Professional Documents
Culture Documents
Ford Fusion Manual EN, 0 PDF
Ford Fusion Manual EN, 0 PDF
The information contained in this publication was correct at the time of going to print. In the interest of
development the right is reserved to change specifications, design or equipment at any time without
notice and without incurring any obligations. This publication, or part thereof, may not be reproduced nor
translated without our approval. Errors and omissions excepted.
Ford Motor Company 2011
1
Table of Contents
2
Table of Contents
3
Table of Contents
Audio troubleshooting
Audio troubleshooting................................153
4
Introduction
5
Introduction
6
Introduction
E89939
Lighting
Rear lamps
Headlamp
E89940
7
At a Glance
AT A GLANCE
Instrument panel overview
Left-hand drive
A B C D E F G H I J K L
V U T S R Q P O N M
E89017
8
At a Glance
Right-hand drive
K L J I G H D E F C B A
M N O S R Q P T U V
E102295
A Window demister.
B Air vent. See Air Vents (page 58).
C Luggage compartment release.
D Main beam, direction indicators, headlamp flasher and information display
controls. See Lighting Control (page 37). See General Information (page
53).
E Instrument cluster. See Gauges (page 49).
F Wiper lever. See Wipers and Washers (page 33).
G Heated windscreen switch. See Heated Windows and Mirrors (page 62).
H Heater rear window switch. See Heated Windows and Mirrors (page 62).
I Storage tray.
J Hazard warning flasher switch. See Hazard Warning Flashers (page 39).
K Stability control switch or coin holder. See Stability Control (page 83).
9
At a Glance
L Airbag deactivated warning lamp or coin holder. See Disabling the passenger
airbag (page 23).
M Audio or navigation unit. See separate handbook.
N Climate controls. See Climate Control (page 58).
O Interior temperature sensor.
P Ignition switch. See Ignition Switch (page 72).
Q Horn.
R Steering wheel adjustment lever. See Adjusting the Steering Wheel (page
31).
S Audio controls. See Audio Control (page 31).
T Storage compartment.
U Headlamp levelling control. See Headlamp Levelling (page 39).
V Lighting controls. See Lighting (page 37).
2 3
E95179
10
At a Glance
E116252
E70436
Close the centre air vents and open the
Press the button to scroll through the side air vents.
displays and hold the button to reset,
select a submenu or change a setting. The Direct the side air vents toward the side
information display will tell you whether a windows.
short press of the button or long press of
the button is required for the various See Manual Climate Control (page 58).
options.
Automatic climate control
See Information Displays (page 53).
Recommended settings for cooling
Manual climate control
Recommended settings for cooling
E116173
11
At a Glance
Audio unit
Automatic volume control (AVC)
When available, automatic volume control
(AVC) adjusts the volume level to
compensate for engine noise and road
E72153 speed noise.
Set the temperature to 22C (72F). 1. Press the MENU button repeatedly
Open the centre and side air vents. until an AVC display appears.
2. Use the left or right arrow button, to
Direct the centre air vents upwards and the
adjust the AVC setting.
side air vents toward the side windows.
Changing the date and time
See Automatic Climate Control (page
60). 1. Press the CLOCK button to display the
date and time.
Locking and unlocking the doors 2. Use the left or right arrow button to
with the remote control select the date or time value that you
wish to change. The selected value will
flash in the display.
3. Turn the volume control to change the
selected date or time value.
4. Use the left or right arrow button to
A B C select additional date or time values
E87379
that you wish to change.
5. Turn the volume control to change the
A Unlock selected date or time value.
B Lock 6. Press the CLOCK button to exit and
save the new date and time.
C Luggage compartment lid unlock
12
At a Glance
Autowipers
E72173
E72162
13
At a Glance
1 2 3
E91009
14
Child Safety
E68916
WARNINGS
Secure children that are less than
150 centimetres (59 inches) tall in a
suitable, approved child restraint, in
the rear seat.
Extreme Hazard! Do not use a
rearward facing child restraint on a
seat protected by an air bag in front
of it!
Read and follow the manufacturers E68918
instructions when you are fitting a
child restraint. Secure children that weigh less than 13
kilograms (29 pounds) in a rearward facing
Do not modify child restraints in any baby safety seat (Group 0+) in the rear
way. seat.
Do not hold a child on your lap when
the vehicle is moving.
15
Child Safety
E68920
BOOSTER SEATS
E70710
WARNINGS
Do not install a booster seat or a We recommend that you use a booster
booster cushion with only the lap seat that combines a cushion with a
strap of the seat belt. backrest instead of a booster cushion only.
Do not install a booster seat or a The raised seating position will allow you
booster cushion with a seat belt that to position the shoulder strap of the adult
is slack or twisted. seat belt over the centre of your childs
shoulder and the lap strap tightly across
Do not put the seat belt under your its hips.
childs arm or behind its back.
Do not use pillows, books or towels
to boost your childs height.
Make sure that your children sit in an
upright position.
Secure children that weigh more
than 15 kilograms (33 pounds) but
are less than 150 centimetres (59
inches) tall in a booster seat or a booster
cushion.
16
Child Safety
CAUTION
E68924 The child seat must rest tightly
against the vehicle seat. It may be
necessary to lift or remove the head
CHILD SEAT POSITIONING restraint. See Head Restraints (page 66).
WARNINGS
Note: When using a child seat on a front
Please consult your Dealer for the seat, always adjust the front passenger seat
latest details relating to Ford to its fully rearwards position. If it proves
recommended child seats. difficult to tighten the lap section of the seat
belt without slack remaining, adjust the
seatback to the fully upright position and
raise the height of the seat. See Manual
Seats (page 64).
Seating positions 0 0+ 1 2 3
Up to 10 kg Up to 13 kg 9 - 18 kg 15 - 25 kg 22 - 36 kg
17
Child Safety
U Suitable for universal category child seats approved for use in this mass group. However,
we recommend that you secure children in a government approved child seat, in the rear
seat.
UF Suitable for universal category forward facing child seats approved for use in this
mass group. However, we recommend that you secure children in a government approved
child seat, in the rear seat.
18
Child Safety
E73697
A Lock
B Unlock
19
Occupant protection
20
Occupant protection
Seat belts
E72658 WARNINGS
Side airbags are fitted inside the seatback Wear a seat belt and keep sufficient
of the front seats. A label indicates that distance between yourself and the
side airbags are fitted to your vehicle. steering wheel. Only when you use
the seat belt properly, can it hold you in a
The side airbags will deploy during position to achieve its optimum effect. See
significant lateral collisions. Only the airbag Sitting in the Correct Position (page
on the side affected by the collision will 64).
deploy. The airbags will inflate within a few
thousandths of a second and deflate on Never use a seat belt for more than
contact with the occupants, thus providing one person.
protection for the chest and shoulder Use the correct buckle for each seat
areas. During minor lateral collisions, belt.
overturns, front collisions and rear
collisions, the side airbags will not deploy. Do not use a seat belt that is slack
or twisted.
Curtain airbags
Do not wear thick clothing. The seat
belt must fit tightly around your body
to achieve its optimum effect.
Position the shoulder strap of the
seat belt over the centre of your
shoulder and position the lap strap
tightly across your hips.
21
Occupant protection
WARNING
Seat belts subjected to strain, as a
result of an accident, should be
renewed and the anchorages
checked by a properly trained technician.
E74124
E87511
22
Occupant protection
E71313
A B
E71312
A Disabled
B Enabled
23
Occupant protection
24
Keys and Remote Controls
E72191 E72190
25
Keys and Remote Controls
E68726
26
Locks
Double locking
WARNINGS
A A
Do not activate double locking when
persons or animals are inside the
vehicle.
You will not be able to unlock the
doors from the inside if you have
double locked them.
27
Locks
A B C
E87379
A Unlock
B Lock
C Luggage compartment lid unlock
Automatic relocking
The doors will relock automatically if you
do not open a door within 45 seconds of
unlocking the doors with the remote
control. The door locks and the alarm will
return to their previous state.
28
Engine immobiliser
29
Alarm
Alarm
The alarm sounds for 30 seconds if an
unauthorised person opens a door, the
load compartment or the bonnet. The
hazard warning flashers will flash for five
minutes.
Any attempt to start the engine or to
remove the audio system sounds the alarm
again.
30
Steering Wheel
2 Volume
1
E95178
E70361
3
E95179
31
Steering Wheel
E70362
Mode
E70363
32
Wipers and Washers
33
Wipers and Washers
The rain sensor will continuously measure REAR WINDOW WIPER AND
the amount of water on the windscreen
and adjust the speed of the front wipers WASHERS
automatically (single wipe, intermittent,
normal or high speed wiping). Intermittent wiping
E72173 E72175
The sensitivity of the rain sensor is set Pull the lever towards the steering wheel.
using the rotary control:
Reverse gear wipe
1 = High sensitivity: The wipers will wipe
even if only a small amount of water is The rear wiper will be activated
detected on the windscreen. automatically when selecting reverse gear,
if
6 = Low sensitivity: The wipers will only
wipe when a larger amount of water is the rear wiper is not already switched
detected on the windscreen. on,
the wiper lever is in position C, or D
WINDSCREEN WASHERS in position B and the front wipers are
operating.
