You are on page 1of 56

BA_U1_MS_210_230_250_01.fm Seite 0 Donnerstag, 11.

Dezember 2003 11:06 11

STIH)

STIHL 026 Instruction Manual

Warning!
To reduce the risk of kickback injury use
STIHL reduced kickback bar and STIHL PM 1
(3/8" Picco) or RM 2 (0,325") chain depending
on sprocket or other available low kickback
components.

Read and follow all safety precautions in


Instruction Manual improper use can cause
serious or fatal injury.

Schwarz Proze 45,0 120,0 LPI


,PSRUWDQW6DIHW\3UHFDXWLRQVIRU&KDLQ6DZ8VHUV

$.LFNEDFN6DIHW\3UHFDXWLRQV take several steps to keep your 6. Follow manufacturers


cutting jobs free from accident or sharpening and maintenance
:DUQLQJ injury. instructions for the saw chain.
Kickback may occur when the nose
1. With a basic understanding of 7. Only use replacement bars and
or tip of the guide bar touches an
kickback, you can reduce or eli- chains specified by the manu-
object, or when the wood closes in
minate the element of surprise. facturer or the equivalent.
and pinches the saw chain in the
Sudden surprise contributes to
cut. Tip contact in some cases may
accidents. 8. Reduced kickback bars and low
cause a lightning fast reverse
kickback chains are designed
reaction, kicking the guide bar up
2. Keep a good firm grip on the to reduce the risk of kickback
and back towards the operator.
saw with both hands, the right injury. Ask your STIHL dealer
Pinching the saw chain along the
hand on the rear handle, about these devices.
top of the guide bar may push the
and the left hand on the front
guide bar rapidly back towards the
handle, when the engine is run- %2WKHU6DIHW\3UHFDXWLRQV
operator. Either of these reactions
ning. Use a firm grip with
may cause you to lose control of the
thumbs and fingers encircling 1. Do QRW operate a chainsaw with
saw which could result in serious
the chainsaw handles. one hand! Serious injury to the
personal injury.
A firm grip will help you reduce operator, helpers, bystanders,
kickback and maintain control or any combination of these
Section 5.12 of ANSI B 175.1-1991
of the saw. persons may result from one-
sets certain performance and
Dont let go. handed operation. A chainsaw
design criteria related to chainsaw
is intended to be used with two
kickback. STIHL has developed a
3. Make sure the area in which you hands.
color code system using green and
are cutting is free from obstruc-
yellow to help you select a power-
tions. Do not let the nose of the 2. Do not operate a chainsaw when
head, bar and chain combination
guide bar contact a log, branch, you are fatigued.
that complies with the kickback
or any other obstruction while
requirements of the ANSI Standard.
you are operating the saw. 3. Use safety footwear; snug-fitting
See the sections entitled "Safety
clothing; protective gloves; and
Precautions" and "Specifications"
4. Cut at high engine speeds. eye, hearing, and head protect-
of this manual.
ion devices.
5. Do not overreach or cut above
Do not rely exclusively upon the
shoulder height.
safety devices built into your saw.
As a chainsaw user, you should
continued on the back inside cover
&RQWHQWV

Main Parts of the Saw 2 Electric Handle Heating* 38 This Manual contains operating and
Definitions 3 Take Care of Guide Bar 38 safety instructions for all STIHL 026
Safety Precautions 4 Checking and Replacing series power saws.
The Operator 4 Chain Sprocket 39 Pay special attention to the safety
The Saw 6 Adjusting Carburetor 40 precautions outlined on pages 4 to 22.
The Use of the Saw 6 Motor management 40 Allow only persons who understand this
Maintenance, Checking Spark Plug 41 Manual to operate your chain saw.
Repair and Storing 23 Replacing Starter Rope
Mounting the Bar and Chain 25 and Rewind Spring 42 To receive maximum performance and
Tensioning the Saw Chain 26 Maintaining and Sharpening satisfaction from your STIHL chain saw,
Checking chain tension 26 Saw Chain 44 it is important that you read and under-
Fuel Mix 27 Maintenance Chart 47 stand the maintenance and safety
Fueling 27 Specifications 48 precautions before using your saw.
Chain lubricant 28 Ordering Spare Parts 49 Contact your STIHL dealer or the
Fill chain Oil Tank 28 Storing the Machine 49 STIHL distributor for your area if you do
Chain Brake 29 STIHL Incorporated Federal Emission not understand any of the instructions in
Information Before You Start 30 Control Warranty Statement 50 this Manual.
Starting the Saw 31
Checking Chain Lubrication
Oil Quantity Control
34
34
:DUQLQJ
During Break- in Period 35 Because a chain saw is a high-speed
During Operation 35 wood-cutting tool, some special safety
After Finishing Work 35 precautions must be observed as with
Spark Arresting Screen in Muffler 36 any other power saw to reduce the risk of
Air Filter System 36 personal injury. Careless or improper use
Winter Operation 37 may cause serious or even fatal injury.

STIHLs philosophy is to continually


improve all of its products. As a result,
engineering changes and improvements
are made from time-to-time.
If the operating characteristics or the
appearance of your saw differ from
those described in this Manual,
please contact your STIHL dealer for
Printed on chlorine-free paper informations and assistance.

2000 Andreas Stihl AG & Co., Waiblingen *(optional extra)


0458 133 3021. M8. E0. PM. Printed in USA

 
0DLQ3DUWVRIWKH6DZ

1= Twist lock
2= Spark plug boot
3= Handle heating switch
4= Chain sprocket cover
5= Chain sprocket
6= Chain brake
2 7= Chain catcher
1 8= Side chain tensioner
9= Bumper spike
10 = Guide bar
6 9 11 = Oilomatic saw chain
3
5 8 10
4 11

145BA025 KN
7

12 = Oil filler cap


13 = Muffler
14 = Front hand guard
15 15 = Front handle (handlebar)
14 16 = Decompression valve
17 = Starter grip
16 18 = Fuel filler cap
19 = Master Control lever
17 20 = Throttle trigger
21 = Throttle trigger interlock
13 21 22 = Rear handle
23 = Rear hand guard
19
22
20
12 18 23
145BA026 K

 
'HILQLWLRQV

 &DUEXUHWRU%R[&RYHU7ZLVW/RFN  2LORPDWLF6DZ&KDLQ  7KURWWOH7ULJJHU,QWHUORFN


Lock for carburetor box cover. A loop consisting of cutters, Must be depressed before the
tie straps and drive links. throttle trigger can be activated.
 6SDUN3OXJ%RRW
Connects the spark plug with the  2LO)LOOHU&DS  5HDU+DQGOH
ignition wire. For closing the oil tank. The support handle for the right
hand, located at or toward the
 +DQGOH+HDWLQJ6ZLWFK  0XIIOHU rear of the saw.
For switching the electric handle Reduces engine exhaust noise and
heating on and off directs the exhaust gases.  5HDU+DQG*XDUG
Gives added protection to
 &KDLQ6SURFNHW&RYHU  )URQW+DQG*XDUG operators right hand.
Covers the clutch and the sprocket. Provides protection against
projecting branches and helps *XLGH%DU1RVH
 &KDLQ6SURFNHW prevent left hand from The exposed end of the guide bar.
The toothed wheel that drives the touching the chain if it slips off (not illustrated, see chapter
saw chain. the handle bar. "Tensioning the Saw Chain".

 &KDLQ%UDNH  )URQW+DQGOH &OXWFK


A device to stop the rotation of the Handle bar for the left hand at Couples engine to chain sprocket
chain if activated in a kickback front of saw. when engine is accelerated beyond
situation by the operators hand or idle speed.
by inertia.  'HFRPSUHVVLRQ9DOYH (not illustrated).
Makes starting easier
 &KDLQ&DWFKHU $QWL9LEUDWLRQ6\VWHP
Helps to reduce the risk of operator  6WDUWHU*ULS The anti-vibration system includes
contact by a chain when it breaks The grip of the starter, for starting a number of buffers designed to
or comes off the bar. the engine. reduce the transmission of vibrations
created by the engine and
 &KDLQ7HQVLRQHU  )XHO)LOOHU&DS cutting attachment to the
Permits precise adjustment of chain For closing the fuel tank. operators hands. (not illustrated).
tension.
 0DVWHU&RQWURO/HYHU
 %XPSHU6SLNH Lever for choke control,
Toothed stop for holding saw steady starting throttle, run and
against wood. stop switch position.

 *XLGH%DU  7KURWWOH7ULJJHU


Supports and guides the saw chain. Controls the speed of the engine.

 
6DIHW\3UHFDXWLRQV

The use of any chainsaw Have your STIHL dealer show you how Safe use of a chainsaw involves
may be hazardous. to operate your chainsaw. Observe all
The saw chain has many applicable local safety regulations, 1. the operator
sharp cutters. If the standards and ordinances. 2. the saw
cutters contact your flesh, 3. the use of the saw.
they will cut you, even if the chain is not
moving. At full throttle, the chain speed :DUQLQJ
can reach 45 mph (20 m/s). It is impor- Minors should never be allowed to use a 7+(23(5$725
tant that you read, fully understand chainsaw. Bystanders, especially
and observe the following safety precau- children, and animals should not be 3K\VLFDO&RQGLWLRQ
tions and warnings. Read the Owners allowed in the area where a chainsaw is
Manual DQG the safety instructions in use. Never let the saw run unattended. You must be in good physical condition
periodically. Store it in a locked place away from and mental health and not under the
children and empty the fuel tank before influence of any substance (drugs,
Pay special attention to the section on storing for longer than a few days. alcohol) which might impair vision,
reactive forces. dexterity or judgment.
Do not lend or rent your

:DUQLQJ chainsaw without the


Owners Manual. Be sure
Do not operate a chainsaw when you are
fatigued. Be alert If you get tired while
Reactive forces, including kickback, can that anyone using your operating your chainsaw, take a break.
be dangerous. Careless or improper use saw reads and under- Tiredness may result in loss of control.
of any chainsaw may cause serious or stands the information contained in this Working with any chainsaw can be
fatal injury. manual. strenuous. If you have any condition that
might be aggravated by strenuous work,
All safety precautions that are generally These safety precautions and warnings check with your doctor before operating
observed when working with an ax or a apply to the use of all STIHL chainsaws. a chainsaw.
hand saw also apply to the operation of Different models may have different
chainsaws. However, because a chain-
saw is a high-speed, fast-cutting power
parts and controls. See the appropriate
section of your Owners Manual for a :DUQLQJ
tool, special safety precautions must be description of the controls and function Prolonged use of chainsaws (or other
observed to reduce the risk of personal of the parts of your model saw. machines) exposing the operator to
injury. vibrations may produce whitefinger
disease (Raynauds phenomenon) or
carpal tunnel syndrome. These conditions


reduce the hands ability to feel and Keep the saw chain sharp and the Clothing must be sturdy
regulate temperature, produce numb- saw, including the AV system, well and snug-fitting, but allow
ness and burning sensations and may maintained. A dull chain will in- complete freedom of
cause nerve and circulation damage and crease cutting time, and pressing a movement. Avoid loose-
tissue necrosis. dull chain through wood will in- fitting jackets, scarfs,
crease the vibrations transmitted to neckties, jewelry, flared or cuffed pants,
All factors which contribute to whitefinger your hands. A saw with loose com- unconfined long hair or anything that
disease are not known, but cold weather, ponents or with damaged or worn could become entangled with the saw or
smoking and diseases or physical condi- AV buffers will also tend to have brush. Wear overalls or jeans with a
tions that affect blood vessels and blood higher vibration levels. reinforced cut retardant insert or cut
transport, as well as high vibration levels retardant chaps.
and long periods of exposure to vibration Maintain a firm grip at all times, but
are mentioned as factors in the develop- do not squeeze the handles with Protect your hands with
ment of whitefinger disease. In order to constant, excessive pressures. gloves when handling
reduce the risk of whitefinger disease Take frequent breaks. saw and saw chain.
and carpal tunnel syndrome, please Heavyduty, nonslip
note the following: All the above mentioned precautions do gloves improve your grip
not guarantee that you will not sustain and protect your hands.
Many STIHL models are available whitefinger disease or carpal tunnel
with an anti-vibration (AV) system syndrome. Therefore, continual and Good footing is most
designed to reduce the transmission regular users should monitor closely the important in chainsaw
of vibrations created by the engine condition of their hands and fingers. work. Wear sturdy boots
and cutting attachment to the If any of the above symptoms appear, with nonslip soles.
operators hands. An AV system is seek medical advice immediately. Steel-toed safety boots
recommended for those persons are recommended.
using chainsaws on a regular or
sustained basis. 3URSHU&ORWKLQJ To reduce the risk of injury to your eyes
never operate a chainsaw unless
Wear gloves and keep your hands
warm. Heated handles, which are  :DUQLQJ
wearing goggles or properly fitted safety
glasses with adequate top and side
available on most STIHL power- To reduce the risk of injury, the operator protection complying with your national
heads, are recommended for cold should wear proper protective apparel. standard.
weather use.


