Professional Documents
Culture Documents
10 Chat PDF
10 Chat PDF
10.1 Introduction
Ascorbic acid is a powerful antioxidant because it can donate a hydrogen atom and
form a relatively stable ascorbyl free radical. As a scavenger of reactive oxygen and
nitrogen oxide species, ascorbic acid has been shown to be effective against the
superoxide radical ion, hydrogen peroxide, the hydroxyl radical and singlet oxygen
(Weber, Bendich & Schalch, 1996).
Ascorbic acid protects folic acid reductase, which converts folic acid to folinic
acid, and may help release free folic acid from its conjugates in food. Ascorbic acid
facilitates the absorption of iron.
10.2 Deficiencies
Severe deficiency of ascorbic acid causes scurvy. Symptoms appear when the
serum level falls below 0.2 mg/dl. A total body pool of less than 300 mg is associated
with symptoms of scurvy, while maximum body pools are limited to about 2 g (IOM,
2000).
acid per day, an amount easily obtained through consumption of fresh fruits and
vegetables.
Ascorbic acid is widely distributed in nature, mostly rich in fresh fruits and leafy
vegetables such as guava, mango, papaya, cabbage, mustard leaves and spinach (Tee et
al., 1997). Animal sources of this vitamin such as meat, fish, poultry, eggs and dairy
products contain smaller amounts and are not significant sources. Most food–based
dietary guidelines are similar in that all recommend consumption of 5 servings of fruits
and vegetables daily. If this recommendation is followed, daily intake of ascorbic acid
will be 210 to 280 mg, depending on food content factors (Levine et al., 1999). Ascorbic
acid is the least stable of all vitamins and is easily destroyed during processing and
storage. Juices are good foods to be fortified with ascorbic acid because their acidity
reduces ascorbic acid destruction. Exposure to oxygen, prolonged heating in the
presence of oxygen, contact with minerals (iron and copper) and exposure to light are
destructive to the ascorbic acid content of foods.
Ascorbic acid is very labile, and the loss of ascorbic acid upon boiling milk
provides one dramatic example of a cause of infantile scurvy. The ascorbic acid content
of food is strongly influenced by season, transportation to market, shelf life, time of
storage, cooking practices and chlorination of water.
Ascorbic acid is the most potent enhancer of non-heme iron absorption. A study
by Hallberg (1987) showed that iron absorption from non-heme food sources can be
increased significantly with a daily ascorbic acid intake of at least 25 mg for each meal
(estimated for 3 meals/day). Higher ascorbic acid intakes should be considered if meals
contain higher contents of nutrient inhibitors such as phytates and tannins.
Ascorbic Acid (Vitamin C) 103
The TSC on Vitamins decided to adapt the FAO/WHO (2002) values as the revised
RNI for Malaysia, with appropriate modifications, given in bold in the following
paragraphs according to age groups and summarised in Appendix 10.1.
Infants
Human milk is recognised as the optimal milk source for infants at least
throughout the first year of life. It is recommended as the sole nutritional milk source for
infants during the first 4 to 6 months of life. IOM (2000) estimated the AI for infants
based on the average volume of milk intake of 780 ml and an average concentration of
ascorbic acid of 50 mg/l in human milk. For infants 0-6 months, 40 mg per day was the
estimated AI and for the 7-12 months infants, the AI was 50 mg per day, taking into
consideration the amount of ascorbic acid from solid foods consumed at this stage.
The FAO/WHO (2002) recommended intakes for ascorbic acid for children and
adolescents were gradually increased from the recommended intake for infants. In
deciding on recommended intake for older children, eg adolescents, the TSC considered
the possible role that ascorbic acid can play in reducing the high prevalence of iron
deficiency anemia in the country (Tee et al., 1998). Hallberg (1987) had observed that
the additional intake of at least 25 mg ascorbic acid promotes absorption of soluble non-
haem iron. In addition, recent studies have pointed towards a possible antioxidant role
for ascorbic acid, ie ability to scavenge reactive oxidants in activated leucocytes, lung,
gastric mucosa and to protect against lipid peroxidation. The TSC therefore decided to
increase the amount recommended by FAO/WHO (2002) by 25 mg ascorbic acid per day
to all age groups from children 10 years and above.