The rear wiper will follow the front wiper
interval (at intermittent or normal speed).
E72174
WARNING
Do not operate the windscreen
washer for more than 10 seconds or
when the reservoir is empty.
34
Wipers and Washers
E72176
E66644
WARNING
Do not operate the washer for more Run the tip of your fingers over the edge of
than 10 seconds at a time, and never the blade to check for roughness.
when the reservoir is empty. Clean the wiper blade lips with water
applied with a soft sponge.
Pull the lever fully towards the steering
wheel and hold it to operate the washer.
CHANGING THE WIPER
The washer will operate in conjunction with BLADES
the wipers.
The washer jet for the rear window is
located on the roof above the rear window. 4
3 5
E66645
35
Wipers and Washers
36
Lighting
Main/dipped beam
E72168
E72162
Pull the lever fully towards the steering
Note: If you have switched autolamps on, wheel to switch between main and dipped
you can only switch the main beam on when beam.
autolamps has switched the headlamps on.
37
Lighting
E72168
38
Lighting
E65990
1-2 - - 0
1-2 3 - 1
1-2 3 Max
1 1.5
1 - Max
1 2
1
See Vehicle Identification Plate (page 126).
E71943
39
Lighting
A B C
E71945
A Off
B Door contact
C On
A B C
E72167
A B C
E91006
A Off
B Door contact
C On
40
Lighting
1
5
E71946
E90592
41
Lighting
CAUTIONS
3 Do not touch the glass of the bulb.
E90593
CAUTION
Do not pull the bumper more than 10
mm from its original position.
WARNINGS
Switch the lights and the ignition off.
42
Lighting
Side repeaters
3 1
E91018
E91019
43
Lighting
2 3
E91020
E90600
C
D
E91021
44
Lighting
Reading lamps
1
E90601
E73938
1. Loosen the screws and remove the
lamp.
2. Remove the bulb.
Interior lamp
3
E73939
E73092
45
Lighting
E72784
46
Windows and Mirrors
Unfolding
Note: If you operate the switches often
Make sure that you fully engage the mirror
during a short period of time, the system
in its support when returning it to its
might become inoperable for a certain time
original position.
to prevent damage due to overheating.
ELECTRIC EXTERIOR
MIRRORS
B
A C
E66485
E93505
47
Windows and Mirrors
E66486
A up
B right
C down
D left
E72184
Automatic folding
The mirrors will fold automatically when
you lock the vehicle with the remote
control. The mirrors will unfold when you
unlock the vehicle with the key or the
remote control.
48
Instrument Cluster
GAUGES
A B C D
E89015
A Tachometer
B Engine coolant temperature gauge
C Fuel gauge
D Speedometer
E Information display
CAUTION
Engine coolant temperature gauge
Do not restart the engine until the
All vehicles cause of overheating has been
resolved.
Shows the temperature of the engine
coolant. At normal operating temperature,
the needle will remain in the centre section. If the needle enters the red section, the
engine is overheating. Stop the engine,
switch the ignition off and determine the
cause once the engine has cooled down.
49
Instrument Cluster
50
Instrument Cluster
51
Instrument Cluster
52
Information Displays
WARNING
Do not operate the information
display controls when the vehicle is
moving.
B
A
C
E D D
E91003
E
A Distance to empty or clock
B Tripmeter
C Odometer
D Select button F
E Reset button E91005
53
Information Displays
PERSONALISED SETTINGS
You can change the settings of various
functions through the information display.
54
Information Displays
E70436
55
Information Displays
56
Information Displays
57
Climate Control
Heating
MANUAL CLIMATE CONTROL
Heating performance depends on the
temperature of the engine coolant. Blower
Air conditioning
Note: The air conditioning operates only
when the temperature is above 4C (39F).
Note: If you use the air conditioning, the
fuel consumption of your vehicle will be
higher.
Air is directed through the evaporator
where it is cooled. Humidity is extracted
from the air to help keep the windows free
E90444
of mist. The resulting condensation is
directed to the outside of the vehicle and
A Off
it is therefore normal if you see a small
pool of water under your vehicle. Note: If you switch the blower off, the
windscreen may mist up.
General information on controlling
the interior climate
Fully close all the windows.
58
Climate Control
E90445
Blue Cold
Red Warm E90447
A Ventilation
F B
E C
E90448
D
E90446
A Windscreen
B Footwell and windscreen E90449
C Face level
Switching the air conditioning on
D Face level and footwell and off
E Footwell
F Face level, windscreen and
footwell
59
Climate Control
Recirculated air
E73059
E72153
E90452
60
Climate Control
61
Climate Control
AUXILIARY HEATER
Diesel auxiliary heater (depending
on country)
The diesel auxiliary heater (PTC electrical
E72157 heater) aids in warming the engine and the
Press the OFF button. interior compartment on vehicles with
diesel engines. It is switched on or off
When switched off, the heating, ventilation automatically depending on the outside
and air conditioning system is switched off temperature, the coolant temperature and
and recirculated air is selected. the alternator load.
Heated windscreen
E72506
E72507
62
Climate Control
E72189
63
Seats
SITTING IN THE CORRECT bend your legs slightly so that you can
press the pedals fully.
POSITION
position the shoulder strap of the seat
belt over the centre of your shoulder
and position the lap strap tightly across
your hips.
Make sure that your driving position is
comfortable and that you can maintain full
control of your vehicle.
MANUAL SEATS
Moving the seats backwards and
forwards
E68595
WARNINGS
Do not adjust the seats when the
vehicle is moving.
Only when you use the seat belt 2
properly, can it hold you in a position
that allows the airbag to achieve its 2
optimum effect.
64
Seats
E68896
E91008
65
Seats
CAUTION
Lower the head restraints.
E91009
Folding the seatbacks down
1. Lift the seat cushion.
1 2. Pull the locking lever and push the
1 seatback forwards.
3. Press the rear of the seatback
downwards.
HEAD RESTRAINTS
2
E86611
E75767
66
Seats
HEATED SEATS
Driver side
E81584
E90906
Adjusting the head restraint
Passenger side
WARNING
Raise rear head restraint when the
rear seat is occupied by a passenger
or a child restraint.
E90907
CAUTION
Operating the heated seats with the
engine off will drain the battery.
67
Seats
2
E95256
68
Convenience features
A B
B
E78055
WARNING C
Never hold the lighter in as this will E91002
69
Convenience features
Storage pockets
A
1
3 B
E91010
E91011
A Driver seat
B Rear seat
70
Convenience features
Activity console
Installing the activity console
E91014
E91015
71
Starting and Stopping the Engine
72
Starting and Stopping the Engine
If the engine does not start after three STARTING A DIESEL ENGINE
attempts, wait 10 seconds and follow the
Flooded engine procedure. Cold or hot engine
If you have difficulty starting the engine
when the temperature is below -25C All vehicles
(-13F), press the accelerator pedal Note: When the temperature is below -15C
between to of its travel and try again. (5F), you may need to crank the engine for
up to 25 seconds. If you consistently operate
Flooded engine the vehicle in such temperatures, we
Vehicles with manual transmission recommend that you have an engine block
heater fitted.
1. Fully depress the clutch pedal. Note: Continue cranking the engine until it
2. Fully depress the accelerator pedal and starts.
hold it there.
Note: You can only operate the starter for
3. Start the engine. a maximum of 30 seconds at a time.
Vehicles with automatic transmission Switch the ignition on and wait
until the glow plug indicator goes
1. Select park or neutral. off.
2. Fully depress the accelerator pedal and
hold it there. Vehicles with manual transmission
3. Fully depress the brake pedal. Note: Do not touch the accelerator pedal.
4. Start the engine. 1. Fully depress the clutch pedal.
All vehicles 2. Start the engine.
If the engine does not start, repeat the 3. If the engine does not start, fully
Cold or hot engine procedure. depress the brake and clutch pedals
and try again.
Engine idle speed after starting
Vehicles with automatic transmission
The speed at which the engine idles
immediately after starting will vary 1. Select park or neutral.
depending on the engine temperature. 2. Fully depress the brake pedal.
If the engine is cold then the idle speed will 3. Start the engine.
automatically be increased in order to heat
the catalytic converter as quickly as
possible. This makes sure that vehicle
emissions are kept to an absolute
minimum.
The idle speed will slowly decrease to the
normal level as the catalytic converter
warms up.
73
Starting and Stopping the Engine
74
Fuel and Refuelling
75
Fuel and Refuelling
CAUTIONS REFUELLING
Do not push-start or tow-start your
vehicle. Use booster cables. See CAUTION
Jump-Starting the Vehicle (page
Do not attempt to start the engine if
114).
you have filled the fuel tank with the
Do not switch the ignition off when incorrect fuel. This could damage the
driving. engine. Have the system checked by a
properly trained technician immediately.
FUEL FILLER FLAP
FUEL CONSUMPTION
The CO2 and fuel consumption figures are
derived from laboratory tests according to
EEC Directive 80/1268/EEC and
A subsequent amendments and are carried
out by all vehicle manufacturers.
