Professional Documents
Culture Documents
R930 Do not used with High Voltage hot shoe AUTO Mode:
flash.
ISM 2400MHz 1 . Top button
In this mode . the triggers transfer
Note: this manual is for firmware 3.0, would be Battery: 2 . Function LED
signal as they are. just as the flash set
updated with the firmware updated in the future. 3 .Side button
directly on the camera.
4 AAA battery are required to 4 . Power Switch
Version 03 function this trigger. When Updating 5 . 2.5mm Output Port
To set this mode. press the side button
Date: June.2 2015 Firmware, Only fresh Alkaline and 6 . Firmware Update Port
long. When the LED 4 blink. Then short
Zinc-carbon are well. 7 . Hot shoe(Transmitter only)
press the side button to switch between
acon 8 . Battery Compartment
Auto->Manual ->Remote->(undefined)
Features & Functions: Parts: 9 . Locking Ring
mode. When LED 4 is green, long press
1
0. Hot Shoe Adaptor the side key, to confirm using the auto
P-ttl High Speed Sync mode - 11. Front LED transfer mode.
1/8000s capable.
Second Curtain Sync mode Prepare Connection: After entering the set mode (led 4 blink),
Wired and wireless shutter release the top button is used to switch between
functions All equipment should be turn OFF when several setting. but for firmware 3.0.
Power adjust mode making connections. user only use the led 4. Please make
2.4G ISM bandwith sure that led 4 blink but not LED 1,2,3.
firmware upgradable The powering up sequence is essential
signal strength indicated for this trigger. Manual power mode: