Professional Documents
Culture Documents
AN17823A Datasheetz
AN17823A Datasheetz
A-1
Checked Total Page 9
Approved AN17823A Page No. 1
Note 1) The temperature of all items shall be Ta=25°C except storage temperature and
operating ambient temperature.
2) At no signal input.
Maximum Power
6 Output 1 PO 1 1 THD=10%, Vol=1.25V 2.4 3.0 - W
Note 1) For this measurement, use the BPF = 15Hz ~ 30kHz (12dB/OCT).
Note) The above characteristics are reference values determined for IC design, but not guaranteed
values for shipping inspection. If problems were to occur, counter measures will be
sincerely discussed.
AN17823A
1 2 3 4 5 6 7 8 9
+
+ + 1.0µ
470µ 10µ 270k
OUT1 10k
8Ω 68k
Vcc 1.25V
5V Vin
0V 0V
Stand-by Volume
+ _ _ +
1 2 3 4 5 6 7 8 9
Vcc Output Input
GND GND
Pin Descriptions
5.8±0.25
1.2±0.25
0.7±0.25
1.5±0.25 3.75±0.25
0.5±0.1
9
φ3.3±0.1
6
19.92±0.3
18.5±0.25
21.6±0.3
5
15.0
2.54
4
0.15 MAX
2
1
1.7±0.25
-0.05
5.6±0.25
0.44 +0.1
1.7±0.25
Name of item
Date Code
Company insignia
(Structure Description)
Chip surface passivation SiN, PSG, Others ( ) 1
Lead frame material Fe group, Cu group, Others ( ) 2 , 6
Inner lead surface process Ag plating, Au plating, Others ( ) 2
Outer lead surface process Solder plating, Solder dip, Others ( ) 6
Chip mounting method Ag paste, Au-Si alloy, Solder, Others ( ) 3
Wire bonding method Thermalsonic bonding, Others ( ) 4
Mold material Epoxy, Others ( ) 5
Package 9-SIP(F)
1
5 6
2
3
( )
Rth(j-c) = 12.0°C/W
Rth(j-a) = 66.5°C/W
F-9S Package Power Dissipation
PD - Ta
5000
5°C/W heat sink
4706
4500
4000
10°C/W heat sink
3636
3500
Power Dissipation, PD (mW)
3000
1500
Without heat sink
1203
1000
500
0
0 25 50 70 75 100 125 150
Ambient Temperature, Ta (°C)
1) Make sure that the IC is free of any pin short-circuiting, ground short, and load short-
circuiting.
2) Ground the radiation fin so that there will be no difference in electric potential between the
radiation fin and ground.
4) Make sure that the heat radiation design is effective enough if the Vcc is comparatively high
or the IC operates high output power.
5) Connect only ground pin for signal sources to the signal GND pin of the amplifier on the
previous stage.