AEP Model
UK Model
FM-AM PROGRAM RECEIVER
SPECIFICATIONS
GENERAL
jor Requirements: 240V ac, S0Hz(UK model)
120V, 220V or 240V se adjustable,
SOHZIAEP modell,
on: 210WIUK model
TBOWIAEP mode!)
Dimensions: Approx.410(w)x145ih)x310(d)mm
Blo 12 (inches
Including projecting ports and
controle
Weight: Approx.7.6ka,
‘Approx 8.89,
Power Consums
16 > 13.02 (net)
19 1b 7 02 (im shiping carton)
EM SECTION
Frequency Range: 87.5—108MHz
‘Antenna: 200 balanced
7810 unbalanced
Intermediate
Frequency: 10.7MHz
Sensitivity at
‘SOB Quieting: 3.5uV (10.748) (MONO)
45: (3908) (STEREO)
SAFETY-RELATED COMPONENT WARNING I!
COMPONENTS IDENTIFIED BY SHADING AND MARK
AVON THE SCHEMATIC DIAGRAMS, EXPLODED
VIEWS AND IN THE PARTS LIST ARE CRITICAL TO
SAFE OPERATION. REPLACE THESE COMPONENTS.
WITH SONY PARTS WHOSE PART NUMBERS APPEAR.
AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
‘2648 Quieting:
(ar 40k deviation)
Usable Sansitivity:
lat Okt deviation)
SIN Ratio:
Harmonie Distortion:
1M Distortion:
Separation:
Frequency Respons
44 (1248) (MONO)
S0uV (3448) (STEREO)
1.84V (608), IHF
1.5, (4a) S/N=2608
7528 (MONO)
70d8 (STEREO)
Av 100H2
0.2% (MONO)
0.2% (STEREO)
as thie
0:2 (MONO)
0.3% (STEREO)
At Okt
0.3% (MONO)
0.5% (STEREO)
0.2% (Mono)
013% (STEREO)
3008 at 100K
‘4508 at Vkhe
‘3548 st 10kHe
40-12, SoOHe"?348
30-16, oooHe 5a
Continued on page 2
SONY.
SERVICE MANUALSTR-313L
Selectivity
Capture Ratio:
AM Suppression Ratio:
Image Response Ratio:
IF Response Rat
‘Spurious Response Ratio:
[RF Intermodulation:
Mating Threshold
'SW/MAW/LW SECTION
Frequancy Range:
Antenna:
Intermediate
Frequency
Usable Sensitivity
SIN Ratio:
Harmonie Distortion:
Continuous RMS
Power Output:
AEP mods
SONY.
Sasa
6048 (400kH2)
4098 (S00kHe, S/N=2648, 40kH
Seviation)
1.038
s4aB
4508
9008
708
60u8
Approx. SuV
SW: 5.8-15.8mH2
MW: 830—1,605kH2
UW: 180—a8oKH2
'SWIMW: External antenna terminal
‘Attached antenna wire
LW: Buittin Ferritarod antenna
sternal antenna terminal
a68kH2
SW: 30qV (29,548),
xternel antenna (10MH2)
sw: Tout (4oas)
external antenna (9,000kH2)
LW: 0047 (53.848 /m
‘oO, aoa),
textornsl antenns (230KM2)
SwIMW: 5208 (SmV)
CW:'5208 (SOmV/ml
SWIM: 0.9% (5m, 400H2)
{W!0.35% (S0mVm, 4002)
2808 (Okie)
‘30a (Tok)
AUDIO AMPLIFIER SECTION
Less than 0.5% THD, both channels
fon simultaneously
‘At 20-20, 000He
2ow+20W (8 0)
as ike
2iwe27W (8.0)
According 0 DIN 45500
‘250+25W (3 0)
25W+250 1, Jess than
Os THD)
MODEL IDENTIFICATION
Rear Pane! —
IFW-AM PROGRAM RECEIVER]
woot. oSTR=313L
lenea Rance
nov
ade
SiRIAL NO
Dynamic Power Output: IMF constant power supply method
‘900 (8.2)
10-40, 000H2, IHF
20at TkHz @ 2)
Less than 0.5% at rated output 8.2)
Lee than 0.7% a rated output (422)
Power Bandwidth:
Damping Factor:
‘mone Distortion:
Less than 0.2% at output (8 2)
Les than 0.3% at Woutput (4.2)
IM Distortion: Less than 0.5% at rated output
(ole: PkHacart) Less than 0.2% at TW output
Residual Noise: Less then 0.084 (at 82)
Frequency Response: PHONO:
TIAA equalization curve +14
Tape!
rer or
(0-50, 000 Ha * 138
Inputs:
Sensitivity | impedance | sin | Wetahting |
PHONO| 2smv (sou) | soxn |7008| A |
Tare | 150mv (-15.56)| 100A [9068[ A |
Measured with rated output power into 822 loads
(both channels driven simultaneously) TkHe,
urputs:
(with rated input
Vottane Trmpedance
REC OUT [i5omv (-15598] _10KA
Headphones: Accepts ll low or high impedence
hheedphones
Speaker: 416.1 speakers are suitable
‘Tone Controls
BASS +28 at 100H2
TREBLE 848 at 1OkH?
+808 at 100H2
‘aaa at 1OKHe
Loudness Controt:
Tart 3008)
UK modi
[sox
|FM-am PROGRAM RECEIVER|
Moog woSTR-3I3L
SIRIAL NOSTR-313L
SECTION 1
OUTLINE
1.1, BLOCK DIAGRAM