Professional Documents
Culture Documents
2 - Kickstand PDF
2 - Kickstand PDF
Kickstand
Open a new part with model units set to
millimeters.
Draw an ellipse
Go to: Tools > Sketch Entities > Ellipse
Draw a spline as
shown in the picture.
2 | Page
Close the sketch
Click OK
Draw an ellipse
Go to: Tools > Sketch Entities > Ellipse
Create a loft
Click OK
3 | Page
Create a dome
Select the green top face of the loft as shown in the picture.
Click OK
Click OK
Direction 1 : Midplane
Change into: 40 mm
Click OK
4 | Page
Create a new sketch on the MIDPLANE KICKSTAND
Direction 1 : Midplane
Change into: 90 mm
Click OK
Create a extrude
Direction 1 : Midplane
Change into: 8 mm
Click OK
5 | Page
Create two fillets
Click OK
Click OK
- MIDPLANE KICKSTAND
6 | Page