They are intended as a comparison
between makes and models of vehicles.
They are not intended to represent the real
world fuel consumption you may get from
your vehicle. Real world fuel consumption
B is governed by many factors including;
driving style, high speed driving, stop/start
E75775
driving, air conditioning usage, the
accessories fitted and towing etc.
Your Ford dealer can give you advice on
improving your fuel consumption.
TECHNICAL SPECIFICATIONS
Fuel Consumption Figures
CO2 Emis-
Urban Extra-Urban Combined
sions
Variant
l/100 km l/100 km l/100 km
g/km
(mpg) (mpg) (mpg)
76
Fuel and Refuelling
CO2 Emis-
Urban Extra-Urban Combined
sions
Variant
l/100 km l/100 km l/100 km
g/km
(mpg) (mpg) (mpg)
77
Transmission
E90581
R Reverse
N Neutral
D Drive (automated)
+/- Drive (manual)
A Drive mode
WARNINGS
Apply the brakes before moving the
selector lever and keep them applied
until you are ready to move off.
E75050
Select reverse only when your vehicle
CAUTION is stationary and the engine is at idle
speed.
Do not engage reverse gear when the
vehicle is moving. This can cause
damage to the transmission. Note: A cold engine has a higher idle speed.
This will increase the tendency for your
vehicle to creep when you have selected a
Note: Fully depress the clutch pedal and drive gear.
wait for three seconds before you select
reverse gear. The selected gear will be shown in the
information display. If it flashes, apply the
brakes or press the accelerator pedal to
move off.
Push the lever to the left (drive mode) to
select manual drive or automated drive.
Moving off
1. Release the parking brake.
78
Transmission
Reverse
E83164
WARNING
P Park
Select reverse only when your vehicle
R Reverse is stationary and the engine is at idle
N Neutral speed.
D Drive
79
Transmission
Neutral
In this position, power is not transmitted
to the drive wheels but the transmission is
not locked. You can start the engine with
the selector lever in this position.
Drive
Select drive to shift automatically through
the forward gears.
2nd Gear
Select 2, the transmission will
automatically shift between 2nd and 1st
E83165
gears only.
When you are travelling in slow moving
1st Gear
traffic or climbing steep gradients there
Select 1, the transmission will select 1st may be a tendency for the transmission to
gear only. continually shift between 4th and 3rd
gears. If this condition should arise switch
Hints on driving with an automatic the overdrive function off.
transmission Note: The transmission will only select
Moving off between 1st, 2nd and 3rd gears if the
overdrive function has been switched off.
1. Release the parking brake.
Drive modes
2. Release the brake pedal and press the
accelerator pedal. The transmission will select the
appropriate gear for optimum performance
Stopping based on ambient temperature, road
1. Release the accelerator pedal and gradient, vehicle load and driver input.
press the brake pedal.
Emergency park position release
2. Apply the parking brake. lever
Kickdown Use the lever to move the selector lever
from the park position in the event of an
Press the accelerator pedal fully with the
electrical malfunction or if your vehicle has
selector lever in the drive position to select
a flat battery.
the next highest gear for optimum
performance. Release the accelerator
pedal when you no longer require
kickdown.
Overdrive
Note: The transmission is normally in
overdrive when drive is selected.
80
Transmission
E83166
81
Brakes
ABS
WARNING
E66567
The ABS does not relieve you of your
responsibility to drive with due care WARNING
and attention.
Make sure that the parking brake is
applied before you release the lever.
The ABS helps you to maintain full steering
and directional stability when you brake
heavily in an emergency, by preventing the Note: Do not press the release button when
road wheels from locking. you apply the parking brake.
1. Press the brake pedal firmly.
HINTS ON DRIVING WITH 2. Pull the parking brake lever upwards
ANTI-LOCK BRAKES to its fullest extent.
Parking on a hill
When the ABS is operating, the brake pedal
will pulse. This is normal. Maintain pressure If you have to park facing uphill, select first
on the brake pedal. gear and turn the front wheels away from
The ABS will not eliminate the dangers the kerb. If you have to park facing
inherent when: downhill, select reverse gear and turn the
front wheels towards the kerb.
you drive too close to the vehicle in
front of you. Releasing the parking brake
the vehicle is aquaplaning.
1. Press the brake pedal firmly.
you take corners too fast.
2. Pull the parking brake lever upwards
the road surface is poor. slightly, press the release button and
push the lever downwards.
82
Stability Control
E72903
A Without ESP
B With ESP
83
Parking Aids
PRINCIPLE OF OPERATION Note: The parking aid may emit false tones
if it detects a signal using the same
frequency as the sensors or if the vehicle is
WARNING
fully laden.
The parking aid does not relieve you
Note: The outer sensors may detect the
of your responsibility to drive with
side walls of a garage. If the distance
due care and attention.
between the outer sensor and the side wall
remains constant for three seconds, the
CAUTIONS tone will switch off. As you continue, the
Vehicles fitted with a trailer tow inner sensors will detect rearward objects.
module not approved by us may not
correctly detect obstacles. USING THE PARKING AID
The sensors may not detect objects
in heavy rain or other conditions that Switching the parking aid on and
cause disruptive reflections. off
The sensors may not detect objects Note: The parking aid switches off
with surfaces that absorb ultrasonic automatically when you start the engine or
waves. when you exceed 16 km/h (10 mph).
The parking aid does not detect Note: The front and rear sensors are always
obstacles moving away from the activated or deactivated together.
vehicle. They will only be detected
shortly after they start to move towards The parking aid is per default off. To switch
the vehicle again. the parking aid on, press the switch in the
instrument panel or select reverse gear.
Take particular care when reversing
with a tow ball arm or rear fitted The light in the switch illuminates when
accessories e.g. a bicycle carrier, as the parking aid is activated.
the rear parking aid will only indicate the To turn it off, press the switch again.
distance from the bumper to the obstacle.
If you use a high pressure spray to Manoeuvring with the parking aid
wash your vehicle, only spray the
sensors briefly from a distance not
less than 20 centimetres (8 inches).
84
Parking Aids
85
Load Carrying
GENERAL INFORMATION
1
WARNINGS
Use load securing straps to an
approved standard, e.g. DIN.
Make sure that you secure all loose
items properly.
Place luggage and other loads as low
and as far forward as possible within 2
the luggage or loadspace. E72512
86
Load Carrying
before starting
after driving 50 kilometres (30 miles)
at 1000 kilometres (600 miles)
intervals.
87
Towing
88
Towing
Unlocking the tow ball arm Inserting the tow ball arm
mechanism
WARNING
Do not use any tools for mounting or
dismounting the tow ball arm. Do not
modify the trailer coupling. Do not
disassemble or repair the tow ball arm.
2
E71329
89
Towing
E71331 B
WARNING 2
If any of the below conditions cannot
be met, do not use the tow bar and
have it inspected by an expert.
90
Towing
Maintenance
WARNING
Remove the tow ball arm and
protect the seat with the plug before
steam cleaning your vehicle.
91
Driving Hints
92
Roadside Emergencies
E87654
WARNING TRIANGLE
Space is provided in the spare wheel well.
93
Status after a collision
E90982
94
Status after a collision
95
Fuses
CAUTION
Fit a replacement fuse with the same
rating as the one you have removed.
Airbag
ABS
96
Fuses
Horn
97
Fuses
Durashift EST
Brake lamps
Reversing lamp
98
Vehicle recovery
CAUTIONS
Too much tension in the tow rope
could cause damage to your vehicle
or the vehicle that is towing.
Do not use a rigid tow bar on the front
towing eye.
99
Maintenance
CAUTION
When carrying out maintenance
checks, make sure that filler caps are
fitted securely.
Daily checks
Exterior lamps.
Interior lamps.
Warning lamps and indicators.
100
Maintenance
OPENING AND CLOSING THE 2. Raise the bonnet slightly and pull the
catch towards you.
BONNET
Opening the bonnet
E90413
E78143
E90414
101
Maintenance
A B C D E F
J I H G
E90583
*
A Engine coolant reservoir : See Engine Coolant Check (page 107).
*
B Brake and clutch fluid reservoir (right-hand drive) : See Brake and Clutch
Fluid Check (page 108).
*
C Engine oil filler cap : See Engine Oil Check (page 107).
D Engine compartment fuse box. See Fuses (page 96).
102
Maintenance
*
E Brake and clutch fluid reservoir (left-hand drive) : See Brake and Clutch Fluid
Check (page 108).
F Battery: No maintenance necessary.
G Windscreen and rear window washer fluid reservoir: See Washer Fluid Check
(page 109).
H Air cleaner: No maintenance necessary.
*
I Engine oil dipstick : See Engine Oil Check (page 107).
J Power steering fluid reservoir: See Power Steering Fluid Check (page 108).
*
The filler caps and the engine oil dipstick are coloured for easy identification.
103
Maintenance
A B C D E F
J I H G
E90585
*
A Engine coolant reservoir : See Engine Coolant Check (page 107).
