negative local 2-axis,
Positive M2 bending moments cause compression on the positive 3 face and tension on the negative 3 face.
Positive M3 bending moments cause compression on the positive 2 face and tension on the negative 2 face,
When end offsets along the length of the frame element are present, the intemal forces and moments are outout at
the faces of the supports rather than the ends of the element. No output is produced within the end offset length.
‘The right-hand rule applies in the figure for determining t
sense of the moments shown by the double arrows.
hipsldocs csiamerica.com/holpflsieabs/Octput_Convertions/Frame,Elomen_Irirral Forces im
22