Wear an approved safety 7+(86(2)7+(6$:
hard hat to protect your
head. Chainsaw noise 7UDQVSRUWLQJWKHFKDLQVDZ
may damage your
hearing. Always wear
sound barriers (ear plugs :DUQLQJ
or ear mufflers) to protect your hearing. Always stop the engine before putting a
Continual and regular users should have chainsaw down or carrying it. Carrying a
their hearing checked regularly. chainsaw with the engine running is
extremely dangerous.

7+(6$: Accidental acceleration of the engine


can cause the chain to rotate. During
Parts of the chainsaw; for illustrations operation, the powerhead muffler and
and definitions of the parts see the the material around it reach extremely

001BA027 L
chapter on Main Parts of Saw. high temperatures. Avoid touching the
hot muffler, you could receive serious


burns.
:DUQLQJ
Never modify a chainsaw in any way. %\KDQGWhen carrying your saw by
Only attachments and parts supplied by hand, the engine must be stopped and The chain guard (scabbard) should be
STIHL or expressly approved by STIHL the saw must be in the proper position. over the chain and the guide bar, which
for use with the specific STIHL saw should point backwards. When carrying
models are authorized. Although certain Grip the front handle and place the your saw, the bar should be behind you.
unauthorized attachments are useable muffler away from the body.
with the STIHL powerhead, their use %\YHKLFOHWhen transporting in a
may, in fact, be extremely dangerous. vehicle, keep chain and bar covered with
the chain guard. Properly secure your
saw to prevent turnover, fuel spillage
and damage to the saw.


3UHSDUDWLRQIRUWKHXVHRIWKHVDZ and thereafter at regular intervals (when- )XHOLQJ,QVWUXFWLRQV
ever the saw is shut off). If the chain
Take off the chain guard and inspect for
safety in operation. For assembly, follow
becomes loose while cutting, shut off the
engine and then tighten. Never try to :DUQLQJ
the procedure described in the chapter tighten the chain while the engine is Fuel your chainsaw in well-ventilated
Mounting the Bar and Chain of your running! areas, outdoors only. Always shut off the
Owners Manual. engine and allow it to cool before refue-
ling. Gasoline vapor pressure may build
STIHL Oilomatic chain, guide bar and )XHOLQJ up inside the gas tank of a two cycle
sprocket must match each other in engine depending on the fuel used, the
gauge and pitch. Your STIHL chainsaw uses an oil-gaso- weather conditions, and the venting
line mixture for fuel (see chapter Fuel system of the tank. In order to reduce
Before replacing any bar and chain, of your Owners Manual). the risk of burns or other personal injury
see the sections on Specifications, from escaping gas vapor and fumes,
remove the fuel filler cap on the STIHL
"Kickback" and the "ANSI B 175.1-1991
chainsaw kickback standard" in this :DUQLQJ product carefully so as to allow any
manual. Gasoline is an extremely flammable fuel. pressure build-up in the tank to release
If spilled or ignited by a spark or other slowly. Never remove fuel filler cap while
engine is running.
 :DUQLQJ
ignition source, it can cause fire and
serious burn injury or property damage.
Proper tension of the chain is extremely Use extreme caution when handling Select bare ground for fueling and move
important. In order to avoid improper gasoline or fuel mix. at least 10 feet (3 m) from fueling spot
setting, the tensioning procedure must before starting the engine. Wipe off any
be followed as described in your manual. Do not smoke or bring spilled fuel before starting your saw, and
Always make sure the hexagonal nut(s) any fire or flame near the check for leakage.
for the sprocket cover is (are) tightened fuel or the chainsaw.
securely after tensioning the chain.
Never start the saw with the sprocket
Note that combustible
fuel vapors may be vented
:DUQLQJ
Check for fuel leakage while refueling
cover loose. Check chain tension once from the fuel system. and during operation. If fuel or oil leakage
more after having tightened the nut(s) is found, do not start or run the engine
until leak is fixed and spilled fuel has
been wiped away. Take care not to get
fuel on your clothing. If this happens,
change your clothing immediately.


 :DUQLQJ
Unit vibrations can cause an improperly
tightened fuel filler cap to loosen or come
off and spill quantities of fuel. In order to
reduce the risk of fuel spillage and fire,
tighten fuel filler cap by hand with as
much force as possible.

The screwdriver end of


the STIHL combination
wrench or other similar
tool can be used as an aid
in tightening slotted fuel
filler caps.

001BA028 L

143BA019 KN
6WDUWLQJ
The chain brake must be engaged when
starting the saw.

:DUQLQJ With the ILUVWPHWKRGthe chainsaw is


started on the ground. Make sure the
The VHFRQGrecommended PHWKRGfor
starting your chainsaw allows you to start
Your chainsaw is a one-person saw. chain brake is engaged (see Chain the saw without placing it on the
Do not allow other persons to be near Brake chapter in your Owners Manual) ground. Make sure the chain brake is
the running chainsaw. Start and operate and place the chainsaw on firm ground engaged, grip the front handle of the
your saw without assistance. For specific or other solid surface in an open area. chainsaw firmly with your left hand.
starting instructions, see the appropriate Maintain good balance and secure Keep your arm on the front handle in a
section of the Owners Manual. Proper footing. locked (straight) position. Hold the rear
starting methods reduce the risk of injury. handle of the saw tightly between your
Do not drop start. This method is very Grip the front handlebar of the saw firmly legs just above the knees. Maintain good
dangerous because you may lose control with your left hand and press down. balance and secure footing. Pull the
of the saw. For saws with a rear handle level with starting grip slowly with your right hand
the ground, put the toe of your right foot until you feel a definite resistance and then
There are two recommended methods into the rear handle and press down. give it a brisk, strong pull.
for starting your chainsaw. With your right hand pull out the starter
grip slowly until you feel a definite
resistance and then give it a brisk,
strong pull.


:DUQLQJ ,PSRUWDQWDGMXVWPHQWV To reduce the risk of serious or fatal

Be sure that the guide bar and chain are :DUQLQJ injury from breathing toxic fumes, never
run the chainsaw indoors or in poorly
clear of you and all other obstructions To reduce the risk of personal injury from ventilated locations. Ensure proper venti-
and objects, including the ground. When loss of control or contact with the lation when working in trenches or other
the engine is started, the engine speed running chain, do not use a saw with confined areas.
with the starting throttle lock engaged incorrect idle adjustment. At correct idle

::DUQLQJ
will be fast enough for the clutch to speed, the chain should not rotate. For
engage the sprocket and, if the chain- directions to adjust idle speed, see the
brake is not activated, turn the chain. appropriate section of your Owners Use of this product (including sharpen-
If the upper quadrant of the tip of the bar Manual. If you cannot set the correct idle ing the saw chain) can generate dust,
touches any object, it may cause kick- speed, have your STIHL dealer check mists and fumes containing chemicals
back to occur (see section on reactive your saw and make proper adjustments known to cause respiratory disease, can-
forces). To reduce this risk, always or repairs. cer, birth defects, or other reproductive
engage the chain brake before starting. harm. If you are unfamiliar with the risks
Never attempt to start the chainsaw After adjusting a chain, start the saw, let associated with the particular dust, mist
when the guide bar is in a cut or kerf. the engine run for a while, then switch or fume at issue, consult your employer,
engine off and recheck chain tension. governmental agencies such as OSHA
 :DUQLQJ
Proper chain tension is very important at
all times.
and NIOSH and other sources on hazar-
dous materials. California and some
When you pull the starter grip, do not other authorities, for instance, have pub-
wrap the starting rope around your :RUNLQJ&RQGLWLRQV lished lists of substances known to cause
hands. Do not allow the grip to snap cancer, reproductive toxicity, etc.
back, but guide the starter rope slowly Operate the chainsaw under good
back to permit the rope to rewind visibility and daylight conditions only. Control dust (such as sawdust), mists

:DUQLQJ
properly. Failure to follow this procedure (such as oli mist from chain lubrication)
may result in injury to hand or fingers and fumes at the source where possible.
and may damage the starter mechanism. Your chainsaw produces In this regard use good work practices
poisonous exhaust fumes and follow the recommendations of
as soon as the combusti- OSHA / NIOSH and occupational and
ble engine is running. trade associations. When the inhalation
These gases (e.g. carbon of toxic dust, mists and fumes cannot be
monoxide) may be colorless and odor-
less.


eliminated, the operator and any by-
standers should always wear a respirator
hot. Dont work alone. Keep within calling
distance of others in case help is :DUQLQJ
approved by NIOSH / MSHA for the type needed. Avoid stumbling on obstacles such as
substance at issue. stumps, roots or rocks and watch out for
Your chainsaw is equipped with a chain holes or ditches. Clear the area where

 catcher. It is designed to reduce the risk you are working. Be extremely cautious
:DUQLQJ of personal injury in the event of a thrown when working on slopes or uneven
Breathing asbestos dust is dangerous or broken chain. From time to time the ground. There is increased danger of
and can cause severe or fatal injury, re- catcher may be damaged or removed. slipping on freshly debarked logs.
spiratory illness or cancer. The use and To reduce the risk of personal injury,
disposal of asbestos containing products
have been strictly regulated by OSHA
do not operate a chainsaw with a
damaged or missing catcher.
:DUQLQJ
and the Environmental Protection Agen- To reduce the risk
cy. Do not cut or disturb asbestos, asbe- Inspect buffers periodically. Replace of serious or fatal
stos containing products (e.g. asbestos damaged, broken or excessively worn injury to the opera-
containing drywall or other construction buffers immediately, since they may tor or bystanders,
products), or products such as pipes result in loss of control of the saw. never use the saw
which are wrapped or covered with asbe- with one hand.
stos insulation. If you have any reason A sponginess in the feel of the saw, You cannot control reactive forces and
to believe that you might be cutting asbe- increased vibration or increased you may lose control of the saw, which
stos, immediately contact your employer bottoming during normal operation can result in the skating or bouncing of
or a local OSHA representative. may indicate damage, breakage or the bar and chain along the limb or log.
excessive wear. Buffers should always
The muffler and other parts of the engine be replaced in sets. If you have any Even for those compact saws designed
(e.g. fins of the cylinder, spark plug) questions as to whether the buffers for use in confined spaces, one-handed
become hot during operation and remain should be replaced, consult your STIHL operation is dangerous because the
hot for a while after stopping the engine. servicing dealer. operator may lose control.
To reduce risk of burns do not touch the
muffler and other parts while they are
:DUQLQJ
Take extreme care in wet and freezing
weather (rain, snow, ice). Put off the
work when the weather is windy, stormy
or rainfall is heavy.


001BA087 L

001BA018 LA
&XWWLQJ,QVWUXFWLRQV
Grip: Always hold the saw firmly with :DUQLQJ
both hands when the engine is running. Never touch a chain with your hand or
Place your left hand on front handle bar any part of your body when the engine is
and your right hand on rear handle and running, even when the chain is not

001BA031 L
throttle trigger. Left-handers should rotating. The chain continues to rotate
follow these instructions too. for a short period after the throttle trigger
is released.
Wrap your fingers tightly around the
handles, keeping the handles cradled :DUQLQJ
between your thumb and forefinger. Do not cut any material other than wood Never work on a ladder, or on any other
With your hands in this position, you can or wooden objects. insecure support. Never use the saw
best oppose and absorb the push, pull Use your chainsaw for cutting only. above shoulder height.
and kickback forces of your saw without It is not designed for prying or shoveling

:DUQLQJ
losing control (see section on reactive away limbs, roots or other objects.
forces). Make sure your chainsaw When sawing, make sure that the saw
handles and grip are in good condition chain does not touch any foreign Never work in a tree unless you have
and free of moisture, pitch, oil or grease. materials such as rocks, fences, nails received specific, professional training
and the like. for such work, are properly secured

 :DUQLQJ Such objects may be flung off, damage


(such as tackle and harness system or a
lift bucket), have both hands free for
Do not operate your chainsaw with the the saw chain or cause the saw to operating the chainsaw in a cramped
starting throttle lock engaged. Cutting kickback. environment and have taken proper
with the starting throttle lock engaged precautions to avoid injury from falling
does not permit the operator proper
control of the saw or chain speed.
:DUQLQJ limbs or branches.
In order to keep control of your saw,
always maintain a firm foothold.