*
B Brake and clutch fluid reservoir (right-hand drive) : See Brake and Clutch
Fluid Check (page 108).
*
C Engine oil filler cap : See Engine Oil Check (page 107).
D Engine compartment fuse box. See Fuses (page 96).
*
E Brake and clutch fluid reservoir (left-hand drive) : See Brake and Clutch Fluid
Check (page 108).
F Battery: No maintenance necessary.
104
Maintenance
G Windscreen and rear window washer fluid reservoir: See Washer Fluid Check
(page 109).
H Air cleaner: No maintenance necessary.
*
I Engine oil dipstick : See Engine Oil Check (page 107).
J Power steering fluid reservoir: See Power Steering Fluid Check (page 108).
*
The filler caps and the engine oil dipstick are coloured for easy identification.
A B C D E F
K J I H G
E90586
105
Maintenance
*
A Engine coolant reservoir : See Engine Coolant Check (page 107).
*
B Brake and clutch fluid reservoir (right-hand drive) : See Brake and Clutch
Fluid Check (page 108).
*
C Engine oil filler cap : See Engine Oil Check (page 107).
D Engine compartment fuse box. See Fuses (page 96).
*
E Brake and clutch fluid reservoir (left-hand drive) : See Brake and Clutch Fluid
Check (page 108).
F Battery: No maintenance necessary.
G Windscreen and rear window washer fluid reservoir (left-hand drive): See
Washer Fluid Check (page 109).
H Air cleaner: No maintenance necessary.
*
I Engine oil dipstick : See Engine Oil Check (page 107).
J Power steering fluid reservoir: See Power Steering Fluid Check (page 108).
K Windscreen and rear window washer fluid reservoir (right-hand drive): See
Washer Fluid Check (page 109).
*
The filler caps and the engine oil dipstick are coloured for easy identification.
E95911
E95540
A MIN
A MIN
B MAX
B MAX
106
Maintenance
ENGINE OIL DIPSTICK - 1.6L Remove the dipstick and wipe it with a
clean, lint free cloth. Replace the dipstick
DURATORQ-TDCI (DV) DIESEL and remove it again to check the oil level.
Topping up
WARNINGS
Only top up when the engine is cold.
E90983
If the engine is hot, wait 10 minutes
for the engine to cool down.
A MIN Do not remove the filler cap when
the engine is running.
B MAX
107
Maintenance
108
Maintenance
TECHNICAL SPECIFICATIONS
Vehicle fluids
Item Specification Recommended fluid
Note: If you operate your vehicle in temperatures below -20C (68F), you must not use
SAE 10W-40 engine oil.
Castrol engine oil recommended.
109
Maintenance
E115472
Capacities
110
Maintenance
111
Vehicle care
Cleaning the rear window Clean the seat belts with interior cleaner
or water applied with a soft sponge. Let
CAUTION the seat belts dry naturally, away from
artificial heat.
Do not scrape the inside of the rear
window or use abrasives or chemical
solvents to clean it.
112
Vehicle care
Rear windows
CAUTIONS
Do not use any abrasive materials to
clean the interior of the rear windows.
Do not install stickers or labels to the
interior of the rear windows.
113
Vehicle battery
CAUTIONS
Connect batteries with only the same
nominal voltage.
Always use booster cables with
insulated clamps and adequate size
cable.
Do not disconnect the battery from
the vehicles electrical system.
E90587
114
Vehicle battery
1. Position the vehicles so that they do Disconnect the cables in the reverse order.
not touch one another.
2. Switch off the engine and any electrical
equipment.
3. Connect the positive (+) terminal of
vehicle A with the positive (+) terminal
of vehicle B (cable C).
4. Connect the negative (-) terminal of
vehicle B to the engine block or engine
mount of vehicle A (cable D), as far
from the battery as possible.
CAUTIONS
Do not connect to the negative ()
terminal of the flat battery.
Make sure that the jump leads are
clear of any moving parts.
115
Wheels and Tyres
116
Wheels and Tyres
Note: Use a jack with a minimum lifting Jacking and lifting points
capacity of 1.5 tonnes and a lifting plate with
a minimum diameter of 80 millimetres (3.1 CAUTION
inches). Use only the specified jacking points.
Your vehicle jack, wheel brace, screw-in If you use other positions, you may
towing eye and wheel trim remover are damage the body, steering,
located in the spare wheel well. suspension, engine, braking system or the
fuel lines.
E92658
117
Wheels and Tyres
A WARNING
When returning the wheel brace
extension to its original position, take
care not to get your fingers caught.
E93184
Indentations in the sills A show the Note: Make sure that the wheel brace is
location of the jacking points. fully extended.
E122546
Type two
CAUTION
The screw-in towing eye has a
E92932
left-hand thread. Turn it
anti-clockwise to install it. Make sure
that the towing eye is fully tightened.
E93020 E122502
Note: If your vehicle is fitted with side skirts, Insert the screw-in towing eye into the
remove the cover before positioning the wheel brace.
vehicle jack.
118
Wheels and Tyres
119
Wheels and Tyres
WARNINGS
Do not fit run flat tyres on vehicles
that were not originally fitted with
them. Please contact your dealer for
more details regarding compatibility.
Make sure that the arrows on
directional tyres point in the direction
of rotation when the vehicle is
moving forwards. If you have to fit a spare
1 wheel with the arrows pointing in the
opposite direction, have the tyre refitted
in the correct direction by a properly
trained technician.
CAUTION
2 Do not install alloy wheels using
wheel nuts designed for use with steel
wheels.
120
Wheels and Tyres
5. Lower the vehicle and remove the jack. Drive with caution and avoid
6. Fully tighten the wheel nuts in the making sudden steering or driving
sequence shown. See Technical manoeuvres, especially if the vehicle
Specifications (page 125). is heavily loaded or you are towing a
trailer.
7. Install the wheel trim using the ball of
your hand. The kit will provide you with an
emergency temporary repair, enabling
you to continue your journey to the next
TYRE REPAIR KIT vehicle or tyre dealer, or to drive a
maximum distance of 200 kilometres
Your vehicle may not have a spare tyre. In (125 miles).
this case it will have an emergency tyre Do not exceed a maximum speed of
repair kit that can be used to repair one 80 km/h (50 mph).
flat tyre.
Keep the kit out of the reach of
The tyre repair kit is located in the spare children.
wheel well.
Only use the kit when the ambient
General information temperature is between 30C (-22F)
and +70C (+158F).
WARNINGS
Using the tyre repair kit
Depending on the type and extent of
tyre damage, some tyres can only be WARNINGS
partially sealed or not sealed at all.
Compressed air can act as an
Loss of tyre pressure can affect vehicle
explosive or propellant.
handling, leading to loss of vehicle control.
Do not use the tyre repair kit if the Never leave the tyre repair kit
tyre has already been damaged as a unattended while in use.
result of being driven under inflated.
Do not use the tyre repair kit on run CAUTION
flat tyres. Do not keep the compressor operating
Do not try to seal damage other than for more than 10 minutes.
that located within the visible tread
of the tyre. Note: Use the tyre repair kit only for the
Do not try to seal damage to the vehicle with which it was supplied.
tyres sidewall. Park your vehicle at the roadside so
that you do not obstruct the flow of
The tyre repair kit seals most tyre traffic and so that you are able to use
punctures [with a diameter of up to six the kit without being in danger.
millimetres (1/4 inch)] to temporarily Apply the parking brake, even if you
restore mobility. have parked on a level road, to make
sure that the vehicle will not move.
Observe the following rules when using the
kit: Do not attempt to remove foreign
objects like nails or screws penetrating
the tyre.
121
Wheels and Tyres
122
Wheels and Tyres
2. Peel off the label A showing the 14. Quickly unscrew the hose C from the
maximum permissible speed of tyre valve. Fasten the valve cap again.
80 km/h (50 mph) from the sealant 15. Leave the sealant bottle B in the
bottle and attach it to the instrument bottle holder D.
panel in the drivers field of view. Make
sure the label does not obscure 16. Make sure the kit is stored safely, but
anything important. still easily accessible in the vehicle.
The kit will be required again when
3. Take the hose H with the pressure you check the tyre pressure.
relieve valve I and the power plug with
cable F out of the kit. 17. Immediately drive approximately
three kilometres (two miles) so that
4. Connect the hose H with the pressure the sealant can seal the damaged
relieve valve I to the sealant bottle B. area.
5. Engage the sealant bottle B into the
WARNING
bottle holder D.
6. Remove the valve cap from the If you experience heavy vibrations,
damaged tyre. unsteady steering behaviour or
noises while driving, reduce your
7. Screw the sealant bottle hose C firmly speed and drive with caution to a place
onto the valve of the damaged tyre. where it is safe for you to stop the vehicle.
8. Make sure that the compressor switch Recheck the tyre and its pressure. If the
G is in position 0. tyre pressure is less than 1 bar (14.7 psi) or
9. Insert the power plug F into the cigar if there are any cracks, bumps or similar
lighter socket or auxiliary power socket. damage visible, do not continue driving
See Cigar Lighter (page 69). with this tyre.
