Professional Documents
Culture Documents
Application For Ocib
Application For Ocib
Effective on January 01, 2010, the revised rules show some significant changes to requirements
with regard to fees. Please review the following sections and apply them to your current
procedures:
Section 4781-7-09 (Q) (1) A permit shall not be valid until all fees as set forth in paragraph (A)
of this Rule have been paid. Nor shall an amendment to a permit be released until the additional
fee, if any has been paid. On manufactured homes, electrical, gas, mechanical and plumbing
system installation fees for each permit type shall be paid in accordance with the schedule of the
commission and/or the authority having jurisdiction.
Section 4781-7-09 (Q) (2) If the installation of a manufactured home has commenced or been
completed prior to the application of a permit by the authority having jurisdiction, the authority
having jurisdiction may assess an additional fee not to exceed the actual cost to determine
compliance and in no case shall exceed one and onehalf times the permit fee and inspection fees.
A mandatory late permit charge of $50.00 must be paid to the Ohio Manufactured Homes
Commission at the time of permit issuance. This shall be paid by a separate payment and
the check must be made payable to Treasure State of Ohio.
Please see attached form that must be used in conjunction with the collection of the $50.00
late permit charge.
Ohio Manufactured Homes Commission
5100 Parkcenter Avenue, Suite 103, Dublin, Ohio 43017
A mandatory late permit charge of $50.00 must be paid to the Ohio Manufactured
Homes Commission at the time of permit issuance, this shall be paid by a separate
payment and the check must be made payable to: Treasurer State of Ohio
This form must be completed upon receipt of the $50.00 late permit charge and mailed
to: Ohio Manufactured Homes Commission
5100 Parkcenter Avenue, Suite 103
Dublin, Ohio 43017
________________________________________________________________
Address of manufactured home City Zip code
________________________________________________________________
Owners name Installers name
________________________________________________________________
Payees name Contact Phone #
________________________________________________________________
Permitting agency
________________________________________________________________
Permit number Permit date Seal number
Pier Layout
Where required:
Zoning Certificate
Flood Plain (county engineer or surveyor)
Ohio Certified Inspection Bureau
6566 S. St. Rt. 78
Glouster, OH 45732
Dispatcher: 740-541-1292
FAX: 740-767-4797
THIRD PARTY MANUFACTURED HOME INSPECTION FEES
The basic fee includes plan review, one footer inspection, one
electrical service inspection including temporary release of meter,
one final inspection and the State of Ohio Inspection Seal
______________________________________________*County_______________________
Final Inspection
____________________________________________________________________________
*APPLICANT: Specify if you are the: (circle appropriate answer)
ELECTRICAL for MANUFACTURED HOME (Inspections will include only the work
performed on-
site.)
*Service installed on: (circle appropriate answer) HOME POLE
*Service size: _____________________ (100 amp/200 amp)
*Wire size:_______________________
Please note: Installer is responsible to install light bulbs and fixtures PRIOR to calling for the
final. All homes, including used homes, must have OPERABLE SMOKE DETECTORS.
OXIDE COMPOUND NEEDED ON ALUMINUM WIRE
2 GROUND RODS NEEDED AT OUTSIDE DISCONNECT (6 FT. APART
CONNECTED TOGETHER)
4 wire feeders-(are required to be protected)
PERMANENT FOUNDATION
For purposes of this rule, a permanent foundation shall:
Have a continuous masonry perimeter wall, either load bearing or a non-load bearing wall;
Have footings that are either below the frost line or protected from frost heave;
Tongue wheels, axles, and hitches shall be removed from under the manufactured
home; and Conform to Chapter 4781-6 of the Administrative Code;
For the purpose of this rule, stable foundation shall:
1. Not require a footing below grade but must be protected from frost heave; We, the home-
owners, accept and understand the responsibility of a stable foundation in lieu of permanent
foundation.
I hereby certify that I am the owner of the named property, or that the proposed work is
authorized by the owner of record and that I have been authorized by the owner to make this
application as his/her authorized agent and I agree to conform to all applicable laws of the
jurisdiction. In addition, if a permit for work described in this application is issued, I certify
that the code official or the code officials authorized representative shall have the authority
to enter areas covered by such permit at any reasonable hour to enforcethe provisions of this
code(s) applicable to such permit.
*Printed Name
*****************************************************************************