Professional Documents
Culture Documents
Problem 5-007 PDF
Problem 5-007 PDF
EXAMPLE 5-007
SOLID – HEMISPHERICAL DOME STRUCTURE WITH STATIC LOADS
PROBLEM DESCRIPTION
In this example, a hemispherical dome structure, modeled using solid objects, is
analyzed for the effects of four 2-kip edge point loads alternating in sign at 90°
intervals around the equator of the hemisphere. The deflections at the locations
where the point loads are applied, in the direction of the point loads, are
compared with published independent results.
The geometry, properties and loading are as suggested in MacNeal and Harder
1985. The 0.04-foot-thick hemispherical shell has a 10-foot radius. A hole is
introduced at the top of the hemisphere, as shown in the figure on the following
page, to avoid triangular elements at the top of the hemisphere.
The top and bottom edges of the hemisphere are free. As suggested in MacNeal
and Harder 1985, only a quarter of the hemispherical dome structure is modeled.
Symmetrical boundary conditions are imposed on the side edges of the quarter
hemisphere. Symmetry conditions are imposed by restraining all joints along
Edge 2 in the global Y direction and restraining all joints along Edge 4 in the
global X direction. The edges are identified in the following figure. A vertical
restraint is applied to a single joint at the center of Edge 1 to maintain stability of
the structure.
Two models are created to study this example. Model A uses a 16x16x1 mesh for
the quarter hemispherical dome structure. The solid object aspect ratio for this
model is approximately 25:20:1. Model B uses a 48x48x1 mesh, which has a
solid object aspect ratio of approximately 8:7:1.
EXAMPLE 5-007 - 1
Software Verification
PROGRAM NAME: SAP2000
REVISION NO.: 2
Material Properties 18 °
E = 68,250,000 k/ft2
ν = 0.3 Edge 3 - Free
G =26,250,000 k/ft2
Section Properties
Thickness = 0.04 ft
Ed
ge
4-
Sy
mm
ric
mmet
e tr
ic
2 - Sy
Radius
Z o
hemisp f
E d ge
here
10 '
Y
X
B
F = 2.0 kips
(1.0 kip on
hemispherical
quadrant)
A
F = 2.0 kips Edge 1 - Free
(1.0 kip on
hemispherical
quadrant)
EXAMPLE 5-007 - 2
Software Verification
PROGRAM NAME: SAP2000
REVISION NO.: 2
RESULTS COMPARISON
MacNeal and Harder 1985 indicates that the theoretical lower bound for the
displacement at the point load locations in the direction of the point load is
0.0924 foot for the condition where the hole at the center of the dome structure is
not present. The reference further suggests a value of 0.0940 foot for comparison
of results with the model where the center hole is present. The 0.0940 foot value
is used in the comparison.
The output is obtained at points A and B, which occur at the bottom corners of
the quarter of the hemispherical dome as shown in the previous figure.
Percent
Output Parameter Mesh SAP2000 Independent Difference
Ux (Point A) ft 16x16x1 0.0701 -25%
Average of two joints 0.0940
at Point A 48x48x1 0.0930 -1%
CONCLUSIONS
The SAP2000 results show an acceptable comparison with the independent
results when an adequate mesh is used.
EXAMPLE 5-007 - 3