10. Start the engine.
18. Stop the vehicle after driving
11. Move the compressor switch G to approximately three kilometres
position 1. (two miles). Check, and where
12. Inflate the tyre for no longer than 10 necessary, adjust the pressure of the
minutes to an inflation pressure of damaged tyre.
minimum 1.8 bar (26 psi) and a 19. Attach the kit and read the tyre
maximum of 3.5 bar (51 psi). Move pressure from the pressure gauge E.
the compressor switch G to position
20. Adjust it to the specified pressure.
0 and check the current tyre pressure
See Technical Specifications
with pressure gauge E.
(page 125).
Note: If a tyre pressure of 1.8 bar (26 psi)
21. Once you have inflated the tyre to its
is not reached do not continue.
correct tyre pressure, move the
Note: When pumping in the sealant through compressor switch G to position 0,
the tyre valve, the pressure may rise up to remove the power plug F from the
6 bar (87 psi) but will drop again after about socket, unscrew the hose C and
30 seconds. fasten the valve cap.
13. Remove the power plug F from the 22. Leave hose C and H connected to the
cigar lighter socket or auxiliary power sealant bottle B and store the kit
socket. away safely.
123
Wheels and Tyres
23. Drive to the nearest tyre specialist to To make sure the front and rear tyres of
get the damaged tyre replaced. your vehicle wear evenly and last longer,
Before the tyre is removed from the we recommend that you swap the tyres
rim, inform your tyre dealer that the from front to rear and vice versa at regular
tyre contains sealant. Renew the intervals of between 5000 and 10000
sealant bottle B and hose C as soon kilometres (3000 and 6000 miles).
as possible after they have been
used. CAUTION
Note: Remember that emergency roadside Do not scrub the sidewalls of the tyres
tyre repair kits only provide temporary when you are parking.
mobility. Regulations concerning tyre repair
after usage of tyre repair kit may differ from If you have to mount a kerb, do so slowly
country to country. You should consult a and approach it with the wheels at
tyre specialist for advice. right-angles to the kerb.
WARNING Examine the tyres regularly for cuts, foreign
objects and uneven wear of the tread.
Before driving, make sure the tyre is
Uneven wear could mean that the wheel
adjusted to the recommended
alignment is outside specification.
inflation pressure. See Technical
Specifications (page 125). Monitor the Check the tyre pressures (including the
tyre pressure until the sealed tyre is spare) when cold, every two weeks.
replaced.
USING WINTER TYRES
Empty sealant bottles can be disposed of
together with normal household waste. CAUTION
Return remains of sealant to your dealer
or dispose of it in compliance with local Make sure that you use the correct
waste disposal regulations. wheel nuts for the type of wheel the
winter tyres are fitted to.
TYRE CARE
If winter tyres are used, make sure that the
tyre pressures are correct. See Technical
Specifications (page 125).
124
Wheels and Tyres
TECHNICAL SPECIFICATIONS
Wheel nut torque
Variant Specification Nm (lb-ft)
All speeds
Normal load Full load
125
Vehicle identification
E87496
126
Capacities and Specifications
DIMENSIONS
Vehicle dimensions
E
B
E91022
127
Capacities and Specifications
128
Capacities and Specifications
G
E90357
129
Capacities and Specifications
130
Audio introduction
IMPORTANT AUDIO
INFORMATION
WARNINGS
Due to technical incompatibility, E66257
E66256
131
Audio unit overview
O F
G G
N H
M L K J I
E138367
132
Audio unit overview
6006CDC
A B C D E
P F
H H
O I
E138369
N M L K J
133
Audio unit overview
Sony CD
A B C D E F
G
S
R H
Q I
P J
E138370 O N M L K
A Scan. See Station tuning control (page 143). See Compact disc track
scanning (page 150).
B Information. See Audio unit operation (page 138). See Audio unit menus
(page 145). See Compact disc player (page 148). See Audio troubleshooting
(page 153).
C Station presets. See Station preset buttons (page 141).
D CD aperture. See Loading compact discs (page 148).
E Clock. See Setting the clock and date on the audio unit (page 137).
F DSP select. See Digital signal processing (DSP) (page 145).
G Autostore. See Autostore control (page 141).
H Menu. See Audio menu control (page 138).
I Traffic announcement. See Traffic information control (page 141).
134
Audio unit overview
135
Audio system security
136
Audio unit clock and date displays
137
Audio unit operation
138
Audio unit operation
During radio recep- During tape playback During CD playback During all functions
tion
AVC
* - Comp News
Sony CD
Menu functions
139
Audio unit operation
Menu functions
3 3
TA volume TA volume
Traffic local or distant Traffic local or distant
Regional ON/OFF Shuffle
- Repeat
- Comp ON/OFF
Note: The sequence in which functions appear may vary for different audio units and
vehicles.
1
Automatic volume control.
2
Alternative frequencies.
3
Traffic announcement.
140
Audio unit operation
141
Audio unit operation
142
Audio unit operation
Switching DAB service linking off Select a waveband and briefly press the
up or down navigation button to tune up
1. Press the MENU button. or down the waveband in small
2. Using the up or down navigation button increments. The display shows the
scroll through the display until DIGITAL frequency selected.
RADIO SERVICE LINK is shown in the
display. Scan tuning
3. Using the left or right navigation button The scan function allows you to listen to
select OFF. 10 seconds of each station detected.
4. Press the MENU button or the button
between the navigation buttons to
confirm your selection.
143
Audio unit operation
Sony CD
1. Press the SCAN button. SCAN flashes
or SCANNING is shown in the display.
2. Press the left or right navigation button
to scan within a waveband.
3. Press the SCAN button to continue
listening to a station.
144
Audio unit menus
145
Audio unit menus
146
Audio unit menus
3. Using the seek up or seek down button 3. Press the button between the
turn the function on or off. navigation buttons to make your
4. Press the MENU button or allow the selection.
system to time out to confirm your 4. Using the left or right navigation button
selection. turn the function on or off.
5. Press the MENU button or the button
Sony CD between the navigation buttons to
1. Press the MENU button briefly. confirm your selection.
2. Using the up or down navigation button
scroll through the display until
REGIONAL is shown in the display.
3. Press the MENU button or allow the
system to time out to confirm your
selection.
NEWS BROADCASTS
Some audio units interrupt normal
reception to broadcast news bulletins from
stations on the FM waveband linked
stations, in the same way as traffic
information is provided.
During news broadcasts, the display
alternates between the station name and
NEWS. News interrupts are broadcast at
the same preset volume level as traffic
announcements.
Sony CD
1. Press the MENU button.
2. Using the up or down navigation button
scroll through the display until NEWS
is shown in the display.
147
Compact disc player
148
Compact disc player
Press the down navigation button once to The unit remembers which CD's are
replay the current track. If pressed within available so it will not select a CD that it
two seconds of the start of a track, the knows to be missing. If you select a missing
previous track will be selected. CD using the preset buttons, NO CD will
be shown in the display and playback will
Press the down navigation button
continue from the current disc.
repeatedly to select previous tracks.
Note: If a selected CD is damaged or upside
down, the warning CD ERROR flashes and
COMPACT DISC PLAYBACK the CD number is displayed. The unit then
selects the next available CD.
Note: During playback, the display indicates
the disc, track and time that has elapsed
since the start of the track. FAST FORWARD/REVERSE
Note: On CD changer audio units, if two or
more CD's are loaded one after the other, 6000CD and 6006CDC
playback will start with the last CD loaded. Press and hold the seek up or the seek
down button to search forwards or
6000CD and 6006CDC backwards within the tracks on the disc.
During radio reception, press the CD button
once to start CD playback. Sony CD
Playback will start immediately after a disc Press and hold the left or right navigation
is loaded. button to search forwards or backwards
within the tracks on the disc.
Sony CD
During radio reception, press the CD/AUX SHUFFLE/RANDOM
button once to start CD playback.
Random track playback, also known as
Playback will start immediately after a disc shuffle, plays all tracks on a CD in random
is loaded. order.
You can, however, switch to a CD of your 1. Press the MENU button repeatedly
choice by pressing the preset button, which until SHUF is shown in the display.
has the number corresponding to the disc 2. Using the seek up or seek down button
you want to play. The display will show scroll through the display until SHUF
which CD is selected. ALL or SHUFF CD is shown in the
display.
3. Using the seek up or seek down button
select the next track to shuffle if
required.
149
Compact disc player
Note: With the function on, SHUFFLE will 6000CD and 6006CDC
be shown in the display as each new track
is selected. Note: When selected, SCAN will be shown
briefly in the display at the start of each
Sony CD track.
Sony CD
COMPACT DISC TRACK
1. Press the SCAN button once to scan
COMPRESSION each track.
2. Press the SCAN button again to select
6000CD and 6006CDC SCAN OFF.
1. Press MENU repeatedly until COMP is
shown in the display. EJECTING COMPACT DISCS
2. Using the seek up or seek down button
turn the function on or off. Note: Radio reception is restored
3. Press the MENU button to confirm automatically when the EJECT button is
your selection. pressed.
Note: If the EJECT button is pressed in error,
Sony CD press the button again to cancel.
