Stock Specifications - Plates >’
Neola}
High yield structural Plates API-2W grade 60
API-2W grade 60 high yield structural plates ae intended for (but not limited to) use in fixed offshore structures, designed to
‘operate inthe offshore sector,
Applicable codes and standards
‘APL 2W, 2006 edition specifies high strength steel plates for offshore structures, produced by thermo-mechanical controlled
processing.
Grade Grade 60 LS Z35
The primary us of these sta sin bjs snes plate constuction and otherintsections where porns of the plate wl be Subct o terson the
_Wicknass dracon Supplementary quam 4 proves fr though-teknesfesthy of les and specie hts fr acaptance Th sel offence
‘rough hckness dunt nd ampat vausvetfid at mins 40°C
Chemical composition
Product analyssin% (Al values are max. unless otherwise stated.)
6 Cevttontiece
005-050 Now
aaise1.60 newer
evan tetonmoa
ona se formula below woseitonm ous
eon tetonmoz
006 see formula below woaeitoam 0x8
025
ons.
10
0.02 -0.06
Mn — CreMo+V Niecy
CiveC+ + ae
naegntarattonnend as
mene amsencoreacin
“Miptasge cows 262.2064Mechanical properties
Grade 60
Thicknesst Yield R, Tensile,
414-621
2 asjans
ik inn 22
416-566
Available supplementary for stock plates as per Appendix A of API 2W
‘Supplementary Subject Remarks
st ur ‘Recording to EN 10160 51/62 or ASTM AS7B
3 “Tensile test ‘Additional tons test shall be taken for head and tal corner ofeach parent-plate
Through Thickness
Testing
3 Low Sulphur $s0,006%
rin ageing” Stein ageing tests ae carried out for thicknesses greater than or equalto 12,5 mm. Plastic sin
se Strain ageing '5%, aged for 1h at 250°C. Transverse CUN-valussin strain aged condition min 41/34) at -40"C
39 PwHT* Fort > 40mm tensile and impect testing in PWHT condition
sto Horcness* Hardness tested according to Vickers
sit Wildsbity® Pre qualfication fr thicknesses = 40 mm up to 75 mmin accordance with APIRP2Z.
si Drop weight testing” For plates over 16 mm thickness. Thickest plate per lot. ‘No break’ at minus 35°C acc ASTM £208
“naa pon request
sa TIP testing meeting class 735 accorcing to ASTM A370 or EN 10164,
surface
All surfaces have been 100% visually inspected, The surface condition does comply with EN 10763-2, class A, sub-class 3.
Certification and traceabitly
{All cimensions will be supplied with 3.2 certificate according to EN 10204, endorsed by recognized and independent inspection agency.
Low stress die-stamping on head and tal of each plate.