following illustration and table. To remove individual parts, only carry out the listed steps: Part Steps Front Bumper Cover 1-6,10 Front Lower Valance 7-9 Panel Front Bumper 1-6,10-12
Copyright 2003, Ford Motor Company
Last updated: 07/01/2003 2004 Explorer/Mountaineer, 10/2003 501-00-2 Body System — Exterior 501-00-2 REMOVAL AND INSTALLATION (Continued)
Item Part Number Description Item Part Number Description
1 14A464C Foglamp electrical connectors 8 W505427 Valance panel bolt (2 req’d) (If equipped) 9 17D997 Valance panel 2 14A464 Sidemarker lamp connector 10 17C831G Front bumper cover (If equipped) Removal Note 3 59612S Splash shield screws 11 W505427S Front bumper nuts 4 N806113S Splash shield pin-type retainer 12 17K820 Front bumper 5 16185 Front fender splash shield 6 W505427S Upper bumper inner screws 2. To install, reverse the removal procedure. 7 N807389 Valance panel scrivets (10 req’d) Item 10: Front Bumper Cover Removal Note (Continued) 1. Rotate the bottom of the cover upward.
2004 Explorer/Mountaineer, 10/2003
501-00-3 Body System — Exterior 501-00-3 REMOVAL AND INSTALLATION (Continued) 2. Apply downward pressure to the to the top of the bumper cover to release the four retaining tabs.