Professional Documents
Culture Documents
OptiX RTN 900 V1R1 Installation Guide VDF PDF
OptiX RTN 900 V1R1 Installation Guide VDF PDF
Installation Guide
www.huawei.com
Mandatory Rules
Installation
Mandatory Rules
Installation
Fuse dimenssion 12 A 20 A
Dimension 442 mm (width) x 220 mm (depth) x 1 U 442 mm (width) x 220 mm (depth) x 2 U (height,
(height, 1 U = 44.45 mm). 1 U = 44.45 mm).
PGND
working protection
1 2 3 4 5 6 7 8
Interface on the Interface Usage Remark
Front Panel Type
1 ETH OAM RJ-45 10Base-T/100Base-TX NM Ethernet interface For WEBLCT
or NM serial interface
In this case, use four latches to mount an ODU on the back of the antenna.
Follow the steps below:
Step 2 Loosen the fixing bolts enough to allow the feed boom to rotate freely.
Procedure
Step 1 Remove the protective caps from the feed boom of the antenna and from the
ODU antenna interface. Apply appropriate lubricant to the gasket of the feed boom.
Step 2 Place the ODU antenna interface against the feed boom. Slowly fit the feed
boom in to make the four ODU latches engage the four antenna hooks.
Next page
Procedure
Step 1 Check the polarization direction of the antenna.
If The antenna is vertically polarized, Go to the next step.
The antenna is horizontally polarized, Go to Step 3.
Step 2 Remove the protective cap from the antenna interface on the coupler. Replace the
polarization converter in the interface by a horizontal polarizer.
Procedure
Step 1 Fix the OT terminal of the protection grounding cable onto the grounding stud of
the ODU.
Procedure
Step 1 Depending on the distance between the IDU and the ODU, cut off a length of IF
cable with a slack of 3 m to 5 m.
Step 2 Refer to A Terminating the IF Cable with Connectors, make a connector for the
end that is connected to the ODU.
Take protective measures for the connector to avoid damage to the connectors during
installation.
Step 4 Leave enough slack of the IF cable for routing and binding it along the mast,
wiring ladder and wiring frame.
Figure 5-2 Waterproof curves before the IF cable enters the IDU room
Step 5 Insert the type-N male connector of the IF cable to the IF interface of the
ODU and screw tight.