Professional Documents
Culture Documents
Define
(i) Nominal size and Actual size
(ii) Fits and Tolerance
(iii) Efficiency of riveted joint
(iv) Fundamental Deviation
(v)
7. A beam of rectangular cross section is welded to a support by means of fillet welds as shown in
figure. Determine the size of the welds, if the permissible shear stress in the weld is limited to 75
N/mm2.
8. It is required to design a knuckle joint to connect two circular rods subjected to axial
tensile force of 150 kN. Design the joint, assuming the working stress for both the pin
and the rod material are 75 MPa in tension, 60 MPa in shear and 150 MPa in crushing.
2 of 1