At the Institute of Training in Manufacture and Automation several workshops
are taught such as PLC, Robotics, Arduino, Control of motors, frequency
inverters and pneumatic the latter being one of the most recent to join the list. During the stay it was observed that the area of pneumatics did not have enough material, which presented a big problem because the engineers who took the course would not cover their needs at the time of practice, for this reason, it was decided to implement a new pneumatic bench and in turn to optimize it, allowing in this way to attend practices in less time and with better quality. The project was carried out by conducting an activity analysis to determine the time it would take to develop the project, also allowed to know that activities needed more time. To meet the expectations of optimizing the time it takes engineers to perform their practices, It was proposed to the institution the implementation of Electrical boards with clems, this allows to have a greater number of people working on the same pneumatic board. The board layout was designed in SolidWorks software and presented to the engineer in charge of the area for its previous revision. The result obtained with this type of boards was satisfactory because it was fulfilled with the objectives proposed at the beginning of the project