1. Press the MENU button. Note: If the CD is not removed it will be
2. Using the up or down navigation button pulled back into the audio unit.
scroll through the display until COMP
is shown in the display. 6000CD
3. Press the button between the Press the EJECT button at any time and
navigation buttons to make your remove the CD.
selection.
4. Using the left or right navigation button 6006CDC
turn the function on or off. Press the EJECT button at any time and
5. Press the MENU button or the button remove the CD being played or use a preset
between the navigation buttons to button to select the CD you want to
confirm your selection. remove. SELECT or SELECT CD followed
by REMOVE CD will be shown in the
display.
COMPACT DISC TRACK
SCANNING
The SCAN function allows you to preview
each track for approximately 10 seconds.
150
Compact disc player
Sony CD Note: This will not eject the CD; the disc
will merely pause at the point where radio
Note: If no CD is loaded when the EJECT reception was restored.
button is pressed, NO CD will be shown in
the display. To resume CD playback, press the CD
button again.
Press the EJECT button at any time and
remove the CD. EJECTING and PLEASE Sony CD
REMOVE will be shown in the display.
Press the RADIO or CD/AUX button.
REPEAT COMPACT DISC Note: This will not eject the CD; the disc
will merely pause at the point where radio
TRACKS reception was restored.
6000CD To resume CD playback, press the
CD/AUX button.
1. Press the MENU button repeatedly
until REPEAT is shown in the display.
EJECTING MULTIPLE
2. Using the seek up or seek down button
choose between OFF and TRK. COMPACT DISCS
6006CDC 6006CD
1. Press the MENU button repeatedly Press and hold the EJECT button until
until REPEAT is shown in the display. EJECT ALL is shown in the display.
2. Using the seek up or seek down button The display will alternate between
choose between ALL (default), CD and REMOVE and WAIT.
TRK. When REMOVE is displayed, remove a
Sony CD disc from the unit. This routine repeats until
all discs have been removed.
1. Press the MENU button.
2. Using the up or down navigation
buttons scroll through the display until
REPEAT is shown in the display.
3. Using the left or right navigation
buttons select REPEAT TRACK or
REPEAT OFF.
4. Press the MENU button to confirm
your selection.
151
Auxiliary input (AUX IN) socket
152
Audio troubleshooting
AUDIO TROUBLESHOOTING
153
Audio troubleshooting
154
Telephone
155
Telephone
156
Telephone
157
Telephone
Voice and mode button Note: Some audio units have the
accept/reject buttons on the front bezel.
1 These operate in the same way.
E87661
E87663
1 Voice button
Mode button only
2 Mode button
1
E87664
E87662
2 Note: You will not be able to use the MODE
button to activate the voice control during
an incoming or active call.
1 Voice button
You will not be able to use the MODE button
2 Accept/Reject button
to control the audio system.
The VOICE button is used to activate or
switch off the Voice control. USING THE TELEPHONE -
On vehicles with an accept/reject button, VEHICLES WITHOUT:
phone calls can be accepted and rejected
by pressing the appropriate button.
NAVIGATION SYSTEM
This chapter describes the phone functions
of the audio unit.
158
Telephone
Note: Refer to your audio guide for details Press and hold 0 to enter a + digit.
of the controls.
Ending a call
An active phone must be present.
Calls can be ended by either:
Even if connected to the audio unit, your
phone can still be used in the usual way. pressing one of the following buttons
on the audio unit: PHONE, CD,
Note: You can exit the phone menu by
AM/FM or ON/OFF
pressing any source button CD, AM/FM or
AUX. pressing the MODE button on the
remote control
Making a call pressing the call reject button.
Dialling a number Note: If you have an audio unit with a
telephone keypad you can end a call only
You can access your phone address book with the call reject button.
either with the phone docked in the cradle
or via Bluetooth. The entries will appear in Redialling a number
the audio unit display.
1. Press the PHONE or the call accept
1. Press the PHONE or the call accept button.
button.
2. Press the MENU button.
2. Press the MENU button.
3. Select the CALL OUT list or the CALL
3. Keep pressing the MENU button until IN list.
PHONEBOOK appears.
Note: If the active phone does not provide
4. Press the seek buttons to select the a call out list, the last outgoing call
desired phone number. number/entry is displayed.
Note: Press and hold the seek button to 4. Press the seek button on the audio unit.
skip to the next letter in the alphabet.
5. Press the PHONE or the call accept
5. Press the PHONE or the call accept button to dial the desired phone
button to dial the selected phone number.
number.
If you have an audio unit with a telephone Redialling the last dialled number
keypad (buttons 0-9, * and #), you can Note: This applies to only audio units with
also direct dial by entering the number on a telephone keypad
the radio display via the keypad and
pressing the call accept button: 1. Press the call accept button.
1. Press the call accept button. 2. Press the call accept button again to
display the last dialled number.
2. Dial the number using the telephone
keypad on the audio unit. 3. Press the call accept button a third
time to dial the number.
3. Press the call accept button.
Note: If you enter an incorrect digit whilst Receiving an incoming call
entering a phone number, press the seek
down button to erase the last digit. A long Accepting an incoming call
press will erase the complete string of digits. Incoming calls can be accepted by either:
159
Telephone
pressing the PHONE button Note: If you have an audio unit with a
pressing the MODE button on the telephone keypad you can only reject a call
remote control with the call reject button.
pressing the call accept button. Changing the active phone
Rejecting an incoming call Note: Phones must be bonded to the
system before they can be made active.
Incoming calls can be rejected by either:
pressing the call reject button Using the station storage button
pressing the CD button 1. Press the PHONE button on the audio
pressing the AM/FM button. unit.
Note: If you have an audio unit with a 2. Press the preset number required
telephone keypad you can only reject a call (using the station preset buttons 1 - 6).
with the call reject button. Note: This process is only for audio units
Note: You cannot reject an incoming call without a telephone keypad.
using the remote control. Using the audio unit menu
Handling a second incoming call 1. Press the PHONE or call accept
button.
Note: The second incoming call function
must be activated in your phone. 2. Press the MENU button on the audio
unit.
If there is an incoming call whilst there is
an ongoing call, a beep will be heard and 3. Select the ACTIVE PHONE option on
you will have the option to end the active the audio unit.
call and to accept the incoming call. 4. Scroll through the different stored
phones by using the seek buttons to
Accepting a second incoming call display the bonded phones.
Second incoming calls can be accepted 5. Press the MENU button to select the
by either: phone which is to be the active phone.
pressing the call accept button Note: After bonding a Bluetooth phone to
pressing the MODE button on the the system, this becomes the active phone.
remote control
Debonding a bonded phone
pressing the PHONE button.
A bonded phone can be deleted from the
Note: This will cancel the ongoing call. system at any time, unless a phone call is
Rejecting a second incoming call in progress.
1. Press the PHONE or call accept
Second incoming calls can be rejected by button.
pressing either:
2. Press the MENU button on the audio
pressing the call reject button unit.
pressing the CD button 3. Select the DEBOND option on the
pressing the AM/FM button. audio unit.
160
Telephone
161
Telephone
162
Voice control
163
Voice control
Short cuts
There are a number of voice command
short cuts available, which allow you to
control some vehicle features without
having to follow the complete command
menu. These are:
1
phone: "MOBILE NAME" , "DIAL
NUMBER", "DIAL NAME" and "REDIAL"
CD player: "DISC" and "TRACK"
climate control: "TEMPERATURE",
"FAN", "AUTO MODE",
"DEFROSTING/DEMISTING ON" and
"DEFROSTING/DEMISTING OFF"
radio: "TUNE NAME"
navigation: "ZOOM" and "ROUTE
SETTING".
1) Only when the mobile phone is fitted
with Bluetooth and voice control
Overview
The overview below shows the available
voice commands for operating your CD
player. The following lists will give further
information about the complete command
menu.
"CD"
"HELP"
a
"DISC"
164
Voice control
"CD"
b
"TRACK"
Disc
If you have a CD changer you can choose
the disc number.
1 "CD" "CD"
2 "DISC"
a "DISC NUMBER PLEASE"
Track
You can also choose a track on your CD
directly.
1 "CD" "CD"
2 "TRACK"
a "TRACK NUMBER PLEASE"
Overview
Radio
The overview below shows the available
The radio voice commands support the voice commands for operating your radio.
functionality of the radio and allow you to The following lists will give further
tune radio stations by voice control. information about the complete command
menu.
165
Voice control
"RADIO"
"HELP"
"AM"
"FM"
a
"TUNE NAME"
"DELETE NAME"
"DELETE DIRECTORY"
"PLAY DIRECTORY"
"STORE NAME"
Tune frequency
This function allows you to tune your radio
by voice commands.
1 "RADIO" "RADIO"
2 "AM" "FREQUENCY PLEASE"
"FM" "FREQUENCY PLEASE"
3 "<frequency>" "TUNE <frequency>"
Store name
If you have tuned a radio station, you can
store it with a name in the directory.
