size RC Trainer, entry level nitro helicopter. Size, weight, dimension, hp specifications were obtained from helihobby and thundertiger .com's respectively. Brett Sumpter rotorcraft advisor.Higher than average*
framerates are required for proper flight-model articulation. If operating on a low frame rate machine, I recommend turning off any/all autogen, and reducing visibility to 1 mile. FPS +30 is required for proper flight model functioning with RC scale aircraft. This .30 size/scale rc heli is very sensitive to flight model flutter and on low fps machines it will tip over and crash on the runway, and/or accelerations out of limits NAN DELTHE! Error and exit the sim. Adjust the settings down to .5mi visibility and lower tx resolution to minimum. PowerbookG3 400 can operate at normal 16bit, 1mi but requires immediate takeoff and patience with the framerate flutter tipovers. Once flying it's ok. This model is also sensitive to settling with power, near ground/ in GE range.Caution: The Raptor 30 is near the limits of the x-plane RC scale handling ability. +30 FPS is required for proper operation. +40 is preferred.A dual analog stick (playstation style) controller is recommended for proper feel and orientation/ control compared to a standard dual stick 4+ channel RC transmitter. Gravis has a series of dual stick analogs. Tested with the Gravis eliminator.If using a dual stick analog controller that returns the sticks to the center, calibrate the left stick (collective for only half travel. For the left stick vertical movement axis, select collective, then move the stick from center UP, then let it return to center. This will give the STANDARD collective pitch helicopters neutral collective at neutral stick, and full collective at high stick.In x-plane helicopters, throttle is automatic. Recommended joystick setupLeft analog stick:Up/down: collective calibrated to half range for STANDARD, full range for 3DL/R: yawRight analog stick:Up/Down: pitchL/R: rollNote. If you wish to try 3D with this model. The factory recommended settings are only for -8 degree collective for a total range +12 to -8.Complete Model manual is available at: http://www.acehobby.com/manuals/heli/Raptor30V2Manual.pdf