Adults
The classic disease of severe ascorbic acid deficiency, scurvy, is now rare in most
countries. Other human experimental data that can be utilised to set a ascorbic acid
requirement, based on a biomarker other than scurvy, are limited. The IOM (2000)
recommended intakes of ascorbic acid are based on an amount of the vitamin that is
thought to provide antioxidant protection as derived from the correlation of such
protection with neutrophil ascorbate concentrations. It is however recognised that there
are no human data to directly quantify the dose-response relationship between ascorbic
acid intake and in vivo antioxidant protection.
The IOM noted that at a ascorbic acid intake of 90 mg/day, the plasma ascorbate
concentration reaches 50 µmol/l which has been shown to inhibit LDL oxidation in vitro
systems. Although it is not known whether ascorbic acid prevents LDL oxidation in vivo,
if it does this might be relevant in the prevention of heart disease. Also, since neutrophils
Ascorbic Acid (Vitamin C) 105
A body content of 900 mg falls halfway between tissue saturation and the point at which
clinical signs of scurvy appear. Assuming an absorption efficiency of 85 percent, and a
catabolic rate of 2.9, the average intake of ascorbic acid can be calculated as:
900 x 2.9/100 x 100/85 = 30.7 mg/day, which can be rounded off to 30 mg/day.
900 x (2.9 + 1.2)/100 x 100/85 = 43.4 mg/day, which can be rounded off to 45
mg/day.
No turnover studies have been done in women, but from the smaller body size and
whole body content of women, requirements might be expected to be lower. However,
in depletion studies plasma concentrations fell more rapidly in women than in men.
FAO/WHO (2002) therefore made the same recommendation for non-pregnant, non-
lactating women as for men.
It has been reported that elderly people generally have lower plasma and tissue
ascorbate levels than young people, often because of poor dentition or mobility problems.
However, FAO/WHO (2002) felt that the requirements of elderly people do not differ
substantially from those of younger people in the absence of pathology, which may
influence absorption or renal functioning. The recommended intake for the elderly are
therefore the same as those for adults (45 mg/day).
106 Recommended Nutrient Intakes for Malaysia 2005
For reasons already mentioned above for the adolescents, the TSC on Vitamins has
proposed that 25 mg per day ascorbic acid be added on to the FAO/WHO (2002)
recommended intake of 45 mg per day for all groups above 10 years of age.
During lactation, it has been estimated that 20 mg/day of ascorbic acid is secreted
in milk. For an assumed absorption efficiency of 85 percent, an extra 25 mg will be
needed by the mother. FAO/WHO (2002) therefore recommended that the RNI should
be set at 70 mg to fulfill the needs of both the mother and infant during lactation.
For the same reasons mentioned for the adolescents, the TSC for Vitamins suggested to
add an additional 25 mg per day of ascorbic acid to the FAO/WHO (2002) recommended
intake for pregnant and lactating women.
RNI for
Pregnancy 80 mg/day
Lactation 95 mg/day
The RNI values for ascorbic acid for Malaysia, adapted from FAO/WHO (2002),
but with the addition of 25 mg per day for all age groups above 10 years of age, are also
the same as those adopted by the Working Group for the Harmonisation of RDAs in
SEAsia (2002). The SEA Group also decided to provide for an additional amount
mentioned. Appendix 10.1 provides a summary of these revised RNI, compared with the
previous Malaysian RDI (Teoh, 1975), the FAO/WHO (2002) recommendations and the
values recommended by IOM (2000).
Ascorbic Acid (Vitamin C) 107
The revised RNI for Malaysia is higher than the 1975 Malaysian RDI for all age
groups. For the infants and young children, the increase is about 50%. For all other
groups, the increase is much more, because of the additional amount mentioned above.
For the adolescents and adults, the increase ranged from 116-225%. The increase for the
pregnant and lactating women is much less, being only about 60%. The recommended
intakes are easily achieved if one follows the Malaysian dietary guidelines. The higher
recommendations for the vitamin are deemed reasonable and justifiable. The higher
recommended levels are well below the UL and hence pose no health hazard. The revised
intakes are still lower than the IOM recommended intakes for most age groups by about
15-60%.