1 "RADIO" "RADIO"
2 "STORE NAME" "STORE NAME"
"NAME PLEASE"
3 "<name>" "REPEAT NAME PLEASE"
166
Voice control
Tune name
This function allows you to call up a stored
radio station.
1 "RADIO" "RADIO"
2 "TUNE NAME"
a "NAME PLEASE"
Delete name
This function allows you to delete a stored
radio station.
1 "RADIO" "RADIO"
2 "DELETE NAME" "NAME PLEASE"
3 "<name>" "DELETE <name>"
"CONFIRM YES OR NO"
4 "YES" "DELETED"
"NO" "COMMAND CANCELLED"
Play directory
This function allows you to let the system
tell you all of the stored radio stations.
1 "RADIO" "RADIO"
167
Voice control
Delete directory
This function allows you to delete all
stored radio stations at once.
1 "RADIO" "RADIO"
2 "DELETE DIRECTORY" "DELETE DIRECTORY"
"CONFIRM YES OR NO"
3 "YES" "RADIO DIRECTORY DELETED"
"NO" "COMMAND CANCELLED"
Overview
TELEPHONE COMMANDS The overview below shows the available
voice commands of the phone system. The
Phone following lists will give further information
Your phone system allows you to create about the complete command menu.
an additional phonebook. The stored
entries can be dialled by voice control.
Phone numbers stored by using voice
control are stored on the vehicle system
and not in your phone.
"PHONE"
"HELP"
a, b
"MOBILE NAME"
a
"DIAL NUMBER"
a
"DIAL NAME"
"DELETE NAME"
"DELETE DIRECTORY"
"PLAY DIRECTORY"
168
Voice control
"PHONE"
"STORE NAME"
a
"REDIAL"
"ACCEPT CALLS"
"REJECT CALLS"
Create a phonebook
Store name
New entries can be stored with the
"STORE NAME" command. This feature
can be used to dial a number by calling up
the name instead of the full phone number.
1 "PHONE" "PHONE"
2 "STORE NAME" "STORE NAME"
"NAME PLEASE"
3 "<name>" "REPEAT NAME PLEASE"
4 "<name>" "STORING NAME"
"<name> STORED"
"NUMBER PLEASE"
5 "<phone number>" "<phone number>"
6 "STORE" "STORING NUMBER"
"<phone number>"
"NUMBER STORED"
Delete name
Stored names can also be deleted from
the directory.
169
Voice control
1 "PHONE" "PHONE"
2 "DELETE NAME" "NAME PLEASE"
3 "<name>" "DELETE <name>"
"CONFIRM YES OR NO"
4 "YES" "<name> DELETED"
"NO" "COMMAND CANCELLED"
Play directory
Use this function to let the system tell you
all stored entries.
1 "PHONE" "PHONE"
2 "PLAY DIRECTORY" "PLAY DIRECTORY"
Delete directory
This function allows you to delete all
entries in one go.
1 "PHONE" "PHONE"
2 "DELETE DIRECTORY" "DELETE DIRECTORY"
"CONFIRM YES OR NO"
3 "YES" "PHONE DIRECTORY DELETED"
"NO" "COMMAND CANCELLED"
Phone functions
Mobile name
This function allows you to access phone
numbers stored with a name tag in your
mobile phone.
170
Voice control
1 "PHONE" "PHONE"
2 "MOBILE NAME"
a, b "MOBILE NAME" "<phone
dependent dialogue>"
Dial number
Phone numbers can be dialled after giving
the name tag voice command.
1 "PHONE" "PHONE"
2 "DIAL NUMBER"
a "NUMBER PLEASE"
Dial name
Phone numbers can be dialled after giving
the name tag voice command.
1 "PHONE" "PHONE"
2 "DIAL NAME"
a "NAME PLEASE"
171
Voice control
Redial
This function allows you to redial the last
dialled phone number.
1 "PHONE" "PHONE"
2 "REDIAL"
a "REDIAL"
"CONFIRM YES OR NO"
3 "YES" "DIALLING"
"NO" "COMMAND CANCELLED"
1 "NUMBER PLEASE"
2 "<numbers 1 to 9, zero, hash, star>"
Main settings
Accept and reject calls
Calls can be accepted or rejected using the
Voice Control.
1 "PHONE" "PHONE"
2 "ACCEPT CALLS" "ACCEPT CALLS"
172
Voice control
Overview
NAVIGATION SYSTEM The overview below shows the available
COMMANDS voice commands for operating your
climate control system. The following lists
Please refer to your separate Navigation will give further information about the
manual for details of the command menus. complete command menu.
CLIMATE CONTROL
COMMANDS
Climate
The climate voice commands supports the
functionality of the fan speed, temperature
and mode settings. Not all functions are
available on all vehicles.
"CLIMATE"
"HELP"
a
"FAN"
a
"DEFROSTING/DEMISTING ON"
a
"DEFROSTING/DEMISTING OFF"
a
"TEMPERATURE"
a
"AUTO MODE"
a) Can be used as a shortcut. On vehicles fitted with an English language module the
"FAN" shortcut is not available.
Fan
This function allows you to adjust the fan
speed.
173
Voice control
1 "CLIMATE" "CLIMATE"
a) Can be used as a shortcut. On vehicles fitted with an English language module the
"FAN" shortcut is not available.
Defrosting/Demisting
1 "CLIMATE" "CLIMATE"
a "DEFROSTING/DEMISTING ON"
"DEFROSTING/DEMISTING ON"
2
a "DEFROSTING/DEMISTING OFF"
"DEFROSTING/DEMISTING OFF"
Temperature
This function allows you to adjust the
temperature.
1 "CLIMATE" "CLIMATE"
2 a "TEMPERATURE PLEASE"
"TEMPERATURE"
"MINIMUM" "TEMPERATURE MINIMUM"
"<a number between 15 and 29 C
3 with 0.5 increments>" or "<a "TEMPERATURE <number>"
number between 59 and 84 F>"
"MAXIMUM" "TEMPERATURE MAXIMUM"
174
Voice control
Auto mode
1 "CLIMATE" "CLIMATE"
2 a "AUTO MODE"
"AUTO MODE"
175
Appendices
ELECTROMAGNETIC WARNINGS
COMPATIBILITY The RF (radio frequency) transmitter
equipment (e.g. cellular telephones,
WARNINGS amateur radio transmitters etc.) may
only be fitted to your vehicle if they comply
Your vehicle has been tested and with the parameters shown in the table
certified to legislations relating to below. There are no special provisions or
electromagnetic compatibility conditions for installations or use.
(72/245/EEC, UN ECE Regulation 10 or
other applicable local requirements). It is Do not mount any transceiver,
your responsibility to ensure that any microphones, speakers, or any other
equipment you have fitted complies with item in the deployment path of the
applicable local legislations. Have any airbag system.
equipment fitted by properly trained Do not fasten antenna cables to
technicians. original vehicle wiring, fuel pipes and
brake pipes.
Keep antenna and power cables at
least 10 centimetres (4 inches) from
any electronic modules and airbags.
