Professional Documents
Culture Documents
Routing Pipe Runs in A Rotated Coordinate System: Objective
Routing Pipe Runs in A Rotated Coordinate System: Objective
Overview:
In this exercise you will be pipe runs using the Route Pipe command to route
Before you start placing the equipments define your workspace to show Unit U06.
3. Activate the PinPoint ribbon and set the active coordinate system to U06 CS on the PinPoint
ribbon.
4. Follow the Plan, Isometric and Side View Diagrams below and ensure that the following
parameters are utilized in order to complete this exercise.
Pipeline: 600-P
Name Rule: DefaultNameRule
Specifications: 1C0031
Nominal Diameter: 4”
5. To begin this exercise Create a 4 “Pipe Run and use the discharge Nozzle on Equipment C-
101B as your Start point.
Plan View
10’
2’ 6” CL Gate
Valve
Pipeline: 600-P
Name Rule:
DefaultNameRule
Specifications: 1C0031
Nominal Diameter: 4”
C-101A C-101B
15’
6’
6. After Placing the 15 ft Straight feature Continue routing Pipe and Connect directly to Nozzle
A on Vertical Vessel D-104 to complete this exercise.