001BA082 KN

001BA093 L
Position the chainsaw in such a way that powerful force used to cut wood can be
your body is clear of the cutting attach- reversed (and work against the opera-
ment whenever the engine is running. tor). If the rotating chain is suddenly
Stand to the left of cut while bucking. stopped by contact with any solid object
like a log or branch or is pinched, the

001BA035 L
Dont put pressure on the saw when reactive forces may occur instantly.
reaching the end of a cut. The pressure These reactive forces may result in loss
may cause the bar and rotating chain to of control which may, in turn, cause
pop out of the cut or kerf, go out of serious or fatal injury. An understanding
control and strike the operator or some of the causes of these reactive forces
other object. If the rotating chain strikes may helpyou avoid loss of control. The reaction of the cutting force of the
some other object, a reactive force may chain causes a rotational force on the
cause the moving chain to strike the The most common reactive forces are chainsaw in the direction opposite to the
operator. kickback, chain movement. This may fling the bar
pushback, up and back in an uncontrolled arc
pull-in. mainly in the plane of the bar. Under
5HDFWLYHIRUFHVLQFOXGLQJNLFNEDFN some cutting circumstances the bar

:DUQLQJ .LFNEDFN
Kickback may occur when
moves towards the operator, who may
suffer severe or fatal injury.
Reactives forces may occur any time the the moving saw chain
chain is rotating. Reactives forces can near the upper quadrant of Kickback may occur when the nose of
be dangerous! In any chainsaw, the the bar nose contacts a the guide bar is pinched unexpectedly,
solid object or is pinched. unintentionally contacts solid material in
the wood or is incorrectly used to begin
a plunge or boring cut.


It may also occur during limbing. a) saws with a displacement of less than angles that may occur in real life cutting
The greater the force of the kickback 3.8 cubic inches situations. Compliance with 5.12 of
reaction, the more difficult it becomes for must, in their original condition, ANSI B 175.1-1991 does not automatic-
the operator to control the saw. Many meet a 45 computer derived ally mean that in a real life kickback the
factors influence the occurrence and kickback angle when equipped with bar and chain will rotate at most 45 .
force of the kickback reaction. These certain cutting attachments.
include chain speed, the speed at which
the bar and chain contact the object, the
and must be equipped with at least
two devices to reduce the risk of :DUQLQJ
angle of contact, the condition of the kickback injury, such as a chain In order for powerheads below 3.8 cubic
chain and other factors. brake, low kickback chain, reduced inch displacement to comply with the
kickback bar, etc. computed kickback angle requirements
The type of bar and saw chain you use of 5.12 of ANSI B 175.1-1991 use only
is an important factor in the occurrence b) saws with a displacement of 3.8 cubic the following cutting attachments:
and force of the kickback reaction. inches and above
Some STIHL bar and chain types are must be equipped with at least one bar and chain combinations listed as
designed to reduce kickback forces. device designed to reduce the risk complying in the Specifications
STIHL recommends the use of reduced of kickback injury such as a chain section of the Owners Manual or
kickback bars and low kickback chains. brake, low kickback chain, reduced other replacement bar and chain
kickback bar, etc. combinations marked in accordance
with the standard for use on the
$16,%FKDLQVDZNLFNEDFN The computer derived angles for saws powerhead or
VWDQGDUG below 3.8 cubic inch displacement are replacement chain designated
measured by applying a computer low kickback saw chain.
Section 5.12 of ANSI standard B 175.1 program to test results from a kickback See the section on "Low kickback saw
1991, sets certain performance and test machine. chain and reduced kickback bars"
design criteria related to chainsaw
kickback.
To comply with section 5.12 of ANSI B :DUQLQJ
175.1-1991: The computer derived angles of 5.12 of
ANSI B 175.1-1991 may bear no rela-
tionship to actual kickback bar rotation


'HYLFHVIRUUHGXFLQJWKHULVNRI
NLFNEDFNLQMXU\ :DUQLQJ
Never operate your chainsaw without a
STIHL recommends the use of the STIHL front hand guard. In a kickback situation
Quickstop chain brake on your power- this guard helps protect your left hand or
head with green labeled reduced kick- other parts of your body. In addition,
back bars and low kickback chains. removal of the hand guard on a saw
equipped with a chain brake will deactivate


the chain brake.
:DUQLQJ
To reduce the risk of injury, stop using
the saw immediately if the chain brake :DUQLQJ
does not function properly. Take the saw No Quickstop or other chain brake
to your local STIHL Service Centre! Do device prevents kickback. These devices
not use the saw until the problem has are designed to reduce the risk of
been rectified (see the section Chain kickback injury, if activated, in certain

001BA036 LA
Brake). kickback situations. In order for the
Quickstop to reduce the risk of kickback
injury, it must be properly maintained
4XLFNVWRSFKDLQEUDNH and in good working order. See the
When a kickback occurs, the guide bar chapter entitled Chain Brake and
STIHL has developed a chain stopping may rotate around the front handle. If the Maintenance, Repair and Storing of
system designed to reduce the risk of cutting position is such that the operators your Owners Manual. In addition, there
injury in certain kickback situations. left hand is gripping the front handle must be enough distance between the
It is called a Quickstop chain brake. behind the hand guard, and if the left bar and the operator to ensure that the
The Quickstop is available as standard hand rotates around the front handle and Quickstop has sufficient time to activate
equipment on your STIHL chainsaw and makes a sufficiently forceful contact with and stop the chain before potential
is available for installation on most older the front hand guard, which is the Quick- contact with the operator.
STIHL saws. Ask your dealer to retrofit stop activating lever, this contact will
your older model saw with a chain brake. activate the Quickstop. The chain brake
on most new model STIHL chainsaws
can also be activated by inertia. See the
chapter entitled Chain Brake of your
Owners Manual.


:DUQLQJ reduce the risk of kickback injury. Other
chains are designed to obtain higher cut-
Please ask your STlHL dealer to properly
match your powerhead with the appro-
An improperly maintained chain brake ting efficiency or sharpening ease but priate bar/chain combinations to reduce
may increase the time needed to stop may result in higher kickback tendency. the risk of kickback injury. Green labeled
the chain after activation, or may not bars and chains are recommended for all
activate at all. STIHL has developed a color code powerheads. See your STIHL Bar and
 :DUQLQJ
system to help you identify the STIHL
reduced kickback bars and low kick-
Chain Information leaflet for details.
Never run the chainsaw above idle
speed for more than 3 seconds when
back chains. Cutting attachments with
green warning decals or green labels on :DUQLQJ
the chain brake is engaged or the chain the packaging are designed to reduce Use of other, non-listed bar/chain combi-
is pinched or otherwise caught in the cut. the risk of kickback injury. The matching nations may increase kickback forces
Clutch slippage can cause excessive of green decaled powerheads under 3.8 and increase the risk of kickback injury.
heat, leading to severe damage of the cubic inch displacement with green New bar/chain combinations may be
motor housing, clutch and oiler compo- labeled bars and green labeled chains developed after publication of this litera-
nent and may interfere with the operation gives compliance with the computed ture, which will, in combination with
of the chain brake. If clutch slippage in kickback angle requirements of ANSI B certain powerheads, comply with 5.12
excess of 3 seconds has occured, allow 175.1-1991 when the products are in of ANSI B 175.1-1991. Check with your
the motor housing to cool before pro- their original condition. Products with STIHL dealer for such combinations.
ceeding and check the operation of your yellow decals or labels are for users with
chain brake as described in the chapter
entitled Chain Brake. Also make sure
extraordinary cutting needs and
experience and specialized training for :DUQLQJ
that the chain is not turning at idle speed dealing with kickback. Reduced kickback bars and low kickback
(see above Important Adjustments). chains do not prevent kickback, but they
67,+/UHFRPPHQGVWKHXVHRILWV are designed to reduce the risk of kick-
JUHHQODEHOHGUHGXFHGNLFNEDFNEDUV back injury. They are available from your
/RZNLFNEDFNVDZFKDLQDQGUHGXFHG JUHHQODEHOHGORZNLFNEDFNFKDLQV STIHL dealer.
NLFNEDFNEDUV DQGD67,+/4XLFNVWRSFKDLQEUDNH

STIHL offers a variety of bars and


IRUERWKH[SHULHQFHGDQGLQH[SH
ULHQFHGFKDLQVDZXVHUV :DUQLQJ
chains. STIHL reduced kickback bars Even if your saw is equipped with a
and low kickback chains are designed to Quickstop, a reduced kickback bar
and/or low kickback chain, this does not
eliminate the risk of injury by kickback.
Therefore, always observe all safety
precautions to avoid kickback situations.


/RZNLFNEDFNFKDLQ kickback energy. Improper lowering or 7RDYRLGNLFNEDFN
sharpening of the depth gauges or
Some types of saw chain have specially shaping of the cutters may increase the The best protection from personal injury
designed components to reduce the chance and the potential energy of a that may result from kickback is to avoid
force of nose contact kickback. STIHL kickback. Always cut with a properly kickback situations:
has developed low kickback chain for sharpened chain.
your powerhead. 1. Hold the chainsaw firmly with both
hands and maintain a secure grip.
Low kickback saw chain is a chain 5HGXFHGNLFNEDFNEDU 2. Be aware of the location of the guide
which has met the kickback performance bar nose at all times.
requirements of 5.12.2.4 of STIHL green labeled reduced kickback 3. Never let the nose of the guide bar
ANSI B 175.1-1991 (Safety Require- bars are designed to reduce the risk of contact any object. Do not cut limbs
ments for Gasoline-Powered Chain- kickback injury when used with STIHL with the nose of the guide bar.
Saws) when tested on a selected repre- green labeled low kickback chains. Be especially careful when cutting
sentative sample of chainsaws below small, tough limbs, small size brush

:DUQLQJ
3.8 cubic inch displacement specified in and saplings which may easily catch
ANSI B 175.1-1991. the chain.
When used with other, more aggressive 4 Dont overreach.

:DUQLQJ
chains, these bars may be less effective 5. Dont cut above shoulder height.
in reducing kickback, and may result in 6. Begin cutting and continue at full
There are potential powerhead and bar higher kickback forces. throttle.
combinations with which low kickback 7. Cut only one log at a time.
saw chains can be used which have not 8. Use extreme caution when reentering
been specifically certified to comply with %RZ*XLGHV a previous cut.

:DUQLQJ
the 45 computer derived kickback angle 9. Do not attempt to plunge cut if you
of 5.12 of ANSI B 175.1-1991. are not experienced with these
Some low kickback chains have not Do not mount a bow guide on any cutting techniques.
been tested with all powerhead and bar STIHL chainsaw. 10. Be alert for shifting of the log or other
combinations. Any chainsaw equipped with a bow forces that may cause the cut to

:DUQLQJ guide is potentially very dangerous.


The risk of kickback is increased with a
close and pinch the chain.
11. Maintain saw chain properly. Cut with
A dull or improperly sharpened chain bow guide because of the increased a correctly sharpened, properly
may reduce or negate the effects of the kickback contact area. Low kickback tensioned chain at all times.
design features intended to reduce chain will not significantly reduce the risk 12. Stand to the side of the cutting path
of kickback injury when used on a bow of the chainsaw.
guide.


&XWWLQJ7HFKQLTXHV

)HOOLQJ

Felling is cutting down a tree.

001BA037 L

001BA038 L
Before felling a tree, consider carefully all
conditions which may affect the direction
of fall, including:

$ 3XOOLQ % 3XVKEDFN The intended direction of the fall.