The review by IOM (2000) reported no evidence suggesting that ascorbic acid is
carcinogenic or teratogenic or that it causes adverse reproductive effects. High intakes
of the vitamin have been reported to have low toxicity; adverse effects have been reported
primarily after very large doses (greater than 3 g/day). Data obtained showed little
increase in plasma steady-state concentrations at intakes above 200 mg/day. Saturable
intestinal absorption and renal tubular reabsorption data suggest that overload of ascorbic
acid is unlikely in humans. Possible adverse effects associated with very high intakes
have been reviewed and include: diarrhea and other gastrointestinal disturbances,
increased oxalate excretion and kidney stone formation, increased uric acid excretion,
pro-oxidant effects, systemic conditioning (“rebound scurvy”), increased iron absorption
leading to iron overload, reduced vitamin B12 and copper status, increased oxygen
demand, and erosion of dental enamel. The tolerable upper intake levels (ULs) as
proposed by IOM (2000) for various age groups are tabulated in Table 10.1.
The FAO/WHO (2002) report pointed out that the potential toxicity of excessive
doses of supplemental ascorbic acid relates to intra-intestinal events and to the effects of
metabolites in the urinary system. Intakes of 2–3 g/day of ascorbic acid produce
unpleasant diarrhoea from the osmotic effects of the unabsorbed vitamin in the intestinal
lumen in most people. Gastrointestinal disturbances can occur after ingestion of as little
as 1 g because approximately half of the amount would not be absorbed at this dose.
Oxalate is an end product of ascorbate catabolism and plays an important role in kidney
stone formation. Excessive daily amounts of ascorbic acid produce hyperoxaluria. The
risk of oxalate stones formation may become significant at high intakes of ascorbic acid
(>1 g), particularly in subjects with high amounts of urinary calcium. The FAO/WHO
Consultation felt that 1 g ascorbic acid appears to be the advisable upper limit of dietary
intake.
108 Recommended Nutrient Intakes for Malaysia 2005
• Content of ascorbic acid in breast milk and complementary foods given to infants.
• Ascorbic acid content in a variety of foods especially cooked and processed fruits
and vegetables.
• Studies on health benefits of ascorbic acid in the occurrence of chronic diseases
and influence on ageing.
10.8 References
FAO/WHO (2002). Vitamin C. In: Human Vitamin and Mineral Requirements. Report of
a Joint FAO/WHO Expert Consultation. FAO, Rome; pp 73-86.
Hallberg L (1987) Wheat fiber, phytates and iron absorption. Scand J Gastroenterol
(Suppl) 129:73-79.
IOM (2000). Ascorbic acid. In: Dietary Reference Intakes for Ascorbic acid, Vitamin E,
Selenium, and Carotenoids. Food and Nutrition Board, Institute of Medicine. National
Academy Press, Washington DC; chapter 5, pp 95-185.
Ascorbic Acid (Vitamin C) 109
Levine M, Conry-Cantilena C, Wang Y, Welch RW, Washko PW, Dhariwal KR, Park JB,
Lazarev A & Graumlich JK (1996) Ascorbic acid pharmacokinetics in healthy
volunteers:evidence for a Recommended Dietary Allowance. Proc Natl Acad Sci 93:
3704-3709.
Levine M, Rumsey SC, Dhariwal KR, Park J & Wang Y (1999) Criteria and
recommendation for ascorbic acid intake. J Amer Med Assoc 281: 1415-1423.
Levine M., Dhariwal KR, Welch RW, Wang Y & Park JB (1995) Determination of
optimal ascorbic acid requirements in humans. Am J Clin Nutr 62: 1347S-56S
Sies H & Stahl W (1995) Vitamins E and C, beta-carotene, and other carotenoids as
antioxidants. Am J Clin Nutr 62: 1315S-1321S
Tee ES, Mohd Ismail N, Mohd Nasir A & Kahtijah I (1997). Nutrient composition of
Malayisan foods, 4th Edition, Malaysian Food Composition Database Programme,
Institute for Medical Research, Kuala Lumpur; 310 p.
Teoh ST (1975). Recommended daily dietary intakes for Peninsular Malaysia. Med J Mal
30: 38-42.
Weber P, Bendich A & Schalch (1996) Ascorbic acid and human health – a review of
recent data relevant to human requirements. Int J Vit Nutr Res 66:19-30.
110 Recommended Nutrient Intakes for Malaysia 2005
RDA
(mg/day)