Professional Documents
Culture Documents
Battery Replacement:
1. Push the small button at the battery door to open the battery compartment.
2. Change the batteries.
3. A 9 Volt Alkaline battery is recommended for best performance but in this
experiment we use 4 AA Alkaline batteries.
Operation:
1. Set up the tripod stand.
2. Switch on the SLM by pressing ON/OFF/ESC button and attach the SLM to the
tripod stand. At any time, other than initial turn-on, if the LOBAT indicator is
displayed, the user must replace the battery. (Refer battery replacement.)
3. Skip the calibration step.
4. Select VIEW SESSION and select F (FAST).
5. Start recording by pressing the RUN/PAUSE button.
6. After getting the reading for 1 hour, once again press the RUN/PAUSE.
7. To save the data recorded, press the STOP button and hold it for 3 seconds.
8. Press the ESC button and it will redirect to the main menu.
9. Repeat step 4 to 7 if you want to save new set of data.
10.Turn off the SLM by pressing ON/OFF/ESC button and hold it for few seconds.