Pull-in occurs when the chain on the Pushback occurs when the chain on the The natural lean of the tree.
bottom of the bar is suddenly stopped top of the bar is suddenly stopped when
when it is pinched, caught or encounters it is pinched, caught or encounters a Any unusually heavy limb structure.
a foreign object in the wood. The reaction foreign object in the wood. The reaction
of the chain pulls the saw forward and of the chain drives the saw straight back Surrounding trees and obstacles.
may cause the operator to lose control. toward the operator and may cause loss
of saw control. Pushback frequently The wind direction and speed.
Pull-in frequently occurs when the occurs when the top of the bar is used for
bumper spike of the saw is not held cutting.
securely against the tree or limb and
when the chain is not rotating at full 7RDYRLGSXVKEDFN :DUQLQJ
speed before it contacts the wood. Always observe the general condition of
1. Be alert to forces or situations that the tree. Inexperienced users should

 :DUQLQJ
may cause material to pinch the top
of the chain.
never attempt to cut trees which are
decayed or rotted inside or which are
Use extreme caution when cutting small leaning or otherwise under tension.
size brush and saplings which may easily 2. Do not cut more than one log at a time. There is an increased risk that such trees
catch the chain and pull you off balance. could snap or split while being cut and
3. Do not twist the saw when cause serious or fatal injury to the
7RDYRLGSXOOLQ withdrawing the bar from a plunge operator or bystanders. Also look for
1. Always start a cut with the chain cut or underbuck cut because the broken or dead branches which could
rotating at full speed and the bumper chain can pinch. vibrate loose and fall on the operator.
spike in contact with the wood. When felling on a slope, the operator
2. Pull-in may also be prevented by using should stand on the uphill side if
wedges to open the kerf or cut. possible.


001BA088 L
1 1/ 2 1
21/2

)HOOLQJ,QVWUXFWLRQV

When felling, maintain a distance of at


least 21/2 tree lengths from the nearest
person.

001BA040 L

001BA041 L
When felling in the vicinity of roads,
railways and power lines, etc., take extra
precautions. Inform the police, utility
company or railway authority before
beginning to cut. (VFDSHSDWK %XWWUHVVURRWV
 :DUQLQJ First clear the tree base and work area If the tree has large buttress roots, cut
The noise of your engine may drown any from interfering limbs and brush and into the largest buttress vertically first
warning call. clean its lower portion with an ax. (horizontally next) and remove the
 :DUQLQJ Then, establish two paths of escape (%)
resulting piece.
There are a number of factors that may and remove all obstacles. These paths
affect and change the intended direction should be generally opposite to the plan-
of fall, e.g. wind, lean of tree, sloping ned direction of the fall of the tree ($)
ground, one-sided limb structure, wood and about at a 45 angle. Place all
structure, decay, snow load, etc. To re- tools and equipment a safe distance away
duce the risk of severe or fatal injury to from the tree, but not on the escape paths.
yourself or others, look for these condi-
tions prior to beginning the cut, and be
alert for a change in direction during fall.


001BA042 L
001BA019 KN

*XQQLQJVLJKW &RQYHQWLRQDOFXW 2SHQIDFHWHFKQLTXH

When making the felling notch, use the $ felling notch - determines the $ = felling notch - determines the
gunning sight on the shroud and housing direction of the fall direction of the fall
to check the required direction of fall:
For a conventional cut: For an open-face cut:
Position the saw so that the
gunning sight points exactly in the
direction you want the tree to fall.
Properly place felling notch
perpendicular to the Iine of fall,
Properly place felling notch
perpendicular to the Iine of falI,
close to the ground close to the ground
Cut down at app. 45-degree angle
to a depth of about 1/5 to 1/4 of the
Cut down at app. 50-degree angle
to a depth of app.1/5 to 1/4 of the
trunk diameter trunk diameter
Make second cut horizontal Make second cut from below at
Remove resulting 45-degree piece app. 40 degree angle
Remove resulting 90-degree piece


001BA043 L

001BA044 L

001BA045 L
0DNLQJVDSZRRGFXWV % )HOOLQJFXW & +LQJH
Conventional and open-face technique: Helps control the falling tree
For medium sized or larger trees
make cuts at both sides of the trunk,
Begin 1 to 2 inches higher than
center of felling notch
Do not cut through the hinge -
you could lose control of the
at same height as subsequent Cut horizontalIy towards the felling direction of the fall

felling cut.
Cut to no more than width of guide
notch
Leave approx.1/10 of diameter uncut. :DUQLQJ
bar. This is the hinge In order to reduce the risk of personal

This is especially important in soft


Do not cut through the hinge
you could lose control of the
injury, never stand directly behind the
tree when it is about to fall, since part of
wood in summer - it helps prevent direction of the fall the trunk may split and come back
sapwood splintering when the tree Drive wedges into the felling cut where towards the operator (barber-chairing),
falls. necessary to control the fall. or the tree may jump backwards off the

:DUQLQJ stump. Always keep to the side of the


falling tree. When the tree starts to fall,
If the tip of the bar contacts a wedge, withdraw the bar, shut off the engine and
it may cause kickback. Wedges should walk away on the preplanned escape
be of wood or plastic never steel, path. Watch out for falling limbs.
which can damage the chain.


001BA047 L
001BA046 L

001BA048 L
:DUQLQJ )HOOLQJFXWIRUODUJHGLDPHWHUWUHHV Avoid repositioning the saw more than

Be extremely careful with partially fallen :DUQLQJ necessary. When repositioning for the
next cut, keep the guide bar fully engaged
trees which are poorly supported. Felling a tree that has a diameter greater in the kerf to keep the felling cut straight.
When the tree hangs or for some other than the length of the guide bar requires If the saw begins to pinch, insert a
reason does not fall completely, set the use of either the sectioning felling cut or wedge to open the cut. On the last cut,
saw aside and pull the tree down with a plunge-cut method. These methods are do not cut the hinge.
cable winch, block and tackle or tractor. extremely dangerous because they
If you try to cut it down with your saw, involve the use of the nose of the guide
you may be injured. bar and can result in kickback. Only 3OXQJHFXWPHWKRG
properly trained professionals should
)HOOLQJFXWIRUVPDOOGLDPHWHUWUHHV attempt these techniques. Timber having a diameter more than
VLPSOHIDQFXW twice the length of the guide bar requires
6HFWLRQLQJPHWKRG the use of the plunge-cut method before
Engage the bumper spikes of the chain- For the sectioning method make the first making the felling cut.
saw directly behind the location of the part of the felling cut with the guide bar
intended hinge and pivot the saw around fanning in toward the hinge. Then, using
this point only as far as the hinge. The the bumper spike as a pivot, reposition
bumper spike rolls against the trunk. the saw for the next cut.


If you are inexperienced with a chainsaw,
plunge-cutting should not be attempted.
Seek the help of a professional.

/LPELQJ

001BA089 L
Limbing is removing the branches from
a fallen tree.

:DUQLQJ
First, cut a large, wide felling notch. There is an extreme danger of kickback
Make a plunge cut in the center of the during the limbing operation. Do not
notch. work with the nose of the bar. Be extremely
cautious and avoid contacting the log or
The plunge cut is made with the guide other limbs with the nose of the guide bar.

001BA033 L
bar nose. Begin the plunge cut by
applying the lower portion of the guide Do not stand on a log while limbing it
bar nose to the tree at an angle. Cut until you may slip or the log may roll.
the depth of the kerf is about the same as
the width of the guide bar. Next, align Start limbing by leaving the lower limbs to
the saw in the direction in which the support the log off the ground. When %XFNLQJ
recess is to be cut. underbucking freely hanging limbs, Bucking is cutting a log into sections.

With the saw at full throttle, insert the


a pinch may result or the limb may fall,
causing loss of control. If a pinch occurs, :DUQLQJV
guide bar in the trunk. stop the engine and remove the saw, 1. When bucking, do not stand on the
by lifting the limb. log. Make sure the log will not roll
Enlarge the plunge cut as shown in
illustration. :DUQLQJ downhill. If on a slope, stand on the
uphill side of the log.

:DUQLQJ
Be extremely cautious when cutting Watch out for rolling logs.
limbs or logs under tension (spring poles).
There is an extreme danger of kickback The limbs or logs could spring back
at this point. Extra caution must be taken toward the operator and cause loss of
to maintain control of the saw. To make control of the saw and severe or fatal
the felling cut, follow the sectioning injury to the operator.
method described previously.


0$,17(1$1&(5(3$,5
$1'6725,1*

0DLQWHQDQFHUHSODFHPHQWRUUHSDLU
RIWKHHPLVVLRQFRQWUROGHYLFHVDQG
V\VWHPVPD\EHSHUIRUPHGE\DQ\
QRQURDGHQJLQHUHSDLUHVWDEOLVKPHQW
RULQGLYLGXDO+RZHYHULI\RXFODLP
ZDUUDQW\IRUDFRPSRQHQWZKLFKKDV
QRWEHHQVHUYLFHGRUPDLQWDLQHGSUR
SHUO\RULIQRQDSSURYHGUHSODFHPHQW
SDUWVZHUHXVHG67,+/PD\GHQ\
ZDUUDQW\

Never operate a chainsaw that is


001BA051 L

001BA050 L
damaged, improperly adjusted or not
completely or securely assembled.
Follow the maintenance and repair
instructions in the appropriate section of
your Owners Manual, especially those
2. Cut only one log at a time. 5. Logs under strain: Risk of pinching! in the chapters Mounting the Bar and
Always start relieving cut () at Chain, Maintaining and Sharpening
3. Shattered wood should be cut very compression side ($). and Chain Brake.
carefully. Sharp slivers of wood Then make bucking cut () at
may be caught and flung in the
direction of the operator of the saw.
tension side (%).
If the saw pinches, stop the engine :DUQLQJ
and remove it from the log. Use only STIHL replacement parts for
4. When cutting small logs, place log maintenance and repair. Use of parts
through V - shaped supports on 6. Only properly trained professionals manufactured by others may cause
top of a sawhorse. Never permit should work in an area where the serious or fatal injury.
another person to hold the log.
Never hold the log with your leg or
logs, limbs and roots are tangled.
Working in blowdown areas is :DUQLQJ
foot. extremely hazardous. Always stop the engine and ensure that
the chain is stopped before making any
7. Drag the logs into a clear area before adjustments, maintenance or repair work,
cutting. Pull out exposed and cleared
logs first.


changing the saw chain or cleaning the result. If your muffler was equipped with For the proper and effective operation of
saw. Do not attempt any maintenance or a spark-arresting screen to reduce the the chain brake the brake band and
repair work not described in your risk of fire (e. g. in the USA, Canada and clutch drum must be kept free of dirt,
Owners Manual. Have such work perfor- Australia), never operate your saw if the grease and other foreign matter which
med at your STIHL service shop only. screen is missing or damaged. Remem- may reduce friction of the band on the

 :DUQLQJ
ber that the risk of forest fires is greater
in hot or dry weather.
drum.

Never test the ignition system with Keep the chain, bar and sprocket clean; For these reasons, each STIHL chain-
ignition wire terminal removed from spark replace worn sprockets or chains. saw should be returned to trained
plug or with unseated spark plug, since Keep the chain sharp. personnel such as your STIHL servicing
uncontained sparking may cause a fire. You can spot a dull chain when easy-to- dealer for periodic inspection and
 :DUQLQJ
cut wood becomes hard to cut and burn
marks appear on the wood.
servicing of the brake system according
to the following schedule:
To reduce the risk of fire and burn injury, Keep the chain at proper tension. Tighten Heavy usage - every three months,
use only spark plugs authorized by all nuts, bolts and screws except the Moderate usage - twice a year,
STIHL. Always press spark plug boot carburetor adjustment screws after each Occasional usage - annually.
snugly onto spark plug terminal of the use.

:DUQLQJ
proper size. (Note: If terminal has The chainsaw should also be returned
detachable SAE adapter nut, it must be immediately for maintenance whenever
attached.) A loose connection between In order for the chain brake on your the brake system cannot be thoroughly
spark plug terminal and ignition wire STIHL chainsaw to properly perform its cleaned or there is a change in its
connector in the boot may create arcing function of reducing the risk of kickback operating characteristics.
that could ignite combustible fumes and and other injuries, it must be properly
cause a fire. Keep spark plug clean, and maintained. Like an automobile brake, For any maintenance please refer to the
make sure ignition lead is in good a chainsaw chain brake incurs wear maintenance chart DQGWRWKHZDUUDQW\
condition. each time it is engaged. VWDWHPHQW near the end of this manual.
 :DUQLQJ The amount of wear will vary depending Additionally, the daily maintenance
Do not operate your chainsaw if the upon usage, conditions under which the schedule for your chainsaw set forth in
muffler is damaged, missing or modified. saw is used and other factors. Excessive your STIHL Owners Manual should be
An improperly maintained muffler will wear will reduce the effectiveness of the strictly followed.
increase the risk of fire and hearing loss. chain brake and can render it inoperable.
Never touch a hot muffler or burn will
Store chainsaw in a dry place and away
from children. Before storing for longer
than a few days, always empty the fuel
tank (see chapter "Storing the Machine"
in this manual).


