Polishing process. For AWJ Polishing Quartz Material removal would be good if it done via Ductile Removal Mechanism using small incidence angle low pressure small Abrasive size. From experiments it is concluded that To obtain the good polishing effect, it is better to choose low pressure, small incidence angle and small size of the abrasive.Hui Fang, Peiji Guo, and Jingchi Yu studied dependence of Material Removal and Surface Roughness on the characteristics of abrasive particles, Workpiece, Pressure, Angle of Incidence on FJP Experiments showed Volume removal rate is proportional to square root of Youngs Modulus and inversely proportional to Knoop Hardness. Surface Roughness depend on Elastic Stiffness E and Plastic Parameter H. Linear Dependence of material removal on working pressure is obtained via experimental results