Professional Documents
Culture Documents
Department:
Bachelor (Hons) of Civil Engineering
Lecturer:
Ir Pan
Group: 2
1
Contents
Abstract .............3
Objective ...........3
Introduction................3
Apparatus...4
Procedure5
Theory6
Results7
Table 1....7
Graph 1...7
Table 2....8
Graph 2...8
Discussion......................................................................................................................................9
Conclusion.9
Reference.......................................................................................................................................9
2
ABSTRACT
Buckling occurs when column has a tendency to deflect laterally, out of the line of action of the
force. Once buckling initiates, the instability can lead to failure of the column, because the
eccentric force acts as a moment causing greater stresses and deflections due to the combination
of the bending and axial forces.
OBJECTIVE
Introduction
The physicist and mathematician Leonhard Euler first derived a series of equations to determine
the deformation of columns under loads. The following procedure attempts to verify one of these
buckling equations for steel columns.Euler determined the following expression for determining
the critical load.
3
APPARATUS
Specimen holders.
Deformation measurement.
Lateral load device with weight.
4
PROCEDURE
5
8. The measuring gauge was aligned to the middle of the rod specimen using the supporting
clamps. The measuring gauge was set at a right angle to the direction of buckling.
9. The measuring gauge was pretighten to 10mm deflection with the adjustable support.
10. The rod specimen load was slowly subjected using the load nut.
11. The deflection was recorded from the measuring gauge. The deflection was read and
recorded at every 0.25mm up to 1mm.
Theory
A long-column straight beam with a rectangular cross section is subjected to a compressive axial load. As
long as the beam remains straight, it can be analysed by the theories of tension or compression loads;
however, if the deflection become suddenly large and leads to catastrophic failure, the buckling theory
has to be applied for the analysis. According to the theory, the critical (or Euler) buckling load Pcr, critical
stress cr, and slenderness ratio L/r can be calculated by the following formulas:
6
L is the length of the beam.
A is the cross section area of the beam, A = bh.
r is the radius of gyration about the axis of bending.
2 21.0104 106.6
For the first specimen(S3)P = =613.72N
6002
2 21.0104 106.6
For the second specimen (S6) P = =522.94N
6502
Results
7
Graph1: specimen (S6)
specimen (S6)
900
800
700
600
Force (N)
500
400
300
200
100
0
0 0.2 0.4 0.6 0.8 1 1.2 1.4 1.6 1.8
Deflection (MM)
Defection
Force (N) (mm)
100 0
200 0.06
300 0.19
400 0.42
450 0.62
8
specimen (S6)
500
450
400
350
300
Force (N)
250
200
150
100
50
0
0 0.1 0.2 0.3 0.4 0.5 0.6 0.7
Deflection (MM)
Then, the stress on the beam can be calculated using critical load as =
522.94
= = 6.54 MPa for specimen (S6)
80
613.72
= = 7.67MPa for specimen (S3)
80
9
Conclusions
The error within this experiment was grossly inaccurate and exhibited unacceptable error. The
main source of error was due to poor testing technique. Evenwith proper technique, however,
persistent and large error was still present. There main error was due to ill conditioned test
samples and poorly calibrated equipment. The samples had experienced buckling many times
previous to this test, and the clampswere not aligned to place the force parallel along the beam
10