0RXQWLQJ
WKH%DUDQG&KDLQ

143BA034 KN

143BA004
1 6 4 4
7
5

143BA003 KN
2

143BA005 KN
145BA001 K

You can run chains of different pitches 'LVHQJDJHWKHFKDLQEUDNH Fit the guide bar over the studs  -
on this chainsaw - depending on the
chain sprocket (see "Specifications")
Pull hand guard  toward the front
handle.
cutting edges on top of bar must
point to right -
Wear work gloves to protect hands and engage the peg of the
The chain pitch must match the guide Fit the chain - start at the bar nose. tensioner slide in locating hole  -
bar. The drive link gauge must match
the guide bar groove width.
place the chain over sprocket  at
the same time -

Unscrew nuts and take off cover

Turn tensioning screw  


counterclockwise until the peg of
the tensioner slide  butts against
left end of housing slot.

 
7HQVLRQLQJWKH6DZ&KDLQ &KHFNLQJ&KDLQ7HQVLRQ

143BA007 KN
145BA004 K
Retensioning during cutting work: Shut down the engine.
Shut down the engine -
and then slacken the nuts.
Wear work gloves to prevent
injuries.

7 Hold the bar nose up -


and use screwdriver to turn
Chain must fit snugly against the
underside of the bar - and, with the
145BA003 K

tensioning screw  clockwise until chain brake disengaged, it must still be


chain fits snugly against possible to pull the chain along the bar
the underside of the bar - by hand.
while still holding bar nose up,
Now turn tensioning screw 
clockwise until there is very little
tighten down the nuts ILUPO\ If necessary, retension the chain.

chain sag on the underside of the A new chain has to be retensioned A new chain has to be retensioned
bar - more often than one that has been in more often than one that has been in
and the drive link tangs are located use for some time - use for some time -
in the bar groove.
check chain tension frequently - Check chain tension frequently -
Refit the sprocket cover -
and screw on the nuts
see section "During Operation". see section "During Operation".

only finger-tight.

Tensioning the chain -


see section
"Tensioning the Saw Chain"

 
)XHOPL[ )XHOLQJ

This engine is certified to operate on We recommend STIHL 50:1 two-stroke


unleaded gasoline and oil with the engine oil since it is specially formulated
mix ratio 50:1. for use in STIHL engines.
Do not use BIA or TCW (two-stroke
Your two-stroke engine requires a water cooled) mix oils!
mixture of brand-name gasoline and
quality two-stroke engine oil with the Take care when handling gasoline.
FODVVLILFDWLRQ7& Avoid direct contact with the skin and
avoid inhaling fuel vapour
Use regular branded unleaded gasoline (see Safety Precautions).
with a minimum octane rating of
90 ROZ (U.S.A./Canada: pump octane The canister should be kept tightly
min. 89!). If the octane number of the closed in order to avoid any moisture
regular grade gasoline in your area is getting into the mixture.
lower, use premium unleaded fuel.
Fuel with a lower octane rating may The fuel tank and the canister in which

143BA008 KN
result in preignition (causing pinging) fuel mix is stored should be cleaned
which is accompanied by an increase in from time to time.
engine temperature. This, in turn,
increases the risk of piston seizure )XHOPL[DJHV
and damage to the engine. Before fueling, clean the fuel filler cap
Only mix sufficient fuel for a few days and the area around it to ensure that no
The chemical composition of the fuel is work, not to exceed 3 months of storage. dirt falls into the tank.
also important. Some fuel additives not Store in approved safety fuel-canisters Always thoroughly shake the mixture in
only detrimentally affect elastomers only. When mixing, pour oil into the the canister before fueling your machine.
(carburetor diaphragms, oil seals, fuel
lines etc.), but magnesium castings as
canister first, and then add gasoline.
:DUQLQJ
well. This could cause running problems Gaso- Oil (STIHL 50:1 or In order to reduce the risk of burns or
or even damage the engine. For this line equivalent branded TC oils) other personal injury from escaping gas
reason it is essential that you use only vapor and fumes, remove the fuel filler
branded fuels! US gal. US fl.oz cap carefully so as to allow any pressure
build-up in the tank to release slowly.
Use only STIHL two-stroke engine oil or
equivalent branded two-stroke air- 1 2.6 :DUQLQJ
cooled engine oils with the classification 2 1/2 6.4 After fueling, tighten fuel cap DV
TC for mixing. 5 12.8 VHFXUHO\DVSRVVLEOH by hand.
Use a suitable tool (e.g. screwdriver end
Dispose empty mixing-oil canisters only of combination wrench) to tighten
at authorized disposal locations. slotted fuel caps.

 
&KDLQ/XEULFDQW )LOOLQJ&KDLQ
2LO7DQN

For automatic and reliable lubrication of


the chain and guide bar:
8VHRQO\DTXDOLW\HQYLURQPHQWDOO\
FRPSDWLEOHFKDLQDQGEDUOXEULFDQW
67,+/FKDLQOXEULFDQWZLWKQRQIOLQJ
DGGLWLYHRUWKHUDSLGO\ELRGHJUDGDEOH
67,+/%LRSOXVLVUHFRPPHQGHG

,PSRUWDQWBiological chain oil must be


resistant to aging (e.g. STIHL Bioplus)
since it will otherwise quickly turn to
resin. This results in hard deposits that
are difficult to remove, especially in the
area of the chain drive, clutch and chain.
It may even cause the oil pump to seize.
143BA009 KN

143BA010 KN
The service life of the chain and guide
bar depends on the quality of the
lubricant. It is therefore essential to use
only a specially formulated chain
Change the fuel pick up body every year. lubricant. Thoroughly clean the oil filler cap
and the area around it to ensure
Before storing your machine for a long If special chain lubricant is not available, that no dirt falls into the tank.
period, drain and clean the fuel tank and you may - in an emergency - use an HD
run engine until carburetor is dry. single grade or multigrade engine oil
with a viscosity that suits the prevailing
Refill the chain oil tankevery time
you refuel.
outside temperature.
There must still be a small amount of oil
:DUQLQJ in the oil tank when the fuel tank is
empty.
Medical studies have shown that If the oil tank is still partly full, the reason
renewed contact with waste oil can may be a problem in the oil supply
cause skin cancer. Avoid direct contact system:
with waste oil. If waste oil does get on Check chain lubrication, clean the
your skin, wash with soap and water. oil passages, contact your STIHL dealer
'RQRWXVH waste oil for any purpose, for assistance if necessary.
and dispose of it only at authorized
disposal locations.

 
&KDLQ%UDNH

7KHFKDLQEUDNHLVDOVRDFWLYDWHGE\
WKHLQHUWLDRIWKHIURQWKDQGJXDUG
if the kickback force of the saw is high
enough:
The hand guard is accelerated toward
the bar nose - even if your left hand is
not behind the hand guard, e.g. during
felling cut.
The chain brake will operate only if the
hand guard has not been modified in
any way.

&KHFNRSHUDWLRQRIFKDLQEUDNH

Before starting work: Run engine at

143BA012 KN
143BA011 KN

idle speed, engage the chain brake


(push hand guard toward bar nose).
Accelerate up to full throttle for no more
than 3 seconds - the chain must not
/RFNLQJFKDLQZLWKFKDLQEUDNH 5HOHDVLQJWKHFKDLQEUDNH rotate. The hand guard must be free of
dirt and move freely.
- in an emergency
- when starting
Pull the hand guard back toward
the front handle.
- at idling speed. &KDLQEUDNHPDLQWHQDQFH
1RWHAlways disengage chain brake
The chain is stopped and locked
when the hand guard is pushed
before accelerating engine and before
starting cutting work. The only exception
The chain brake is subject to normal
wear and tear. It must therefore be
toward the bar nose by the left hand - to this rule is when you check operation checked and serviced regularly by
or when brake is activated by inertia of the chain brake. High revs with the trained personnel (e.g. STIHL dealer) at
in certain kickback situations. chain brake engaged (chain locked) will the following intervals:
quickly damage the powerhead and
chain drive (clutch, chain brake). Full-time professional
users: every 3 months
Semi-professional
users: every 6 months
Occasional
users: every 12 months

 
,QIRUPDWLRQ%HIRUH<RX6WDUW
GRQWVWDUWWKHHQJLQH\HW

STOP STOP STOP

0 0 0 4

3 3
2 2
1

143BA014
143BA013

143BA015
7KHIRXUSRVLWLRQV "Warm Start" position: In the "Warm Start" position, continue
RIWKH0DVWHU&RQWUROOHYHU Choke shutter is open - cranking after engine begins to fire.
throttle trigger is in starting-throttle As soon as the engine runs,
To start the engine, move the lever to position LPPHGLDWHO\ blip the throttle trigger
"Cold Start" position  - If you leave the Master Control lever so that the Master Control lever moves to
do not use force. in the "Cold Start" position, "Run" -
If the Master Control lever is on the combustion chamber will flood idling position -
"Run"  : Press down the throttle trigger and stall the engine. normal operating position  .
interlock - and move the Master Control The Master Control lever must be in
lever downward. "Warm Start" position  to start a warm 7RVKXWGRZQWKHHQJLQH
"Cold Start" position: Choke shutter is engine. Also select this position if engine Move the Master Control lever upward
closed - throttle trigger is in starting- has been running but is still cold. to "STOP" position  :
throttle position. A cold engine should The stop contact engages the contact
be started in this position. The Master Control lever should not be spring - this cuts out the ignition system.
As soon as engine begins to fire, forced to "Run" position  -
move the Master Control lever to it will move to "Run" as soon as the
"Warm Start" position  : throttle trigger is activated.
Move the Master Control lever one
notch upward.

 
6WDUWLQJWKH6DZ

STOP

143BA018 KN
133BA001 K

Press in the button Observe safety precautions -


see section "Safety Precautions".
Place your saw on the ground -
make sure you have a firm footing -
Compression pressure is released Push hand guard forward  : check that chain is not touching any
when the button is pressed in. The chain is now locked - objects or the ground -
This helps reduce the effort Press throttle trigger interlock  bystanders must be well clear of
required to pull the starter rope. and set general work area of the saw -
Master Control lever to:
For this reason the botton should
be pressed in before each starting For cold start N
Hold the saw firmly on the ground
with your left hand on the front
attempt. handle - your left thumb should be
For warm start Q under the handle -

(even if engine has been running


put your right foot into the rear
handle and press down.
but is still cold)

 
STOP

3
143BA019 KN

143BA020 KN
4

Alternative method of starting: Pull the starter grip slowly with your When engine begins to fire:
Hold the rear handle tightly
between your legs, just above the
right hand until you feel it engage -
then give the grip a brisk strong pull
Move Master Control lever  to Q
and continue cranking -
knees - and push down the front handle DVVRRQDVHQJLQHUXQV
grip the front handle firmly with your
left hand -
at the same time -
do not pull out starter rope more
LPPHGLDWHO\ blip the throttle
trigger  -
your thumb should be under the than 70 cm (about 28 in) - the Master Control lever  will
handle - it might otherwise break. move
Do not let the starter grip snap back - to "Run" position  
guide it slowly into the housing and the engine settles down
so that the starter rope can rewind to idling speed.
properly.
If engine is new, pull starter grip
several times to prime the fuel line. As the chain brake is still engaged, the
engine must be returned to idling speed
immediately to avoid damage to the
engine and chain drive (clutch, chain
brake).

 
133BA009 KN
133BA010 KN
143BA012 KN
143BA012 KN

Pull the hand guard back toward


the front handle:
$WYHU\ORZRXWVLGHWHPSHUDWXUHV
$OORZHQJLQHWRZDUPXS
,IHQJLQHGRHVQWVWDUW

the chain brake is now If you did not move the Master Control
disengaged - As soon as the engine runs: lever to "Warm Start" Q
your saw is ready for operation. Blip the throttle trigger quickly enough after the engine began
Observe safety precautions. to disengage it from starting throttle to fire, the combustion chamber has
Always check operation of chain
lubrication before starting work.
position -
Master Control lever will move
flooded.

