F7-12. Determine the average normal stress developed in
rod AB if the load has a mass of 50 kg. The diameter of rod
ABis8 mm.
E7-12
9-5. The assembly consists of a steel rod CB and an
aluminum rod BA, each having a diameter of 12 mm. If the
rod is subjected to the axial loadings at A and al the coupling
B, determine the displacement of the coupling B and the end
A. The unstretched length of each segment is shown in the
figure. Neglect the size of the connections at B and C, and
assume that they are rigid. £, = 200 GPa, £,;= 70 GPa.
I8kN*11-48. The shaft is supported by a smooth thrust bearing
at A and smooth journal bearing at D. If the shaft has the
cross section shown, determine the absolute maximum
bending stress in the shaft.
10-11, The assembly consists of two sections of galvanized
steel pipe connected together using a reducing coupling at B.
‘The smaller pipe has an outer diameter of 0.75 in. and an inner
diameter of 0.68 in., whereas the larger pipe has an outer
diameter of | in. and an inner diameter of 0.86 in. If the pipe is
tightly secured to the wall at C, determine the maximum shear
stress developed in each section of the pipe when the couple
shown is applied to the handles of the wrench.