Professional Documents
Culture Documents
7.2.2.4 Packet Tracer - Configuring Basic EIGRP With IPv4 Instructions PDF
7.2.2.4 Packet Tracer - Configuring Basic EIGRP With IPv4 Instructions PDF
Topology
Addressing Table
Objectives
Part 1: Configure EIGRP
Part 2: Verify EIGRP Routing
2013 Cisco and/or its affiliates. All rights reserved. This document is Cisco Public. Page 1 of 3
Packet Tracer Configuring Basic EIGRP with IPv4
Background
In this activity, you will implement basic EIGRP configurations including network commands, passive interfaces
and disabling automatic summarization. You will then verify your EIGRP configuration using a variety of show
commands and testing end-to-end connectivity.
b. On each router, configure EIGRP to advertise the specific directly connected subnets. The configuration
for R1 is shown.
R1(config-router)# network 172.16.1.0 0.0.0.255
R1(config-router)# network 172.16.3.0 0.0.0.3
R1(config-router)# network 192.168.10.4 0.0.0.3
2013 Cisco and/or its affiliates. All rights reserved. This document is Cisco Public. Page 2 of 3
Packet Tracer Configuring Basic EIGRP with IPv4
2013 Cisco and/or its affiliates. All rights reserved. This document is Cisco Public. Page 3 of 3