6KXWGRZQHQJLQH to normal operating position - Turn knob or lever above rear


Move Master Control lever to engine settles down to idling speed. handle 90 counterclockwise.
"Stop" E Disengage chain brake:
Pull hand guard toward front handle
Lift off the carburetor box cover
vertically.
Always disengage the chain brake as shown in illustration -
before opening the throttle. Running the
engine at higher revs with the chain
Open throttle slightly -
warm up engine for short period.
brake engaged (saw chain at a
standstill) will quickly damage the engine
Change over to winter operation
if necessary -
and chain drive (clutch, chain brake). see section "Winter Operation".

 
&KHFNLQJ&KDLQ/XEULFDWLRQ 2LO4XDQWLW\
&RQWURO

Pull off the spark plug terminal -


Take out screw and remove the
shroud -
Unscrew and dry off the spark plug -

Set the Master Control lever to G

Crank the engine several times


with the starter
to clear the combustion chamber -
Refit the spark plug and connect
the spark plug terminal -
reassemble all other parts
Set Master Control lever
to "Warm Start" Q
even if engine is cold -
1

143BA024 KN

145BA011 K
Now start the engine.

)XHOWDQNUXQXQWLOGU\
DQGWKHQUHIXHOHG
The saw chain must always throw off Different quantities of oil are required for
Pull starter rope several times until
fuel line is primed.
a small amount of oil. different bar lengths, types of wood and
cutting techniques.
Never operate your saw without
chain lubrication. If the chain is run Use the adjusting screw () to vary the
dry the whole cutting attachment oil feed rate as required.
will be irretrievably damaged within
a very short time.
Always check chain lubrication and
Most economic setting -
turn adjusting screw to "("
oil level in tank before starting work. ((matic position).
To increase oil feed -
Every new chain has to be broken turn adjusting screw clockwise.
in for about 2 to 3 minutes. To reduce oil feed -
turn adjusting screw counter-
After breaking in chain,
check chain tension
clockwise.

and adjust if necessary - Your chain must always be wetted with


see section a film of lubricant.
"Checking chain tension".

 
'XULQJ%UHDNLQ3HULRG 'XULQJ2SHUDWLRQ $IWHU)LQLVKLQJ:RUN

A factory new machine should not be


run at high revs (full throttle off load)
&KHFNFKDLQWHQVLRQIUHTXHQWO\
A new chain has to be retensioned more
Slacken off the chain if you have
retensioned it at operating
for the first three tank fillings. This avoids often than one that has been in use for temperature during cutting work.
unnecessary high loads during the some time.
break-in period. The chain contracts as it cools down.
&KDLQFROG If it is not slackened off, it could damage
As all moving parts have to bed in Tension is correct when chain fits snugly the crankshaft and bearings.
during the break-in period, the frictional against the underside of the bar and can
resistances in the engine are greater still be pulled along the bar by hand.
during this period. The engine develops Retension if necessary - %HIRUHVWRULQJ\RXUVDZ
its maximum power after about 5 to 15 see section "Tensioning the Saw Chain". IRUDORQJSHULRG
tank fillings. See chapter "Storing the Chain Saw".
&KDLQDWRSHUDWLQJWHPSHUDWXUH
'RQRWPDNHWKHPL[WXUHOHDQHUWR The chain stretches and begins to sag.
DFKLHYHDQDSSDUHQWLQFUHDVHLQ The drive links must not come out of the
SRZHUWKLVFRXOGGDPDJHWKHHQJLQH bar groove - the chain may otherwise
VHHVHFWLRQ$GMXVWLQJ&DUEXUHWRU jump off the bar.
Retension the chain -
see section "Tensioning the Saw Chain".
,PSRUWDQWAlways disengage the chain
brake before opening the
throttle. Running the engine at higher Always slacken off the chain after
revs with the chain brake engaged (saw finishing work.
chain at a standstill) will quickly damage The chain contracts as it cools down.
the engine and chain drive (clutch, chain If it is not slackened off, it can damage
brake). the crankshaft and bearings.

$IWHUORQJSHULRG
RIIXOOWKURWWOHRSHUDWLRQ
Allow engine to run for a short while
at idling speed so that engine heat can
be dissipated by flow of cooling air.
This protects engine-mounted compo-
nents (ignition, carburetor) from thermal
overload.

 
6SDUN$UUHVWLQJ6FUHHQLQ $LU)LOWHU6\VWHP
0XIIOHU

2 2
1 1
1

133BA011 KN
143BA036 KN

133BA008KN
3

&OHDQLQJ$LU)LOWHU

The air filter system can be adapted to


suit different operating conditions by
2 simply installing a choice of filters. 4
143BA037 KN

)DEULFILOWHU
for normal operating conditions and

KN
winter operation

If engine is down on power, check the )OHHFHILOWHU Unscrew the slotted nuts  .
spark arresting screen in the muffler: for dry and very dusty work areas Remove filter.
Separate the two halves of the filter.
Take out the screw  . Knock the filter out on the palm of
Remove the spark arresting
screen  .
:KHQWKHUHLVDQRWLFHDEOHORVVRI
HQJLQHSRZHU
your hand or blow it out with com-
pressed air from the inside outwards
Clean spark arresting screen if
necessary. Turn knob or lever  above rear ,QFDVHRIVWXEERUQGLUW
If screen is damaged or coked up, handle 90 counterclockwise. Wash the air filter in fresh, non-
fit a new one. Lift off the carburetor box cover  flammable cleaning solution (e.g.
Refit the spark arresting screen in vertically. warm soapy water) and then dry.
the reverse sequence. Clean away loose dirt from around
filter. 1HYHUXVHDEUXVKWRFOHDQWKHIOHHFH
ILOWHUHOHPHQW
Dirty air filters reduce engine power,
increase fuel consumption and make
Always replace a damaged filter
element.
starting more difficult. Make sure that the choke shutter
 with spring is properly fitted.
Reinstall the filter.

 
:LQWHU2SHUDWLRQU

3
2

133BA009 KN

133BA012 KN

133BA005 KN
1
4

2
133BA010 KN

133BA013 KN

133BA006 KN
$WWHPSHUDWXUHVEHORZ& )  0DFKLQHVZLWKVKXWWHULQVKURXG 0DFKLQHVZLWKVKXWWHULQFDUEXUHWRU
3UHKHDWWKHFDUEXUHWRU ER[FRYHU
Remove the screw (1)
Turn knob or lever above rear
handle 90 counterclockwise.
Pull out the shutter (2) and refit it
in the "winter" position
Pry the shutter  out of the
carburetor box cover and slide it
Lift off the carburetor box cover (bottom illustration) into the slot  at the bottom end of
vertically. Insert screw and tighten it down.
Preheated air from around the cylinder is
the carburetor box cover.

now drawn in along with cold air - this 7KHVKXWWHUPXVWEHUHWXUQHGWRWKH


helps prevent carburetor icing. VXPPHUSRVLWLRQZKHQWKHRXWVLGH
WHPSHUDWXUHLVKLJKHUWKDQ&
7KHVKXWWHUPXVWEHUHWXUQHGWRWKH ) 7KLVLVQHFHVVDU\WRDYRLG
VXPPHUSRVLWLRQ WRSLOOXVWUDWLRQ  HQJLQHUXQQLQJSUREOHPVDQGWKHULVN
ZKHQWKHRXWVLGHWHPSHUDWXUHLV RIRYHUKHDWLQJ
KLJKHUWKDQ& ) 7KLVLV
QHFHVVDU\WRDYRLGHQJLQHUXQQLQJ
SUREOHPVDQGWKHULVNRIRYHUKHDWLQJ

 
(OHFWULF+DQGOH 7DNH&DUHRI*XLGH%DU
+HDWLQJ

$WWHPSHUDWXUHVEHORZ& ) 

It is advisable to fit the optional intake


air preheating kit if you use your saw in
extremely cold conditions (temperatures 2
below -10 C /+14 F, in powder or
drifting snow).

When fitted, the kit ensures that only


heated air is drawn in from around the
cylinder -
it prevents air filter and carburetor icing.

The shutter or cover for carburetor


preheating must be in the "winter"

143BA026 KN
138BA012 L
position when the intake air preheating
kit is fitted. 1 3
If your saw is very cold (frost or ice on
machine), start the engine and keep it
at a high idle speed (with chain brake
disengaged) until it reaches normal
Switching on electric handle heating* Turn the bar over - every time you
sharpen the chain - and every time
operating temperature. Move switch on front handle to 
Move switch back to 
you replace the chain -
this avoids one-sided wear,
The air filter may load up faster when to switch off heating. especially at nose and
you use intake air preheating - underside of the bar.
clean it more frequently. There is no risk of overheating during
long periods of operation. Regularly clean
In the event of engine running problems, The whole heating system is   oil inlet hole
first check that conditions for use maintenance-free.   oilway
of intake air preheating still apply.   bar groove.

0HDVXUHJURRYHGHSWK
with scale on filing gauge* -
at nose of Duromatic bars -
in area used most for cutting
on Rollomatic bars.

* Special accessory * Special accessory * Special accessory

 
&KHFNLQJDQG5HSODFLQJ
&KDLQ6SURFNHW

Chain Pitch Minimum


type groove
depth

Rapid 0.325" 6.0 mm (0.24")


Picco 3/8" 6.0 mm (0.24")
Rapid 3/8" 6.0 mm (0.24")

If groove depth is less than specified:


5HSODFHWKHJXLGHEDU
5HSODFHWKHFKDLQVSURFNHW 5LPVSURFNHW
The drive link tangs will otherwise scrape DIWHUXVLQJWZR2LORPDWLFFKDLQV
along the bottom of the groove - Use a screwdriver to
the cutters and tie straps will not ride on or sooner if the wear marks on the sprok- remove the E-clip.
the bar rails. ket are deeper than approx. Take off the washer and
0.5 mm (1/64") since this would reduce rim sprocket.
the life of the chain.
Check wear marks:
Examine splines on clutch drum -
if wear marks are severe, fit a new
Left: on webs of rim sprockets - clutch drum:
Right: on teeth of spur sprockets.
Pull clutch drum and needle cage
You can use gauge* 0000 893 4101 off the crankshaft - clean the
to check the depth of the wear marks on crankshaft stub and needle cage,
spur and rim sprockets. and lubricate with STIHL grease
It is best to use two chains in rotation (tube 0781 120 1111).
with one sprocket. Reassemble with new rim sprocket
and new clutch drum, if necessary -
%HIRUHUHPRYLQJFKDLQVSURFNHW fit rim sprocket with cavities facing
Remove chain sprocket cover,
chain and guide bar.
outward -
refit washer and E-clip on the crankshaft.
Disengage the chain brake:
Pull hand guard toward front handle. Use only original STIHL clutch drums to
ensure correct operation
of the chain brake.

* Special accessory

 
$GMXVWLQJ&DUEXUHWRU

0RWRUPDQDJHPHQW

Exhaust emissions are controlled by the


design of the fundamental engine
parameters and components
(e.g. carburation, ignition, timing and
valve or port timing) without the addition
of any major hardware.
The carburetor is set at the factory to L
K guarantee an optimum fuel-air mixture
6SXUVSURFNHW under all operating conditions.
Emissions at idling speed and part-load
Use a screwdriver to are kept to a minimum by reducing the
remove the E-clip. idle mixture.
LA
Pull washer, spur sprocket and

133BA022 KN
needle cage off the crankshaft. Check the air filter and clean or re-
place it if necessary.
Clean the crankshaft stub and
needle cage, and lubricate with
STIHL grease
Check the spark arresting screen
and clean or replace it if necessary.
(tube 0781 120 1111). (QJLQHVWRSVZKLOHLGOLQJ
Carefully screw the low speed /VFUHZPXVWEHRQHWXUQRSHQ
Reassemble with new spur sprocket - screw / down onto its seat.
After fitting the clutch drum, rotate Now open it one turn counter- Turn the idle speed screw /$ clockwise
it about one turn to engage clockwise (standard until chain begins to run -
oil pump drive - setting, / ) then back off the screw one quarter
refit washer and E-clip on the crankshaft. of a turn.

Use only original STIHL chain


Warm up the engine.

sprockets to ensure correct It is usually necessary to change the &KDLQUXQVZKHQHQJLQHLVLGOLQJ


operation of the chain brake. setting of the idle speed screw /$ /VFUHZPXVWEHRQHWXUQRSHQ
after every correction to the low speed
screw / . Turn the idle speed screw /$
counterclockwise until chain
Turn screws only very slightly and stops running -
carefully - even minor changes have a then turn screw another quarter turn in
noticeable effect on the engines running the same direction.
behavior.

