Professional Documents
Culture Documents
Diplodocus: Ronald Koh - 1995 C
Diplodocus: Ronald Koh - 1995 C
1. 2.
Begin with a square of between 15 and 20cm, Fold diagonally in half again, crease firmly,
with the white side faced up. Fold diagonally and unfold.
in half.
3. 4.
Separate the two vertical edges on the Turn the model over ...
right and squash fold.
5. 6.
7.
9. 10.
11.
13.
... then push in the centre where the diagonal creases Your model should now look
intersect and collapse the paper again along the like this. Turn model over.
existing mountain and valley fold lines.
16. 17.
21.
22. 23.
Separate and draw the diagonal edge of the first Fold as shown, crease firmly, and
layer of the flaps on each side towards the centre, unfold.
then fold the corners at the sides to meet the top
corner of each triangle.
24. 25.
Fold up the lower triangular ... then rabbit's ear fold ... like this. Now turn
flaps and rabbit's ear fold the the lower pieces ... the model over.
upper pieces ...
Fold the tip of the triangle to ... then fold this piece all the Fold the upper diagonal edges
the intersecting crease lines down from the horizontal to the centre, crease firmly, and
as shown .. mid-point of the model. unfold, then rotate the paper
clock wise through 90 degrees.
32. 33.
Fold and unfold on the left, as in Now bring the four diagonal edges to the
Step 31. centre as illustrated, Note the crimps in the
centre.
34.
35.
Fold the model horizontally in The four vertical pieces will form the legs.
half Fold down the two on this side and repeat at
the back.
36.
37.
38.
The point on the left will form the head
and neck. Reverse fold slightly below the
tip, then reverse fold again at the base of
the tail piece on the right.
39.
Mountain fold the both sides of
the neck within itself, then valley
fold both sides of the tail piece as
illustrated.
41. 42.
43.