Professional Documents
Culture Documents
Step 8 Select "Communication cable between two computer (COM1) then click Next
Note: Driver for Modem – Communication cable between two computers (COM1) or Tellabs Modem driver must
be install first before setup Dial-up connection
Step 9 Click Finish
Step 10 Open Network Connection folder - Sellect Tellabs6300 Dial-up then right click
select Properties
Step 10 At General Tab - Select Communication cable between two computers (COM1)
then click configure
Step 11 Set Maximum speed (bps) to 38400 and uncheck all boxes
Step 12 Options Tab - set the following
Step 13 Security Tab - Select Typical (recommended setting) and select Allow unsecured
password
Step 14 Networkng Tab - Select PPP: Windows95/98/NT4/2000, Internet
Click Setting
Step 19 When connection shows "connected" open Tellabs 6300 Craft Terminal