 
&KHFNLQJ6SDUN3OXJ

(UUDWLFLGOLQJEHKDYLRXU
SRRUDFFHOHUDWLRQ
HYHQWKRXJK/VFUHZLQRQHWXUQ
RSHQ

000BA039 KN
Idle setting is too lean.
Turn the low speed screw / counter- A
clockwise until engine runs and
accelerates smoothly.
Wrong fuel mix (too much engine oil in
the gasoline), a dirty air filter and
unfavorable running conditions (mostly 1
at part throttle etc.) affect the condition of
the spark plug. These factors cause

000BA036 TR
deposits to form on the insulator nose
which may result in trouble in operation.

If engine is down on power, difficult to


start or runs poorly at idling speed,
first check the spark plug. Fit a new spark plug after
approx. 100 operating hours -
Remove spark plug -
see chapter Starting:
or earlier if the electrodes are
badly eroded.
Clean dirty spark plug.
Check electrode gap -
it should be 0.5mm/0.02" $ -
:DUQLQJ
To reduce the risk of fire and burn injury,
readjust if necessary.
Use only resistor type spark plugs
of the approved range.
use only spark plugs authorized by
STIHL (see Specifications). Always
press spark plug boot  snugly onto
spark plug terminal  of the proper
Rectify problems which have caused
size. (Note: If terminal has detachable
fouling of spark plug:
SAE adapter nut, it must be attached.)
Incorrect carburetor setting, too much oil
A loose connection between spark plug
in fuel mix, dirty air filter,
terminal and ignition wire connector in
unfavorable running conditions, e.g.
the boot may create arcing that could
operating at part load.
ignite combustible fumes and cause a
fire.

 
5HSODFLQJ6WDUWHU5RSH
DQG5HZLQG6SULQJ

1
5
1

133BA014 KN
1 1

6
2
3
4

135BA032 L
133BA015 KN

133BA040 KN
5HSODFLQJ6WDUWHU5RSH Ease the cap  out of the starter
grip.
6DZVZLWKRXW(ODVWRVWDUW

Take out the screws  . Remove remaining rope from the Thread the new rope -
Remove four screws - rotor and grip. Make sure the 3.5 mm (9/64") dia. and 960 mm
Push the hand guard upward - sleeve does not slip out of the grip. 373/4") long - through the rotor and
Pull underside of fan housing away
from crankcase and remove it
Tie a simple overhand knot in the
end of the new starter rope -
secure it with a simple overhand
knot.
downward 1113 195 8200 ( 3,5x960) -
Ease the spring clip  off the
starter post.
and then thread the rope through
the top of the grip and the rope
Thread the other end of the rope
through the guide bush (from
Carefully slip the washer  and bush  . inside) and the underside of the
pawl  off the starter post. Refit the cap in the grip. starter grip and secure it with a

:DUQLQJ
Pull the rope through the rotor and
secure it with a simple overhand
special knot - do not wind rope onto
rotor.
Take particular care to avoid injury - the knot.
rewind spring may pop out and unwind.

 
133BA020 KN

133BA021 KN
3
2
1
7HQVLRQLQJUHZLQGVSULQJ 5HSODFLQJDEURNHQUHZLQGVSULQJ
Make a loop in the unwound starter
rope and use it to turn the rope ro-
Lubricate the new spring with
a few drops of non-resinous oil.
tor six full revolutions clockwise. Remove the rope rotor -
Hold the rotor steady - see ,,Replacing Starter Rope -

133BA017 KN

straighten the twisted rope - remove the spring housing


release the rotor - and parts of spring -
let go of rope slowly so that
it winds onto the rotor.
fit the new spring housing -
bottom plate must face upward -
slip outer spring loop over lug.
%RWKYHUVLRQV The starter grip must locate firmly
in the rope guide bush.
Reinstall the rope rotor,
tension the rewind spring,
Coat rope rotor bearing bore with
non-resinous oil -
If the grip droops to one side:
Add one more turn on rope rotor
fit the fan housing and secure in
position.
slip rotor over starter post - turn it
back and forth so that anchor loop
to increase spring tension. If the spring pops out of its housing
during installation:
of rewind spring engages - When starter rope is fully extended
it must still be possible to rotate
refit it in the counterclockwise
direction, starting outside and
Refit the pawl  in the rotor - the rotor at least another half turn. working inward.
fit the washer  on the starter post If this is not the case, the spring
- use screwdriver or suitable pliers is overtensioned and could break.
to install spring clip  Take one turn off the rope.
on starter post and engage it on the
pawls peg - the spring clip must
Refit the fan housing.

point clockwise - see illustration.

 
0DLQWDLQLQJDQG
6KDUSHQLQJ6DZ&KDLQ

&RUUHFWO\VKDUSHQHGFKDLQ
A
A properly sharpened chain slices
through wood effortlessly and requires
very little feed pressure.
3/8

689BA020 KN

689BA021 KN
Do not work with a dull or damaged
B
chain as it will increase the physical
effort required, produce unsatisfactory
results and a higher rate of wear.
The chain pitch (e.g. 3/8) is marked on $ Filing angle
&OHDQDQGFKHFN\RXUFKDLQ the depth gauge side of each cutter. % Side plate angle
for cracks in the links and damaged
rivets - 8VHRQO\VSHFLDOVDZFKDLQILOHV Chain type Angle ()
replace any damaged or worn parts of A B
the chain and match the new parts to the Other files have the wrong shape and
cut. Rapid-Micro (RM) 30 85
shape and size of the original parts.
Rapid-Super (RS) 30 60
Picco-Micro (PM/PMN) 30 85
,PSRUWDQW It is absolutely imperative to Select file diameter according to chain
comply with the angles and dimensions pitch - see table at the end of this
specified below. If the VDZFKDLQLV chapter.
Cutter shapes:
LQFRUUHFWO\VKDUSHQHG - and in
You must observe certain angles when Micro = Semi-chisel
particular if the depth gauge is set too
resharpening the chain cutters Super = Full chisel
low - there is a risk of increased
kickback of the chainsaw, with resulting
6SHFLILHGDQJOHV$DQG%DUH
GDQJHURILQMXU\.
REWDLQHGDXWRPDWLFDOO\LIUHFRPPHQ
GHGILOHVRUVKDUSHQLQJWRROVDQG
6HOHFWWKHDSSURSULDWHVKDUSHQLQJ
FRUUHFWVHWWLQJVDUHXVHG
WRROVIRUWKHFKDLQSLWFK.
See Technical Data for the permitted
Furthermore, the angles must be the
chain pitches.
same on all cutters.
If angles are uneven:
Chain will run roughly, not in a straight
line, wear quickly and finally break.


Avoid touching the tie straps and
drive links with the file.
Rotate the file at regular intervals
while filing -
this avoids one-sided wear.

689BA018 KN
90 Use a piece of hardwood to remove

689BA025 KN
burrs from cutting edge.
Check angles with the filing gauge.

As these requirements can be met only )LOHFRUUHFWO\ $OOFXWWHUVPXVWEHWKHVDPHOHQJWK


after sufficient and constant practice:

8VHDILOHKROGHU*
If you use a file holder or the FG 1:
Leave the chain on the bar.
If the cutters are not the same length,
they will have different heights. This
Clamp the bar in a vise if necessary. makes the chain run roughly and can
A file holder must be used for manual
resharpening of Super chain. The correct
Lock the chain - push hand guard
forward
cause it to break.

filing angle is marked on the file holder. To rotate the chain - pull hand
guard against front handle
Find the shortest cutter and then file all
other cutters back to the same length.
Sharpen chain frequently, take
away as little metal as possible -
This can be very time consuming - it is
best to have it done in the workshop on
90
85 70 60 80 two or three strokes of the file are an electric grinder.
usually enough
Always file from the inside to the
689BA022 KN

outside of the cutter.



30 35
10 0 The file only sharpens on the
forward stroke -
lift the file off the cutter on the back-
stroke.
)RUFKHFNLQJDQJOHV
STlHL filing gauge* (see table)
Hold the file KRUL]RQWDOO\ for all
chain types (at right angle to side of
A universal tool for checking the filing guide bar) and file according to the
and side plate angles, depth gauge angles marked on the filing tool.
setting and cutter length. Also cleans the
guide bar groove and oil inlet hole.

* Special accessory


Chain Depth gauge
pitch distance D
a Inch (mm) mm (Inch)
1/4 (6.35) 0.65 (0.026)

689BA024 KN
689BA023 KN
3/8-PM (9.32) 0.65 (0.018)
3/8-PMN (9.32) 0.45 (0.026)
0.325 (8.25) 0.65 (0.026)
3/8 (9.32) 0.65 (0.026)
'HSWKJDXJHVHWWLQJ 0.404 (10.26) 0.80 (0.031) Round off depth gauges parallel to the
stamped marking.
The depth gauge determines the height This setting may be increased by 0.2 mm
at which the cutter enters the wood and (0.008") for cutting softwood in mild
thus the thickness of the chip removed. weather season - no frost. $IWHUVKDUSHQLQJ
Clean the chain thoroughly, remove
Distance between depth gauge and /RZHULQJGHSWKJDXJHV filings or grinding dust - lubricate the
cutting edge = D chain by immersing it in an oil bath.
The depth gauge setting is reduced
when the chain is sharpened. Use filing
gauge to check the setting every time %HIRUHORQJRXWRIVHUYLFHSHULRG
you sharpen the chain and, if necessary, Clean the chain with a brush and
lower the depth gauge with a flat or immerse it in an oil bath.
triangular file so that it is level with the
filing gauge.

6KDUSHQLQJWRROV

Chain pitch Round file Round file File holder Filing gauge Flat file Sharpening kit*
Inch (mm) mm (Inch) Part No. Part No. Part No. Part No. Part No.
1/4 (6.35) 4.0 (5/32) 5605 772 4006 5605 750 4327 1110 893 4000 0814 353 3356 5605 007 1027
3/8 PMN (9.32) 4.0 (5/32) 5605 772 4006 5605 750 4327 0000 893 4000 0814 353 3356 5605 007 1026
3/8 P (9.32) 4.0 (5/32) 5605 772 4006 5605 750 4327 1110 893 4000 0814 353 3356 5605 007 1027
0.325 (8.25) 4.8 (3/16) 5605 772 4806 5605 750 4328 1110 893 4000 0814 353 3356 5605 007 1028
3/8 (9.32) 5.2 (13/64) 5605 772 5206 5605 750 4329 1110 893 4000 0814 353 3356 5605 007 1029
0.404 (10.26) 5.5 (7/32) 5605 772 5506 5605 750 4330 1106 893 4000 0814 353 3356 5605 007 1030

* consisting of file holder with round file, flat file and filing gauge.


