HONDA
GX120K1 - GX160K1
VALVE CLEARANCE
NOTE
v
2)
3)
med with the engine cold.
‘clearance inspection and adjustment must be perfor-
Remove the four cylinder head cover bolt, cylinder head
cover and gasket.
‘Sot the piston at top dead center of the compression stroke
(both valves fully closed). The triangular mark on the starter
pulley will align with the top hole on the fan cover when the
piston is at top dead center of the compression or exhaust
stroke.
Insert a feeler gauge between the rocker arm and valve to
‘measure valve clearance.
Standard valve
clearance
0.1520.02 mm
(0.006+0.001 in)
0.2020.02 mm
(0.008+0.001 in)
x
4
If adjustment is necessary, proceed as follows:
b.
Hold the rocker arm pivot and loosen the rocker arm
pivot lock nut.
‘Tum the rocker arm pivot to obtain the specified clear-
ance.
Retighten the rocker arm pivot lock nut while holding the
rocker arm pivot
|. Recheck valve clearance after tightening the rocker arm
pivot lock nut.
‘CYLINDER HEAD COVER BOLT (4)
TOP HOLE
ROCKER ARM
VALVE
ROCKER ARM PIVOT
LOCK NUT
ROCKER ARM PIVOT
To increase valve clearance, screw out.
To decrease valve clearance. screw in.HONDA
G@Xxe40K1-GX270
G@X340K1'GX390K1
VALVE CLEARANCE
istment must be per
11) Remove the cylinder head cover bolt, cylinder head cover and
‘gasket.
2) Set the piston at top dead center of the compression stroke
(both valves fully closed). The triangular mark on the starter
pulley will align with the top hole on the fan cover when the
piston is at top dead center of the compression or exhaust
stroke.
3) Insert a feeler gauge between the rocker arm and valve tomeas-
ure valve clearance.
5 0.15 + 0.02 mm
‘Standard valve (0.008 + 0.001 in)
clearance x 0.20 + 0.02 mm
(0.008 + 0.001 in)
4) If adjustment is necessary, proceed as follows:
Holding the rocker arm pivot and loosen the pivot lock nut.
b. Turn the rocker arm pivot to obtain the specified clearance.
cc. Tighten the lock nut to the specified torque while holding
‘the rocker arm pivot.
TORQUE: 10 Nom (1.0 kg-m, 7 fab)
4d, Recheck valve clearance after tightening the lock nut.
CYLINDER HEAD
ROCER ARM
PIvoT
ROCKER ARM PIVOT
Lock NUT
To increase valve clearance, screw out.
To decrease valve clearance, screw in.