Bri
Ghris Ray- Engineering Pte Ltd
Su bea bs Fans E206 te Erat sinneecray
‘ief Operatin
dure for Model PSH systems (without
Description of the Parking System:-
This system is from Hangzhou Xizi-IUK Parking System Co Ltd utilizing
Japanese technology and design.
This type of system is able to go up 6 parking levels high without a pit. For
illustration and description, the Model PSH2 shall be used as an example.
The PSH2 consist of 2 levels of car parking platform, with 1 level of on-road
level parking platforms and 1 level of elevated parking platforms above road
level. The on-road level platforms merely slide left-right only, and the
elevated platforms above road level moves up-down only. All movement is
by using motors and chains.
The noise level emitted from this type of systems is usually approximately
55-60 db when measured 1 meter away from the system entrance at
driveway level. Where necessary, noise abatement measures can be
incorporated ie. box enclosure around motors, dampers etc., to further
control operating noise levels.
Page 1 of 3Garis Ray~
The slowest time involving the systems’ two up/down movement and one
sliding leftright movement is approximately 90 seconds. If the car is already
‘on road level, the system does not need to be moved at all.
Safety Features:-
)
ii)
ii)
)
vy
vi)
vii)
viii)
ix)
Platform’s up/down and left/right sliding movement is controlled by
limit switches to control motor function and to signal platform in
position, with additional provision for an over-run limit switch.
Intrusion photo-sensors to detect intrusion into the system when the
system is in operation. Any intrusion detected will mmediately stop
‘any movernent of the equipment.
Vehicle length photo-sensor detection to ensure that vehicles that
are in excess of the permitted designed length, the driver will not be
able to operate the system.
Vehicle height photo-sensor detection to ensure that vehicles that
are in excess of the permitted designed height, the driver will not be
able to operate the system
Chain tension detection, to automatically stop all equipment
‘movement in the event that chain tension is detected to be loose i.e.
chain breakage or otherwise etc.
Motors will have electromagnetic breaks, which in the event of a
power failure, the motor will immediately stop and brake. Preventing
any further movement of the platforms and locking them in position.
Emergency buttonis, to allow of driver to stop the system
immediately for any emergency or for whatever reasons.
When the system is operating, there will be a warning light, so as to
give a visual warning.
The system is powered using PLC software, and if there is an error
in system operations, there will be corresponding error codes to
facilitate easy trouble-shooting to reinstate the system back to
operational status.
A safety gate in front of the system can be incorporated, so that
during system operating, the gate is down on road level to prevent
any entry or intrusion into the system. Once the platform/s are in
position, the gate will be raised to allow entry of either vehicle into
the system, or driver to drive car out.
Page 3.0f3(ater Orang Rater)
ana 178 Tyan Re Het .0ng
‘Sheet -Seuatre
4 “6 Pod ai she 8
bt Y CREGin17-593-0 oman)
Specification jaar
7 Type T_ tye,
4 [a gh 5100 _
§ [Caren 2100 we
a -_
oe 3 [Paneat 700 1g
it sed O50 mn
wo
Sie ped 70-80 n/n
7 Side Eleva UR ine ene ‘mator-choin type [PROECT TLE
Elevation — die note chin pe
Wnt Zain
Sie net oak
pectin id bt eco eh) ine
Parking mode book infor out Mechanized Car Parking System
ars Ts
For ey Bh -
Power HOM SOHe 36 prawne no: ‘
Ter moa gh] Se a
or wh ben fresow ex.
Platform witNrner) 2060
Ghris- Ray
Engineering Pte Ltd
oaime cnouse
8 21 oa st rece tt a8
0 ar ir 8
— 200 250 200 ~ ae
~ Xi Zz I
are: _ovsoao7
ae bow arm pea
oe
'ON NO ACCOUNT MAY THIS DRAWING
TO. SCALED, ANY DISCREPANCIES IN
FIGURED OMENSIONS IS. TO BE