0DLQWHQDQFH&KDUW

Please note that the following maintenance intervals apply for normal operating
conditions only. If your daily working time is longer than normal or cutting conditions are difficult

refueling stop
after finishing
starting work

work or daily
(very dusty work area tropical wood etc.) shorten the specified intervals accordingly.

as required
if damaged
after each

see page:
monthly

if faulty
weekly
before
Visual inspection (condition, leaks) x x
Complete machine
Clean x
Throttle trigger , throttle trigger interlock,
Master Control, depending on model Check operation x x
Check operation x x 29
Chain brake
Clean by STIHL dealer x 29
Check x 28
Filter in fuel tank
Clean, Replace filter element x
Fuel tank Clean x
Chain oil tank Clean x
Chain lubrication Check x 28
Inspect, also check sharpness x x 45
Saw chain Check chain tension x x 26
Sharpen x 45
Check (wear, damage) x 38
Clean and turn over x x
Guide bar
Deburr x
Replace x x
Chain sprocket Check x 39
Clean x x 36
Air filter
Replace x
Cooling inlets Clean x
Cylinder fins Clean x
Check idle adjustment chain must not turn x x 40
Carburetor
Readjust idle x
Spark plug Replace x 42
All accessible screws and nuts
(not adjusting screws) Retighten x
Rubber vibration buffers Have replaced by STIHL dealer x
Inspect x x
Muffler Inspect spark arresting screen x
Clean or replace spark arresting screen x x
Check x
Chain catcher
Replace x

 
6SHFLILFDWLRQV

(QJLQH &XWWLQJ$WWDFKPHQW STIHL yellow-labeled chains:


Recommended cutting attachments for 0.325" pitch:
STIHL single cylinder two-stroke engine for compliance with 5.12 of ANSI Rapid-Micro (26 RM) and
Displacement: 48.7 cm3 (2.97 cu.in) Standard B 175.1-1991 Rapid-Super (26 RS)
Bore: 44 mm (1.73 in) (see page 12 of this Manual): for 3/8" pitch:
Stroke: 32 mm (1.26 in) Rapid-Micro (33/36 RM) and
Idle speed: 2.800 r.p.m. Rapid-Super (33/36 RS)
STIHL reduced kickback bar Since new bar/chain combinations may
(with green label): be developed after publication of this
,JQLWLRQ6\VWHP for 0.325" pitch and 3/8" pitch: Manual, ask your STIHL dealer for the
Type: Rollomatic with sprocket nose latest STIHL recommendations.
Electronic magneto ignition 40, 45 or 50 cm (16, 18 or 20 in)
(breakerless) STIHL low kickback chain* In order to comply with the kickback
Spark plug (suppressed): (with green label): performance requirements of 5.12
Bosch WSR 6 F 8.25 mm (0.325") Rapid-Micro 2 of ANSI Standard B 175.1-1991,
or NGK BPMR 7 A (26 RM 2), do not use replacement saw chain
Electrode gap 0.5 mm (0.02 in) 9.32 mm (3/8") Rapid-Micro 2 unless it has been designated as
Spark plug thread: (33/36 RM 2) meeting the ANSI 5.12 requirements
M 14x1.25; 9.5 mm (0.37 in) long Chain sprocket: on this specific powerhead, or has been
7-tooth for 0.325" pitch, designated as "low kickback" saw chain*
7-tooth for 3/8" pitch in accordance with the ANSI B 175.1-
)XHO2LO6\VWHP 1991 standard.
Carburetor:
All position diaphragm carburetor with Other cutting attachments available for *See definition of "low kickback chain"
integral fuel pump this powerhead are: on page 11 of this Manual.
Air filter: STIHL yellow-labeled bar:
Prefilter and bisectional box filter for 0.325" pitch and 3/8" pitch:
Fuel capacity: 0.46 l (0.97 U.S. pt) Rollomatic "S" with sprocket nose
Fuel mixture: See chapter "Fuel" 40, 45 or 50 cm (16, 18 or 20 in)
Chain lubrication: Duromatic with stellite tipped nose
Fully automatic, speedcontrolled plunger 40, 45 or 50 cm (16, 18 or 20 in)
type oil pump. Additional manual oil flow
control
Oil tank capacity: 0.29 l (0.61 US pt)

:HLJKW
(without bar and chain)
026; 4.7 kg (10.4 lb)
026 W 4.9 kg (10.8 lb)

 
2UGHULQJ6SDUH3DUWV 6WRULQJWKH0DFKLQH

Please enter your saw model, machine For recommended STIHL reduced For periods of about 3 months or longer:
number as well as the part numbers of kickback cutting attachments
the guide bar, saw chain and chain
sprocket in the spaces provided on the
see section "Specifications"
of this Owner's Manual.
Drain and clean the fuel tank in a
well ventilated area.
right Run engine until carburetor is dry -
this helps prevent the carburetor
This will make re-ordering simpler. diaphragms sticking together.

The guide bar, saw chain and chain


Remove the saw chain and guide
bar, clean them and protect
sprocket are subject to normal wear and with corrosion inhibiting oil.
tear. Thoroughly clean the machine -
pay special attention to the
The part numbers of the standard bar, :DUUDQW\FODLPVIROORZLQJUHSDLUV cylinder fins and air filter.
chain and sprocket are printed on the
right for your convenience.
FDQEHDFFHSWHGRQO\LIWKHUHSDLUKDV
EHHQSHUIRUPHGE\DQDXWKRUL]HG
If you use a biological chain lubri-
cant (e.g. STIHL Bioplus), fill the
67,+/6HUYLFH6KRSXVLQJRULJLQDO chain oil tank.
When purchasing these parts, always
quote the saw model, the part numbers
67,+/VSDUHSDUWV Store the machine in a dry and high
or locked location - out of the
and names of the parts. Original STIHL parts can be identified reach of children and other
by the STIHL part number, unauthorized persons.
the logo STIHL6
Model
and the STIHL parts symbol
The symbol may appear alone
Machine number on small parts.

Guide bar part number * depending on market

Chain part number

Sprocket part number

 
67,+/,QFRUSRUDWHG)HGHUDO(PLVVLRQ&RQWURO:DUUDQW\6WDWHPHQW

<RXU:DUUDQW\5LJKWV Where a warrantable condition exists, As the small off-road equipment engine
DQG2EOLJDWLRQV STIHL Incorporated will repair your small owner, you should be aware, however,
off-road equipment engine at no cost to that STIHL Incorporated may deny you
The U.S. Environmental Protection you, including diagnosis (if the diagnostic warranty coverage if your small off-road
Agency (EPA), the California Air work is performed at an authorized equipment engine or a part has failed
Resources Board (CARB) and STIHL dealer), parts, and labor. due to abuse, neglect, improper mainten-
Incorporated are pleased to explain the ance or unapproved modifications.
Emission Control System Warranty on 0DQXIDFWXUHUV:DUUDQW\&RYHUDJH
your model year 2000 and later equip- The small off-road equipment engines You are responsible for presenting your
ment type engine. In California, new are warranted for two years in California. small off-road equipment engine to a
small off-road engines must be designed, In other states, 1997 and later model STIHL service center as soon as a
built and equipped to meet the States year small off-road equipment engines problem exists. The warranty repairs will
stringent anti-smog standards. In other are also warranted for two years. If any be completed in a reasonable amount of
states, new 1997 and later model year emission-related part on your engine is time, not to exceed 30 days.
small off-road equipment engines must defective, the part will be repaired or If you have any questions regarding
be designed, built and equipped, at the replaced by STIHL Incorporated free of your warranty rights and responsibilities,
time of sale, to meet the U.S. EPA charge. please contact a STIHL customer
regulations for small non road engines. service representative at 1-800-467-
The equipment engine must be free from 2ZQHUV:DUUDQW\5HVSRQVLELOLWLHV 8445 or you can write to STIHL Inc.,
defects in materials and workmanship As the small off-road equipment engine 536 Viking Drive, P.O. Box 2015,
which cause it to fail to conform with owner, you are responsible for the per- Virginia Beach, VA 23450-2015.
U.S. EPA standards for the first two formance of the required maintenance
years of engine use from the date of listed in your owners manual. STIHL
sale to the ultimate purchaser. Incorporated recommends that you &RYHUDJHE\67,+/,QFRUSRUDWHG
retain all receipts covering maintenance STIHL Incorporated warrants to the
STIHL Incorporated must warrant the on your small off-road equipment engine, ultimate purchaser and each subsequent
emission control system on your small but STIHL Incorporated cannot deny purchaser that your small off-road
off-road engine for the period of time warranty solely for the lack of receipts or equipment engine will be designed,
listed below provided there has been no for your failure to ensure the perform- built and equipped, at the time of sale,
abuse, neglect or improper maintenance ance of all scheduled maintenance. to meet all applicable regulations. STIHL
of your small off-road equipment engine. Incorporated also warrants to the initial
Any replacement part or service that is purchaser and each subsequent
Your emission control system includes equivalent in performance and durability purchaser that your engine is free from
parts such as the carburetor and the may be used in non-warranty mainten- defects in materials and workmanship
ignition system. Also included may be ance or repairs, and shall not reduce the which cause the engine to fail to
hoses, and connectors and other warranty obligations of the engine conform with applicable regulations for a
emission related assemblies. manufacturer. period of two years.

 
:DUUDQW\3HULRG :DUUDQW\:RUN 0DLQWHQDQFH5HTXLUHPHQWV
The warranty periods will begin on the STIHL Incorporated shall remedy The maintenance instructions in this
date the utility equipment engine is war-ranty defects at any authorized manual are based on the application of
purchased by the initial purchaser and STIHL servicing dealer or warranty the recommended 2-stroke fuel-oil
you have signed and sent back the station. Any such work shall be free of mixture (see also instruction "Fuel").
warranty card to STIHL. If any emission charge to the owner if it is determined Deviations from this recommendation
related part on your engine is defective, that a warranted part is defective. Any regarding quality and mixing ratio of fuel
the part will be replaced by STIHL manufacturer-approved or equivalent and oil may require shorter maintenance
Incorporated at no cost to the owner. replacement part may be used for any intervals.
Any warranted part which is not warranty mainten-ance or repairs on
scheduled for replacement as required emission-related parts and must be
maintenance, or which is scheduled only provided without charge to the owner. /LPLWDWLRQV
for regular inspection to the effect of STIHL Incorporated is liable for damages This Emission Control Systems
"repair or replace as necessary" will be to other engine components caused by Warranty shall not cover any of the
warranted for the warranty period. the failure of a warranted part still under following:
Any warranted part which is scheduled warranty.
for replacement as required mainten- - repair or replacement required
ance will be warranted for the period of The California Air Resources Boards because of misuse, neglect or lack of
time up to the first scheduled replace- Emission Warranty Parts List specifically required maintenance,
ment point for that part. defines the emission-related warranted
parts. These warranted parts are: - repairs improperly performed or
replacements not conforming to
'LDJQRVLV Carburetor STIHL Incorporated specifications that
You, as the owner, shall not be charged Choke (Cold start enrichment system) adversely affect performance and/or
for diagnostic labor which leads to the Intake manifold durability, and alterations or
determination that a warranted part is Air filter modifications not recommended or
defective. However, if you claim warranty Spark plug approved in writing by STIHL
for a component and the machine is Magneto or electronic ignition system Incorporated,
tested as non-defective, STIHL (ignition module)
Incorporated will charge you for the cost Catalytic converter (if applicable) and
of the emission test. Fasteners
Mechanical diagnostic work will be - replacement of parts and other
performed at an authorized STIHL services and adjustments necessary
servicing dealer. Emission test may be :KHUHWRPDNHDFODLPIRU:DUUDQW\ for required maintenance at and after
performed either at STIHL Incorporated 6HUYLFH the first scheduled replacement point.
or at any independent test laboratory. Bring the product to any authorized
STIHL servicing dealer and present the
signed warranty card.

 
 
Continuation of Important Safety Precautions

4. Use caution when handling fuel. 10. Do not operate a chainsaw that Manual maintenance instruc-
Move the chainsaw at least is damaged, improperly tions, should be performed by
10 feet (3 m) from the fueling adjusted, or not completely competent chainsaw service
point before starting the engine. and securely assembled. Be personnel.
sure that the saw chain stops (For example, if improper tools
5. Do not allow other persons to moving when the throttle trigger are used to remove the
be near the chainsaw when is released. flywheel or if an improper tool
starting or cutting with the is used to hold the flywheel in
chainsaw. Keep bystanders 11. Shut off the engine before order to remove the clutch,
and animals out of the work setting the chainsaw down. structural damage to the
area. flywheel could occur and could
12. Use extreme caution when be subsequently cause the
6. Do not start cutting until you cutting small size brush and flywheel to burst).
have a clear work area, secure saplings because slender mate-
footing, and a planned retreat rial may catch the saw chain 18. When transporting your chain-
path from the falling tree. and be whipped toward you or saw, use the appropriate chain
pull you off balance. guard (scabbard).
7. Keep all parts of your body
away from the saw chain when 13. When cutting a limb that is Other important safety precautions
the engine is running. under tension be alert for are contained in the body of the
springback so that you will not Owners Manual.
8. Before you start the engine, be struck when the tension in
make sure that the saw chain the wood fibers is released.
is not contacting anything. 1RWH
14. Keep the handles dry, clean,
9. Carry the chainsaw with the and free of oil or fuel mixture. When using a chainsaw for logging
engine stopped, the guide bar purposes, refer to the Code of
and saw chain to the rear, and 15. Operate the chainsaw only in Federal Regulations, Parts 1910
the muffler away from your well-ventilated areas. and 1928.
body.
16. Do not operate a chainsaw in a
tree unless you have been
specifically trained to do so.

17. All chainsaw service, other than


the items listed in the Owners
BA_U4_86_01.fm Seite 1 Donnerstag, 11. Dezember 2003 11:11 11

! WARNING!
The engine exhaust from this product
contains chemicals known to the State
of California to cause cancer, birth
defects or other reproductive harm.

0458 133 3021


englisch / English USA / EPA

You might also like