MIGAS-INDONESIA.COM p =
Reactions in HYSYS
by migas | Jul 4, 2007 | Proses, Uncategorized |
‘There are currently five different types of reaction that may be simulated in HYSYS and a number
of reactor types that they may be used with (and one special reactor that does not require any
equations). Reactions may also be used in Columns and Separators (though there are some
limitations on the phases that may be used by the reactions in those cases).
‘There are currently five different types of reaction that may be simulated in HYSYS and a number
of reactor types that they may be used with (and one special reactor that does not require any
equations), Reactions may also be used in Colurins and Separators (though there are sone
limitations on the phases that may be used by the reactions in those cases). The five reaction types
are as follows:
Conversion
This reaction type does not require any thermodynamic knowledge. You must input the
stoichiometry and the conversion of the basis reactant, The specified conversion cannot exceed
100%. The reaction will proceed until either the specified conversion has been reached or a limiting
reagent has been exhausted.
Conversion reat
ions may not be grouped with any other form of reaction in a reaction set.
However, they may be grouped with other conversion reactions and ranked to operate either
sequentially or simultaneously. Lowest ranking occurs first (may start with either 0 or 1).Just as
with single reactions, simultaneous reactions cannot total over 100% conversion of the same basis,
Conversion reactions cannot be used with Plug Flow Reactors or CSTRs. In general, they should
only be used in,
Conversion Reactors,
Selengkapnya
Migas Indonesia
2.4K tes
Like Page
1 fiend kes this
Recent Posts