1 2 3 4
E85998
1 30 50 W 3, 4
30 54 50 W 1, 2, 3
68 87.5 50 W 1, 2, 3
176
Appendices
142 176 50 W 1, 2, 3
380 512 50 W 1, 2, 3
806 940 10 W 1, 2, 3
1200 1400 10 W 1, 2, 3
1710 1885 10 W 1, 2, 3
1885 2025 10 W 1, 2, 3
177
178
Index
A Audio introduction.........................................131
Audio menu control.....................................138
A/C Audio system security.................................136
See: Climate Control...........................................58 Audio troubleshooting................................153
About This Manual...........................................5 Audio unit clock and date displays.........137
ABS Audio unit commands................................164
See: Brakes.............................................................82 CD Player/CD Changer.....................................164
ABS driving hints Radio.......................................................................165
See: Hints on Driving With Anti-Lock Audio unit menus.........................................145
Brakes..................................................................82 Audio unit operation....................................138
Accessories Audio unit overview......................................132
See: Parts and Accessories.................................5 Automatic Climate Control.......................60
Adjusting the Steering Wheel.....................31 Air distribution........................................................61
Air Conditioning Blower.......................................................................61
See: Climate Control...........................................58 Recirculated air......................................................61
Air Vents............................................................58 Setting the temperature.....................................61
Alarm..................................................................30 Switching the air conditioning on and
Alternative frequencies..............................146 off...........................................................................61
6000CD and 6006CDC..................................146 Switching the automatic climate control
Sony CD.................................................................146 on and off...........................................................62
Appendices.....................................................176 Windscreen defrosting and demisting..........61
Arming the alarm...........................................30 Automatic Transmission - Vehicles With:
Alarm........................................................................30 4-Speed Automatic Transmission
Automatic arming delay....................................30 (4F27E)...........................................................79
Arming the engine immobiliser.................29 Drive modes...........................................................80
At a Glance..........................................................8 Emergency park position release
Adjusting the steering wheel............................10 lever.....................................................................80
Audio unit.................................................................12 Hints on driving with an automatic
Autolamps...............................................................13 transmission.....................................................80
Automatic climate control..................................11 Selector lever positions......................................79
Autowipers...............................................................13 Automatic volume control........................145
Creating a level load floor..................................14 6000CD and 6006CDC..................................145
Electric folding mirrors.........................................13 Sony CD..................................................................145
Engine idle speed after starting.......................10 Autostore control...........................................141
Home safe lighting................................................13 6000CD and 6006CDC...................................141
Information displays.............................................11 Sony CD...................................................................141
Instrument panel overview.................................8 Auxiliary Heater...............................................62
Locking and unlocking the doors with the Diesel auxiliary heater (depending on
remote control...................................................12 country)..............................................................62
Manual climate control........................................11 Auxiliary input (AUX IN) socket...............152
Welcome lighting..................................................13
Audio Control....................................................31
Mode.........................................................................32
B
Seek...........................................................................32 Balance/fade control..................................138
Volume......................................................................31 6000CD and 6006CDC..................................138
Audio distortion reduction (CLIP)..........145 Sony CD..................................................................138
6000CD and 6006CDC..................................145
Sony CD..................................................................145
179
Index
180
Index
181
Index
Handbrake
See: Parking Brake...............................................82
L
Hazard Warning Flashers............................39 Lighting Control...............................................37
Headlamp Levelling......................................39 Autolamps...............................................................37
Recommended headlamp levelling switch Headlamp flasher................................................38
positions.............................................................39 Home safe lighting...............................................37
Head Restraints..............................................66 Main/dipped beam...............................................37
Adjusting the head restraint.............................67 Welcome lighting..................................................37
Removing the head restraint............................67 Lighting...............................................................37
Heated Seats...................................................67 Load Carriers
Heated Windows and Mirrors....................62 See: Roof Racks and Load Carriers...............86
Heated exterior mirrors......................................62 Load Carrying..................................................86
Heated windows...................................................62 General Information...........................................86
Heating Loading compact discs..............................148
See: Climate Control...........................................58 6000CD.................................................................148
Hints on Driving With Anti-Lock 6006CDC..............................................................148
Brakes..............................................................82 Sony CD.................................................................148
Locking and Unlocking.................................27
I Automatic relocking............................................28
Central locking.......................................................27
Ignition Switch.................................................72 Double locking.......................................................27
Immobiliser Locking and unlocking confirmation.............27
See: Engine immobiliser....................................29 Locking and unlocking the doors with the
Important audio information....................131 key..........................................................................27
Audio unit labels..................................................131 Locking and unlocking the doors with the
Disc labels..............................................................131 remote control..................................................28
Incorrect security code...............................136 Reprogramming the unlocking
Information Displays.....................................53 function...............................................................28
General Information............................................53 Locks....................................................................27
Information Messages..................................55 Lost security code........................................136
Instrument Cluster........................................49 Luggage Covers..............................................86
182
Index
M On/off control................................................138
Opening and Closing the Bonnet............101
Maintenance..................................................100 Closing the bonnet.............................................101
General Information.........................................100 Opening the bonnet...........................................101
Technical Specifications.................................109
Manual Climate Control..............................58
Air distribution control.......................................59
P
Blower......................................................................58 Parking Aids.....................................................84
Cooling the interior quickly..............................60 Principle of Operation........................................84
Cooling with outside air....................................60 Parking Brake...................................................82
Defrosting and demisting the Applying the parking brake...............................82
windscreen........................................................59 Parking on a hill.....................................................82
Heating the interior quickly..............................59 Releasing the parking brake.............................82
Recirculated air.....................................................60 Parts and Accessories.....................................5
Reducing interior air humidity.........................60 Look for the Ford logo on the following
Switching the air conditioning on and parts .......................................................................6
off..........................................................................59 Now you can be sure that your Ford parts
Temperature control...........................................59 are Ford parts......................................................5
Ventilation...............................................................59 Personalised Settings..................................54
Manual Seats..................................................64 Audible warnings..................................................54
Adjusting the angle of the seatback.............65 Audio display.........................................................54
Adjusting the height of the drivers Direction indicators.............................................54
seat.......................................................................65 Hazard warning flashers....................................54
Folding the passenger seat forwards...........65 Language.................................................................54
Moving the seats backwards and Unlocking the doors with the remote
forwards.............................................................64 control.................................................................54
Manual Transmission...................................78 Power Door Locks
5-speed manual transmission........................78 See: Locking and Unlocking..............................27
Durashift EST.........................................................78 Power Steering Fluid Check.....................108
Message Centre Topping up............................................................108
See: Information Displays.................................53 Power Windows..............................................47
Mirrors To open the drivers window
See: Heated Windows and Mirrors................62 automatically....................................................47
See: Windows and Mirrors................................47 Programming the remote control............25
Re-programming the unlocking
N function...............................................................25
183
Index
184
Index
Telephone........................................................155
General Information..........................................155
U
Telephone Under Bonnet Overview - 1.25L
See: Using the telephone - Vehicles With: Duratec-16V (Sigma)/1.4L Duratec-16V
Travel Pilot EX..................................................161 (Sigma)/1.6L Duratec-16V
See: Using the telephone - Vehicles Without: (Sigma).........................................................102
Navigation System........................................158 Under Bonnet Overview - 1.4L
Tow Ball.............................................................88 Duratorq-TDCi (DV) Diesel...................104
Driving with a trailer............................................90 Under Bonnet Overview - 1.6L
Driving without a trailer.....................................90 Duratorq-TDCi (DV) Diesel...................105
Inserting the tow ball arm................................89 Using seat belts during pregnancy..........23
Maintenance...........................................................91 Using Snow Chains......................................124
Removing the tow ball arm.............................90 Vehicles with stability control (ESP)..........125
Unlocking the tow ball arm Using Stability Control.................................83
mechanism.......................................................89 Using the Parking Aid...................................84
Towing a Trailer..............................................88 Manoeuvring with the parking aid.................84
Steep gradients....................................................88 Switching the parking aid on and off...........84
Towing Points..................................................99 Using the telephone - Vehicles With:
Front towing eye...................................................99 Travel Pilot EX..............................................161
Towing the Vehicle on Four Wheels.......99 Changing the active phone.............................162
All vehicles..............................................................99 Debonding a bonded phone..........................162
Vehicles with a Durashift EST.........................99 Handling an incoming call...............................161
Vehicles with an automatic Handling a second incoming call.................162
transmission.....................................................99 Making a call.........................................................161
Towing................................................................88 Using the telephone - Vehicles Without:
Track selection..............................................148 Navigation System....................................158
6000CD and 6006CDC..................................148 Changing the active phone............................160
Sony CD.................................................................148 Debonding a bonded phone..........................160
Traffic information control.........................141 Handling a second incoming call.................160
Activating traffic announcements................141 Making a call........................................................159
Ending traffic announcements......................142 Receiving an incoming call.............................159
Local or distant traffic.......................................142 Using voice control......................................163
To adjust the preset volume...........................142 System operation...............................................163
Traffic announcement volume......................142 Using Winter Tyres.......................................124
Transmission....................................................78
Type approvals...............................................177
FCC/INDUSTRY CANADA NOTICE...............177
V
RX-42 - declaration of conformity................177 Vehicle battery................................................114
Tyre Care..........................................................124 Vehicle care......................................................112
Tyre Pressures Vehicle Identification Number.................126
See: Technical Specifications........................125 Vehicle Identification Plate.......................126
Tyre Repair Kit.................................................121 Vehicle identification...................................126
General information............................................121 Vehicle recovery.............................................99
Inflating the tyre..................................................122 Ventilation
Using the tyre repair kit......................................121 See: Climate Control...........................................58
Tyres Vents
See: Wheels and Tyres......................................116 See: Air Vents........................................................58
185
Index
VIN
See: Vehicle Identification Number.............126
Voice control..................................................163
Principle of Operation.......................................163
W
Warning Lamps and Indicators................50
ABS warning lamp...............................................50
Airbag warning lamp..........................................50
Brake system lamp..............................................50
Direction indicator...............................................50
Door open warning lamp..................................50
Engine warning lamp...........................................51
Front fog lamp indicator.....................................51
Frost warning lamp...............................................51
Glow plug indicator...............................................51
Headlamp indicator..............................................51
Ignition warning lamp..........................................51
Low fuel level warning lamp.............................51
Main beam indicator............................................51
Oil pressure warning lamp.................................51
Overdrive indicator................................................51
Power steering warning lamp...........................51
Powertrain warning lamp..................................52
Rear fog lamp indicator......................................52
Stability control (ESP) warning lamp..........52
Warning Triangle............................................93
Washer Fluid Check....................................109
Washers
See: Wipers and Washers.................................33
Washing
See: Cleaning the Exterior.................................112
Waveband button.........................................141
6000CD and 6006CDC ..................................141
Sony CD...................................................................141
Wheels and Tyres..........................................116
General Information...........................................116
Technical Specifications..................................125
Windows and Mirrors....................................47
Windscreen Washers....................................34
Windscreen Wipers.......................................33
Autowipers..............................................................33
Intermittent wiping..............................................33
Winter Tyres
See: Using Winter Tyres....................................124
Wipers and Washers.....................................33
186
(CG3441en)