Professional Documents
Culture Documents
HT640 Programming Guide
HT640 Programming Guide
Programming
Versions:
The HT640 can be programmed to operate as four different versions:
A All features available. (Typical default for UK sales)
B USA and Canadian modes not available, No WX channels. (Typical default for European sales)
C USA and Canadian modes not available, No WX channels, no scrambler
D Programmable channel line up. (Ideal for commercial applications)
PROGRAMMING PROCEDURE
To change version:-
Press 16/9 and A/B and switch power on - switch off as soon as display flashes.
Press 16/9 and MEM and switch power on hold buttons in until the version (A,B,C or d)
appears on the display.
Using up/down buttons select desired version and press MEM to store.
Switch radio off to complete. The version of the radio has now been set. This can be changed
back at any time.
Press WX and MEM and switch power on this time holding buttons until 01 is displayed.
Using the up/down buttons select which private channel position you want to program.
Press 16/9 and select desired channel, select power level using H/L button on side (HL-
selectable, L-fixed low power, or TX inhibit), simplex/duplex is selected using the scan button.
Press 16/9 to select next private channel position if needed and repeat above.
NOTE: In international mode P01 is programmed with M2 (161.425MHz) if no other channel has
been programmed in this position. All private channels are prefixed P and located between
channels 01 & 88.
Press 16/9 and SCAN and switch power on - switch off as soon as display flashes.
Press 16/9 and SCAN and switch power on this time holding buttons until 16 is displayed.
Note: Private channels can be programmed in the same way as the other versions.
23GGGGGGGGGGGGGGGGGGGGGGGGGGGGGGGGGGEntel UK -LondonG