Professional Documents
Culture Documents
How To PDF
How To PDF
1. Insert OP-COM erased interface and look in Device Manager that it’s
detected and installed and if not install drivers from folder DRIVERS OK
2. PLEASE REMEMBER ALL SOFTWARE MUST BE RUN WITH
ADMINISTRATOR RIGHTS (Click right on program-Run as Administrator)
3. Now let’s see if you have bootloader present:
Open OPCOMFUT v2.9.exe (with admin rights).
Go to FIRMWARE-Check Version/ID
If you have an image like below thn pic bootloader it’s ok, if you don’t
and you have a message that says that bootloader not found then you
need to repair it.
4. So if you don’t have a message as showed in the picture then you have to
restore bootloader of your PIC18F458
5. Go to OCFlash Folder and open OCFlash.exe(with Admin rights), select
Load Firmware and chose file Bootloader.hex . Also after this check on
FlashMode – Only bootloader recovery without FW flash
10. That it’s all, now you have a functional clone again.