Professional Documents
Culture Documents
DATA Communication System Lab1
DATA Communication System Lab1
Objective:
Basic Router configuration and assign IP address
Requirement:
Procedure:
Step1:
First of all we open Cisco packet tracer software then select Router from pop up menu bar.
Step2:
Step3:
In Router (config) we write the interface fa0/0 by press enter this command we enter in interface
mode
Step4:
Now the Router(config if ) command appear in CLI then write Ip address and subnet mask in
order to configure the the router
Step5:
Diagram:
Explanation:
Enable command:
NO shut command;
Exit Command:
Conclusion:
In this lab we learn about the configuration of router in cisco packet tracer by using different
command as mention above procedure.