Professional Documents
Culture Documents
Lab Report 4 VLAN Inter VLAN Step by Step Routing Configuration PDF
Lab Report 4 VLAN Inter VLAN Step by Step Routing Configuration PDF
Lab Report: 04
Title: Configuration of Virtual Local Area Network (VLAN) and Inter-VLAN.
Objective:
⇰ Configure and maintain Virtual Local Area Network (VLAN).
⇰ Assign switch ports to a VLAN also assign the management VLAN.
⇰ Configure trunking and verify that the switches can communicate to each other.
⇰ Configuration of Inter-VLAN routing with sub-interfaces corresponding to the
configured VLANs.
Simulation:
VLAN is a virtual LAN. In technical terms, a VLAN is a broadcast domain created by switches.
For configuring VLAN and Inter-VLAN, create a topology as in following figure.
Addressing Table:
Step 1: Go to the PC0 => Desktop => IP configuration mode and type
Same as configure all other five PCs. [PC1, PC2, PC3, PC4, PC5]
Switch 2 (S2)
Step 3: Create VLANs. The commands are same in all switches. So, repeat these commands in
S0, S1, and S2.
Switch 1: (S1)
Switch 2: (S2)
Switch 2 (S2)
Switch 0 (S0)
Switch 0 (S0)
Router 0 (R0)
Now assign default gateway and virtual gateway for VLANs by following commands,
Router 0 (R0)
Switch 0 (R0)
That’s it.
Fully complete the configuration of VLAN and Inter-VLAN. For testing the connectivity among
PCs, as usual we use the ping command in source PC’s command prompt to write destination
PC’s IP address. For example here ping from PC0 to PC6 and observe the output.